L24305 service information

Service Information Category No Mazda Motor Corporation P.O.Box 18, Hiroshima 730-8670 Japan Ref No Literature L243/05 Coverage Page of Date issued Distributor only Please convey this information to your Warranty Dept October 28, 2005 Please inform your dealers Parts Dept Director Training Dept General Manager Attachment: Field Rep Applicable Model Applicable Country or Specification Australian specs Mazda6 MPS Subject: Additions/Corrections to Service Materials The additions and/or corrections have been made to the following service materials in response to engineering modifications and/or errors Attached are copies of the pages to be added or revised Please make copies of these sheets as necessary, and attach them to the applicable pages in each manual The material to be corrected is shown on the top of each page The additions and/or corrections are shown enclosed in broken lines or underlined on the revised page Applied Materials: Manual Name (Form No.) Mazda6 MPS Wiring Diagram (5659-1∗-05H) Page 20, 34, 38, 39, 46, 54, 60 Remarks FUEL PUMP RELAY, FUEL PUMP SPEED CONTROL RELAY ∗: Indicates the printing location A: Australia, 0: Japan Service Material Planning Group Vehicle Service & Program Department Form no L243/05 20 (CIRCUIT RELAY) STARTER RELAY (ST.RELAY) HORN RELAY (HORN RELAY) FUEL INJECTOR RELAY (INJ RELAY) FUEL PUMP RELAY FRONT SIDE CHECK CONNECTOR (FUEL PUMP RELAY) FUEL PUMP SPEED COTROL RELAY F-01 MAIN FUSE BLOCK FUSE BOX COOLING FAN RELAY (FAN RELAY) A/C RELAY (A/C RELAY) [(R.FOG RELAY)] REAR WINDOW DEFROSTER RELAY (DEFOG RELAY) B/Y B/LG 39 31 L/G G/Y G/Y R/L R/Y R/Y 27 28 29 30 Y 20 FUEL PUMP 30A 10 17 BLOWER 40A 19 16 BTN 40A INJ DRIVE 30A 15 IG KEY2 40A 14 DEFOG 40A 18 13 ABS 60A 12 FAN 30A 11 FAN 30A 30 29 MAG 10A 28 27 26 25 24 23 22 21 H/CLEAN 20A FOG 15A MAIN 120A IG KEY1 30A [P.WIND 30A] 21 22 37 38 39 HEAD HR 10A HEAD HL 10A HEAD LL 15A 40 36 [DRL 15A] HEAD LR 15A 35 M DEF 7.5A SPARE 20A SPARE 15A SPARE 10A TAIL 10A ILLUMI 10A 34 STOP 20A HAZARD 10A INJ 15A 33 ENG+B 10A ENG BB 5A (E) B/W B/W (E) 13 B/R B/Y W/R L/W ENG BAR 15A 31 G W/G [R/Y] B 34 LG/R 32 10 11 12 TNS RELAY (TAIL RELAY) BR/R 35 LG/B ETC 10A R/L W/B W/B G/W 24 23 R/G 25 26 HEADLIGHT RELAY (HEAD RELAY) (F) FRONT FOG LIGHT RELAY (FOG RELAY) DRIVE-BY-WIRE RELAY (ETC RELAY) G/B G/B 32 W 36 40 33 W/L W/G 37 38 B/Y MAIN RELAY (MAIN RELAY) B/R B/R B/L L/Y ( ) NAME INDICATED ON FUSE BOX COVER < > IF EQUIPPED [ ] NOT USED : VACANT L/B BR/B P Y/B L/O 14 15 16 17 18 19 20 00F-1 Mazda6 MPS Wiring Diagram (5659-1∗-05H) Revised 10/2005 (Ref No L243/05) B/R(E) F-01 D-01 DATA LINK CONNECTOR2(I) BATTERY 34 LG R L B/L B/Y W/R(F) B(F) LG/B(F) GY/R(F) LG(F) DSC HU/CM (SECTION 0415-b) D-02 CHECK CONNECTOR BTN 40A NOTE:SEEN FROM TERMINAL SIDE L/R MAIN FUSE BLOCK MAIN 120A DATA LINK CONNECTOR C-04 F-02 FUSE BLOCK ROOM 15A (SECTION 0114) D-02 CHECK CONNECTOR(F) BCM (SECTION 0940-c) FUEL PUMP RELAY Y/B(F) LG(F) W/R(I) LG(I) R(I) B/L(I) A B B/Y(I) B GY/R LG Y/B FRONT BCM (SECTION 0140-f) D-01 DATA LINK CONNECTOR2 CAN_L CAN_H NOTE:SEEN FROM TERMINAL SIDE GND J B/L(F) C-04 L(I) DOM KLN F/P L/R(I) : VACANT 00D Mazda6 MPS Wiring Diagram (5659-1∗-05H) Revised 10/2005 (Ref No L243/05) 38 CHECK CONNECTOR (SECTION 00D) 2A 12 13 B(R) P FUEL GAUGE SENDER UNIT FUEL PUMP UNIT 0940-01 BCM 2P LG 2O 2K 2I 2N 2L 2J R/W G/O G/W 2M 2H 2G (R) B BR 2F 2D BR B/R 2E NOTE:SEEN FROM TERMINAL SIDE FRONT Y/B Y/B R/Y Y/G 2B W/G W/R B/L B/W 5F #B 5E 5C 5B #BR #B/R R/Y 5D (I) Y/G 5A NOTE:SEEN FROM TERMINAL SIDE FRONT V/W(R) B/Y(F) B(F) 0114-04 R/Y(R) 0114-04 B/W(F) Y/G(R) 0940-01 G/R Y/G V/W B AN C-04 W/R(F) 0114-03 FUEL PUMP UNIT(R) FUEL GAUGE SENDER UNIT(SUB) B/L(F) 0114-02 (FUEL PUMP RELAY) FUEL PUMP SPEED CONTROL RELAY 0114-02 W/R(F) 0114-05 FUEL PUMP RESISTOR 0114-05 PCM 10 (SECTION 0140-e) W/R(F) B/W(F) W/G(F) FUEL PUMP SPEED CONTROL RELAY(F) 0114-03 FUEL PUMP 0114-03 G/R(R) C-06 G/R(F) 0114-01 (CIRCUIT RELAY) FUEL PUMP RELAY 0114-01 W/G(F) 0114-02 2C Y/B(F) Y/B(F) FUEL PUMP 30A IG KEY2 40A IG KEY1 30A FUEL PUMP RELAY(F) B/W W/R G/R MAIN 120A MAIN FUSE BLOCK PCM (SECTION 0140-h) B/R(E) F-01 0114-01 BATTERY FUEL SYSTEM 2B 2A M 0940-01 Y/G(I) R/Y(I) W/G(F) V/W R/Y 13 12 F-02 FUSE BLOCK OFF C-02 ACC MAIN RELAY (SECTION 0140-a) L(I) IG1 C-02 B1 INSTRUMENT CLUSTER (SECTION 0922-1b) 11 OFF B2 W/R W/G 0114-05 FUEL PUMP RESISTOR(F) IG2 ST ENGINE 15A IGNITION SWITCH 0114-04 FUEL GAUGE SENDER UNIT (SUB)(R) 5A 5B W/G(F) B/W(I) C-04 BCM B/R(F) W/G(F) B/Y(I) B(I) ( ) NAME INDICATED ON FUSE BOX COVER #: BOSE TYPE AUDIO : VACANT 0114 Mazda6 MPS Wiring Diagram (5659-1∗-05H) Revised 10/2005 (Ref No L243/05) 39 Revised 10/2005 (Ref No L243/05) 01 ENGINE 14 FUEL SYSTEM (F)-(I) [BLUE] C-04 C-06 (F)-(R) HARNESS SYMBOL : 0114-05 BCM (E) FUEL PUMP RESISTOR [BLACK] 0940-01 (F) (D) (R) [BLACK] FUEL PUMP UNIT 0114-03 13 12 FUEL GAUGE SENDER UNIT (SUB) [BLACK] 0114-04 FUSE BLOCK (REFER TO 00F SECTION) (REFER TO 00F SECTION) F-02 0114-02 C-04 FUEL PUMP SPEED CONTROL RELAY FUEL PUMP RELAY 0114-01 MAIN FUSE BLOCK F-01 [BLUE] (F)-(I) C-06 (F)-(R) C-02 IGNITION SWITCH 0114 Mazda6 MPS Wiring Diagram (5659-1∗-05H) 0140-01 PCM(F) 46 1V Y 3AA W 3X B 3W 3Z L 3V 3Y 1AA 1X 1W 1AD 1Z L/R G 1S F-01 1M 1J 1N 3P 1R 3M 1O GY O/L 1Q 3Q 3U 3R G/O P/L 3T 3J 1L 3K 3O 3L BR/B Y/L 3N 1H 3I Y/R 3H GY 3G P/B 1I G/Y W/G 1K R/W V/R BR/Y BR/B 3S 1U 1T 1G 3F R/L 3E W 3D 1F 1E W 1D B/L 1C P/L 1B L/W 1A L 3C Y/B 3B R/G 3A ENG BB 5A ENG BAR 15A INJ 15A 0140-35 MAIN RELAY (MAIN RELAY) 0140-35 ETC 10A MAIN FUSE BLOCK 1P IG KEY2 40A ENG+B 10A MAIN 120A IG KEY1 30A W BR/B R/Y GY/B LG/B Y/B 1Y B/R(E) G/B B/L 1AC Y/R 1AB BATTERY CONTROL SYSTEM 2AC 2AB 4AC 2AA 4Y W/B 2Z W 2Y W/G W/B 4AA B/L 4AD 4Z Y L 2R 4P O/L 2Q BR 2P 2O 2N 4U L/Y 4T 4R Y/B 4Q 4O W 2H 2L 4K GY 4J 2I 4I L/Y 4H P 4G 2F 4F 0140-01 W(F) 2Y B/W(F) B/W(I) 4A G 2C R/B 2B L/Y 2A 4C 4B 0140-35 MAIN RELAY(F) 0140-02 DRIVE-BY-WIRE RELAY(F) WASTEGATE CONTROL SOLENOID VALVE (SECTION 0140-k) COOLING FAN RELAY (SECTION 0112) 2AD B/R(F) M C-04 AN C-04 B/R(F) W/L(F) HO2S(FRONT) (SECTION 0140-c) R/G R/B 4E PCM 2Z EGR VALVE (SECTION 0140-g) 0140-02 DRIVE-BY-WIRE RELAY (ETC RELAY) 0140-02 4D R 2E B 2D GY/L Y/G 4L B/O L/O 4N R 2G 23 22 21 W(F) 1D 4V P(F) R/W BR/R 2K Y 4M G 2M W(F) W(F) 2J 3C L(F) W/L(F) 2X BR/Y B/L 4S R 2U G 2T 4X B/L 4X 4W P 4V B/Y 2X O 2W 2S G/B(F) G/B(F) L/B 2V 4AC L/W L/B 4AB B/R 2AD B/L 2AC B/L 2AB W(F) W/L(F) B/Y(F) (SECTION 0114) FUEL PUMP SPEED CONTROL RELAY 11 W/G(F) W/L(F) R/L(F) W/B(F) B/Y(F) B(F) R/L P 20 19 B/W(F) B/W(F) 18 OFF IGNITION SWITCH IGNITION COIL (SECTION 0140-b) FUEL INJECTOR RELAY (SECTION 0140-d) C-02 ACC L W/L CRANKSHAFT POSITION SENSOR (SECTION 0140-i) B/Y W/G NOTE:SEEN FROM TERMINAL SIDE FRONT IG1 17 L(I) OFF B1 C-02 ( ) NAME INDICATED ON FUSE BOX COVER : VACANT CAMSHAFT POSITION SENSOR (SECTION 0140-i) IG2 ST B2 NOTE:SEEN FROM TERMINAL SIDE FRONT W/L(F) W/L(F) 0140-01 F-02 FUSE BLOCK ENGINE 15A B/Y(I) B(I) 0140-a Mazda6 MPS Wiring Diagram (5659-1∗-05H) Revised 10/2005 (Ref No L243/05) 54 W/B 2AA 2AD B/R 2Z B/L W 2Y 2AC B/L 2AB B/Y 2X O 2W L/B 2V R 2U G 2T Y 2S L 2R O/L 2Q BR 2P 2O 2N G 2M 2F 2E B/L G/Y Y/B 2G R/L 2D Y/R 2C 0140-10 INJECTOR DRIVER MODULE(SHORT CORD) 2AC 2AB 0140-01 PCM(F) CONTROL SYSTEM 2H W 2G 2L R/B 2A 2I 2F R 2E B 2D 2B 2A G 2C R/B 2B L/Y 3K Y/L(F) R/B(F) 2B Y/L 2A R/B R/W BR/R Y/L 2B R 2K 2J 0140-01 0140-10 Y 3AA L 3Z 3Y W 3X B 3W 3V 3P 3M 3J 3E 3G R/L(F) R/L 2D 3Q 3U 3R G/O P/L 3T 3K 3O 3L BR/B Y/L 3N 3I Y/R 3H R/W V/R BR/Y BR/B GY 3S 3H Y/R(F) Y/R 2C INJECTOR DRIVER MODULE 3F R/L 3E W 3D PCM L 3C Y/B 3B R/G 3A 3B Y/B(F) C-28 Y/B 2E 4AC 4Y W/G W/B 4AA B/L 4AD 4Z 4AC L/W L/B 4AB 4X B/L 4X 4W P 4V 3N BR/B(F) 26 4U L/Y 4T 4P 4R Y/B 4Q BR/Y B/L 4S FUEL INJECTOR RELAY (SECTION 0140-d) Y 4M 4K GY 4J 4O 4I L/Y 4H P 4G GY/L Y/G 4L B/O L/O 4N 4F 4E 4A 4C 4B R/G R/B 4D 4P B/L(F) 10 (SECTION 0114) FUEL PUMP SPEED CONTROL RELAY : VACANT 0140-e Mazda6 MPS Wiring Diagram (5659-1∗-05H) Revised 10/2005 (Ref No L243/05) 0140-01 PCM(F) 60 1V 1AA 1X 1W 1AD 1Z L/R G 1S 1P 1M 1J 1U 1T 1N 1R 1O GY O/L 1Q 1H 1G 1L P/B 1I G/Y W/G 1K W BR/B R/Y GY/B LG/B Y/B 1Y G/B B/L 1AC Y/R 1AB 1F 1E W 1D MAIN RELAY 30 (SECTION 0140-g) CONTROL SYSTEM B/L 1C P/L 1B L/W 1A 4S 4Y W/G W/B 4AA B/L 4AD 4Z 4AC L/W L/B 4AB P 4X B/L 4X 4W 4U L/Y 4T 4P 4R Y/B 4Q BR/Y B/L 4S 0140-20 E 4V W(F) C-08 W(E) OIL CONTROL VALVE 0140-20 BR/Y(E) F BR/Y(F) C-08 0140-01 4Q 4M Y 4J GY 4K 4O 4I L/Y 4H P 4G GY/L Y/G 4L B/O L/O 4N B(F) 4F 4E 4C 4B R/G R/B 4A 0140-21 W(F) B G/B B/R C-10 W BR/Y 0140-22 O/L B/W 0140-21 VARIABLE SWIRL SHUTTER VALVE SWITCH(F) VARIABLE SWIRL SOLENOID VALVE 0140-22 C-10 L/O(F) 4K 4L GY/L(F) COOLING FAN RELAY (SECTION 0112) 0140-20 OIL CONTROL VALVE(E) VARIABLE SWIRL SHUTTER VALVE SWITCH 0140-21 4A 4D B/W(F) O/L(F) 1N PCM R/B(F) Y/B(F) 4AC W(F) 0140-01 FAN CONTROL MODULE (SECTION 0112) (SECTION 0114) FUEL PUMP RELAY B/R G/B 0140-22 VARIABLE SWIRL SOLENOID VALVE(SHORT CORD) : VACANT 0140-h Mazda6 MPS Wiring Diagram (5659-1∗-05H) Revised 10/2005 (Ref No L243/05)