toyota camry factory service repair manual 2000

... Special Service Materials SST Special Service Tools STD Standard STJ Cold-Start Fuel Injection SW Switch SYS System T/A Transaxle T/M Transmission TACH Tachometer TAM P.T TOYOTA- Astra Motor TASA TOYOTA ... Dead Center TDV TOYOTA de Venezuela C.A TEMP Temperature TEMS TOYOTA Electronic Modulated Suspension TFT TOYOTA Free-Tronic TIS Total Information System For Vehicle Development TKM TOYOTA Kirloskar ... Motor Ltd TMC TOYOTA Motor Corporation TMMIN PT TOYOTA Motor Manufacturing Indonesia IN–45 INTRODUCTION – TERMS ABBREVIATIONS TMMK MEANING TOYOTA Motor Manufacturing Kentucky, Inc TMP TOYOTA Motor

Ngày tải lên: 17/11/2023, 15:59

... Check the owner's manual supplement in which the maintenance schedule is shown • Every service item in the periodic maintenance schedule must be performed • Periodic maintenance service must be ... Check the maintenance schedule in the owner's manual supplement • Following the maintenance schedule is mandatory • Determine the appropriate time to service the vehicle using either miles driven ... Check the maintenance schedule in the owner's manual supplement • Following the maintenance schedule is mandatory • Determine the appropriate time to service the vehicle using either miles driven

Ngày tải lên: 17/11/2023, 16:18

... SUB-ASSEMBLY (for Manual Transmission) (See page EM-79) 29 INSTALL CLUTCH DISC ASSEMBLY (for Manual Transmission) Transmission See page R155 CL-32 R155F CL-37 30 INSTALL CLUTCH COVER ASSEMBLY (for Manual ... ASSEMBLY (See page EM-98) 32 INSTALL AUTOMATIC TRANSMISSION ASSEMBLY (See page AT-113) 33 INSTALL MANUAL TRANSMISSION UNIT ASSEMBLY Transmission See page R155 MT-9 R155F MT-11 34 INSTALL EXHAUST

Ngày tải lên: 17/11/2023, 16:26

... body and cylinder head will allow air suction and cause the engine to run improperly If necessary, repair the engine assembly EC EC–8 2TR-FE EMISSION CONTROL – EMISSION CONTROL SYSTEM Pressure Gauge ... air can flow freely into the air inlet line If air cannot flow freely into the air inlet line, repair or replace it (c) Reconnect the air inlet line hose to the charcoal canister 2TR-FE EMISSION ... body and cylinder head will allow air suction and cause the engine to run improperly If necessary, repair the engine assembly 1GR-FE EMISSION CONTROL – EMISSION CONTROL SYSTEM Pressure Gauge G036150E01

Ngày tải lên: 17/11/2023, 16:41

... combination of low phosphates and organic acids.) • New Toyota vehicles are filled with Toyota Super Long Life Coolant When replacing the coolant, Toyota Super Long Life Coolant (color is pink, premixed ... improper coolants may damage the engine cooling system CO CO–4 2TR-FE COOLING – COOLANT • Use only Toyota Super Long Life Coolant or similar high quality ethylene glycol based nonsilicate, non-amine, ... tank is between the FULL and LOW lines when the engine is cold If low, check for leakage and add Toyota Super Long Life Coolant or similar high quality ethylene glycol based non-silicate, non-amine,

Ngày tải lên: 17/11/2023, 16:46

... EM-93) 29 REMOVE CLUTCH COVER ASSEMBLY (for Manual Transmission) Transmission See page R155 CL-30 R155F CL-35 30 REMOVE CLUTCH DISC ASSEMBLY (for Manual Transmission) Transmission See page R155 ... LU–20 2TR-FE LUBRICATION – OIL PUMP 25 REMOVE EXHAUST PIPE ASSEMBLY FRONT (See page EX-2) 26 REMOVE MANUAL TRANSMISSION UNIT ASSEMBLY Transmission See page R155 MT-6 R155F MT-8 27 REMOVE AUTOMATIC ... Transmission) Transmission See page R155 CL-30 R155F CL-35 31 REMOVE FLYWHEEL SUB-ASSEMBLY (for Manual Transmission) (See page EM-77) 32 REMOVE DRIVE PLATE & RING GEAR SUBASSEMBLY (for Automatic

Ngày tải lên: 17/11/2023, 16:53

... Check that the wiring between VVT sensor and ECM Result Result Proceed to NG Repair wiring between VVT sensor and ECM OK Repair VVT sensor (5) Check resistance in crankshaft position sensor Standard ... sensor OK Go to next step (6) Check IGT signal from ECM Result Result Proceed to NG Check ECM OK Repair wiring between ignition coil and ECM (d) Using a 16 mm plug wrench, install the spark plugs ... sensor OK Go to next step (6) Check IGT signal from ECM Result IG Result Proceed to NG Check ECM OK Repair wiring between ignition coil and ECM (d) Using a 16 mm plug wrench, install the spark plug

Ngày tải lên: 17/11/2023, 17:12

... illustration Indicator Blue White Ready White Charging Necessary Red Have battery checked by your Toyota dealer INSPECT BATTERY TERMINALS, FUSIBLE LINK AND FUSES (a) Visually check the battery terminals ... the ammeter Standard: 30 A or more • If the ammeter reading is less than the standard amperage, repair the generator • If the battery is fully charged, the indication will sometimes be less than ... the ammeter Standard: 30 A or more • If the ammeter reading is less than the standard amperage, repair the generator • If the battery is fully charged, the indication will sometimes be less than

Ngày tải lên: 17/11/2023, 17:25

... Spline grease Release hub grease C114215E01 CLUTCH – CLUTCH UNIT (for RA60) CL–41 REMOVAL REMOVE MANUAL TRANSMISSION UNIT ASSEMBLY (See page MT-7) REMOVE CLUTCH RELEASE FORK SUB-ASSEMBLY (a) Remove ... installation, move the fork forward and backward to check that the release bearing slides smoothly INSTALL MANUAL TRANSMISSION UNIT ASSEMBLY (See page MT-9) F050793 Release hub grease INSPECT AND ADJUST ... Spline grease Release hub grease C114215E01 CLUTCH – CLUTCH UNIT (for RA60F) CL–45 REMOVAL REMOVE MANUAL TRANSMISSION UNIT ASSEMBLY (See page MT-6) REMOVE CLUTCH RELEASE FORK SUB-ASSEMBLY (a) Remove

Ngày tải lên: 20/11/2023, 10:40

... MT–48 R155 MANUAL TRANSMISSION – INPUT SHAFT INPUT SHAFT R155 MANUAL TRANSMISSION TRANSMISSION COMPONENTS MT INPUT SHAFT BEARING NO ... shaft R155 MANUAL TRANSMISSION – INPUT SHAFT D026113 MT–51 INSTALL NO SYNCHRONIZER RING (a) Apply gear oil to synchronizer ring No 2, and install it onto the input shaft MT MT–52 R155 MANUAL TRANSMISSION ... greater than the maximum, replace the 2nd gear with a new one D026066 D026067 MT R155 MANUAL TRANSMISSION – MANUAL TRANSMISSION UNIT MT–33 INSTALL COUNTER GEAR (a) Provisionally install the counter

Ngày tải lên: 20/11/2023, 10:44

... Remove the bolts and remove the transfer case lower protector REMOVE MANUAL TRANSMISSION ASSEMBLY (for R155F) (See page MT-8) REMOVE MANUAL TRANSMISSION ASSEMBLY (for RA60F) (See page MT-6) REMOVE ... Q007289 37 REMOVE TRANSFER INPUT GEAR STOPPER 38 REMOVE TRANSFER INPUT GEAR STOPPER BALL 39 REMOVE MANUAL TRANSFER PLANETARY CARRIER WASHER G038881 40 REMOVE TRANSFER INPUT SHAFT 41 REMOVE TRANSFER ... PLANETARY RING GEAR HOLE SNAP RING TRANSFER LOW PLANETARY GEAR SPLINE PIECE LOW PLANETARY GEAR ASSEMBLY MANUAL TRANSFER PLANETARY CARRIER WASHER TRANSFER INPUT GEAR STOPPER BALL TRANSFER INPUT GEAR STOPPER

Ngày tải lên: 20/11/2023, 10:49

... to another vehicle, the problem may be in the tester itself Consult the Service Department listed in the tester operator's manual C122885 DIAGNOSIS SYSTEM (a) Warning light (1) When there is a ... pressure warning light blinks at 0.5 second intervals (1Hz) NOTICE: When the malfunction has been repaired, the tire pressure warning light does not come on (b) Normal mode (1) DTCs are stored in ... TIRE AND WHEEL – TIRE PRESSURE WARNING ECU for Automatic Transmission on Separate Seat Type : for Manual Transmission on Separate Seat Type: INSTRUMENT PANEL CUP HOLDER TRAY SHIFT KNOB SHIFT KNOB

Ngày tải lên: 20/11/2023, 11:07

... STEERING COLUMN – STEERING SYSTEM SR–3 REPAIR Steering Wheel Masking Tape Steering Column Upper Cover STEERING OFF CENTER REPAIR PROCEDURE (a) Inspect steering wheel off center ... (Supplemental Restraint System) such as the driver airbag and front passenger airbag Failure to carry out service operations in the correct sequence could cause the SRS to unexpectedly deploy during servicing ... the ranked order of probability of each of the possible causes Check each part in the order shown Repair or replace the parts as necessary STEERING SYSTEM Symptom Hard steering Poor return Excessive

Ngày tải lên: 20/11/2023, 11:17

... Connect terminals and of the pressure switch connector on the vehicle wire harness side using a service wire (3) Start the engine (4) Turn the air conditioning switch on and check that the magnet ... Magnet clutch is OFF Replace the pressure switch if the magnet clutch operates normally Inspect and repair the wire harness between the pressure switch and the ECM AC–87 AIR CONDITIONING – MAGNETIC

Ngày tải lên: 20/11/2023, 11:27

... Inspection with intelligent tester (ACTIVE TEST) (b) Terminals of ECU (see page EI-13) NEXT ADJUST, REPAIR OR REPLACE NEXT NEXT END EI CONFIRMATION TEST EI–6 ENGINE IMMOBILISER – ENGINE IMMOBILISER ... (d) Reconnect the ECU connector (e) Reconnect the amplifier connector VC5 CODE NG TXCT B087953E03 REPAIR OR REPLACE HARNESS OR CONNECTOR OK REPLACE TRANSPONDER KEY AMPLIFIER (OPERATION) (a) After ... T9-4 (CODE) Below 1Ω (d) Reconnect the ECU connector (e) Reconnect the amplifier connector CODE NG REPAIR OR REPLACE HARNESS OR CONNECTOR Transuponder Key Amplifier T9 CODE B087953E04 OK REPLACE

Ngày tải lên: 20/11/2023, 13:34

... the high speed limit (h) 'RES' function If the cruise control operation was canceled under the manual cancel condition (other than by turning cruise control main switch ON-OFF button off), and ... speed returns to over the low speed limit, since the stored vehicle speed remains in the memory (i) MANUAL CANSEL function The ECM cancels the cruise control while driving under the following conditions: ... TABLE NEXT CIRCUIT INSPECTION* NEXT 10 TERMINALS OF ECU NEXT 11 IDENTIFICATION OF PROBLEM NEXT 12 REPAIR OR REPLACE NEXT 13 CONFIRMATION TEST* NEXT END CC CC–8 CRUISE CONTROL – CRUISE CONTROL SYSTEM

Ngày tải lên: 20/11/2023, 13:49

... (for Manual Transmission on Separate Seat Type) (See page IP11) 32 REMOVE FRONT CONSOLE BOX (for Automatic Transmission on Bench Seat Type) (See page IP-11) 33 REMOVE FRONT CONSOLE BOX (for Manual ... ASSEMBLY REPAIR HINT: • Use the same procedures for the RH and LH • The procedures listed below are for the LH side • If the area where the headlight unit LH is installed is damaged, the repairs ... BULB REPLACEMENT (a) If even a thin film of oil is left on the surface of the halogen light, its service life will be shortened because the light will burn at a higher temperature (b) Handle any

Ngày tải lên: 20/11/2023, 13:52

... using the key • UNLOCK on the door control switch (manual operation) is pushed after the door control knob is turned to the UNLOCK position manually • The doors are unlocked with wireless operation ... harness Unlock warning switch assembly Key lock-on prevention function does not work properly (manual operation and key-linked lock are available) Front door courtesy light switch assembly (driver ... CHECK ELECTRICAL DOOR LOCK OPERATION (a) Check the basic function (1) The door control switch (manual operation): 1) pushing LOCK locks all the doors and 2) pushing UNLOCK unlocks all the doors

Ngày tải lên: 20/11/2023, 14:14

... (R1-15) Below Ω TX+ (R1-5) - Body ground 10 kΩ or higher TX+ (R1-5) - Body ground 10 kΩ or higher REPAIR OR REPLACE HARNESS OR CONNECTOR Stereo Component Amplifier Assembly Wire Harness View: S23 ... GND (R1-20) Constant Below 1Ω ACC (R1-11) - GND (R120) Ignition switch ACC or ON 10 to 14 V NG REPAIR OR REPLACE HARNESS OR CONNECTOR OK PROCEED TO NEXT CIRCUIT INSPECTION SHOWN IN PROBLEM SYMPTOMS ... (S24-10) - GND (S2415) Always 10 to 14 V ACC (S23-12) - GND (S2415) Ignition switch ACC 10 to 14 V NG REPAIR OR REPLACE HARNESS OR CONNECTOR (STEREO COMPONENT AMPLIFIER ASSEMBLY - BATTERY OR BODY GROUND)

Ngày tải lên: 20/11/2023, 14:40

... FRONT SEAT ASSEMBLY (for Separate Folding Seat Type) SE–19 INSTALLATION CAUTION: Some of these service operations affect the SRS airbag system Read the precautionary notices concerning the SRS ... – FRONT SEAT ASSEMBLY (for Separate Seat Type Driver Side) SE–23 REMOVAL CAUTION: Some of these service operations affect the SRS airbag system Read the precautionary notices concerning the SRS ... SEAT – FRONT SEAT ASSEMBLY (for Separate Folding Seat Type) SE–5 REMOVAL CAUTION: Some of these service operations affect the SRS airbag system Read the precautionary notices concerning the SRS

Ngày tải lên: 20/11/2023, 15:37