2000 toyota camry repair manual download

... sure to read the following item carefully, then follow the correct procedure described in the repair manual. AC0LI–02 N20242 Sight Glass –AIR CONDITIONING AIR CONDITIONING SYSTEM AC–3 2485AuthorĂ: ... detector and repair if neces- sary (2) Charge proper amount of re- frigerant (3) If indicated pressure value is near 0 when connected to gauge, create the vacuum after inspecting and repairing the ... Bubbles present in sight glass Insufficient* (1) Check for gas leakage with gas leak de- tector and repair if necessary (2) Add refrigerant until bubbles disappear 2 No bubbles present in sight glass

Ngày tải lên: 28/04/2014, 12:52

... kgf·cm, 7 ft·lbf) 18. INSTALL MANUAL VALVE BODY DETENT SPRING AND MANUAL VALVE BODY (a) Align the manual valve with the pin on the manual shaft lever. (b) Lower the manual valve body into place. ... (non–magnetic): bushing wear 4. REMOVE MANUAL VALVE BODY DETENT SPRING AND MANUAL VALVE BODY (a) Remove the detent spring on the manual valve body. (b) Remove the manual valve body. 5. REMOVE OIL STRAINER ... ft·lbf) (d) Place the detent spring on the manual valve body and temporarily install the 2 bolts first. Torque: 10 N·m (100 kgf·cm, 7 ft·lbf) (e) Check that the manual valve lever is touching the center

Ngày tải lên: 28/04/2014, 12:53

... CONNECT TOYOTA HAND–HELD TESTER OR OBDII SCAN TOOL Remove the fuse cover on the instrument panel Connect a TOYOTA hand–held tester or OBDII scan tool to the DLC3 Please refer to the TOYOTA hand–held ... CONNECT TOYOTA HAND–HELD TESTER OR OBDII SCAN TOOL (a) Remove the fuse cover on the instrument panel (b) Connect a TOYOTA hand–held tester or OBDII scan tool to the DLC3 (c) Please refer to the TOYOTA ... timing mark moves in a range between 0° and 10° DISCONNECT TIMING LIGHT FROM ENGINE DISCONNECT TOYOTA HAND–HELD TESTER OR OBDII SCAN TOOL AuthorĂ: DateĂ: 1181 EM–10 ENGINE MECHANICAL (5S–FE)

Ngày tải lên: 28/04/2014, 13:24

... (370, 27) –MANUAL TRANSAXLE (E153) MANUAL TRANSAXLE UNIT MX–3 1804A uthorĂ: DateĂ: MANUAL TRANSAXLE UNIT COMPONENTS MX050–01 Q09982 Q09983 Q09984 Q09985 MX–4 –MANUAL TRANSAXLE (E153) MANUAL TRANSAXLE ... Pipe MX–10 –MANUAL TRANSAXLE (E153) MANUAL TRANSAXLE ASSEMBLY 1811A uthorĂ: DateĂ: MANUAL TRANSAXLE ASSEMBLY COMPONENTS [...]... AuthorĂ: DateĂ: 1822 MX–22 MANUAL TRANSAXLE (E153) – MANUAL ... MX04X–01 –MANUAL TRANSAXLE (E153) MANUAL TRANSAXLE SYSTEM MX–1 1802A uthorĂ: DateĂ: MANUAL TRANSAXLE SYSTEM PRECAUTION When working with FIPG material,

Ngày tải lên: 28/04/2014, 13:27

... (1MZ–FE) EMISSION CONTROL... PP–18 PREPARATION – SFI (5S–FE) PP0JX–04 RECOMMENDED TOOLS 09082–00040 TOYOTA Electrical Tester 09258–00030 Hose Plug Set Plug for vacuum hose, fuel hose etc AuthorĂ: ... Tool Set 09231–14010 Punch AuthorĂ: DateĂ: 76 PP–25 PREPARATION – COOLING (5S–FE) PP0K0–03... ”Toyota Long Life Coolant” or equivalent DateĂ: 79 PP–28 PREPARATION – COOLING (1MZ–FE) COOLING ... AuthorĂ: DateĂ: 80 PP–29 PREPARATION – COOLING (1MZ–FE) PP0C1–03 RECOMMENDED TOOLS 09082–00040 TOYOTA Electrical Tester AuthorĂ: DateĂ: 81 PP–30 PREPARATION – COOLING (1MZ–FE) PP0C2–02 EQUIPMENT

Ngày tải lên: 28/04/2014, 13:31

... sure to read the following items carefully, then follow the correct procedures described in the repair manual F Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most ... up power supply from outside the vehicle F Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs F Do not expose the steering wheel pad, front ... from another vehicle When replacing parts, replace them with new parts F Never disassemble and repair the steering wheel pad, front passenger airbag assembly, side airbag assembly, airbag sensor

Ngày tải lên: 28/04/2014, 13:32

... the active test mode on the TOYOTA hand– held tester. (4) Please refer to the TOYOTA hand–held tester oper- ator’s manual for further details. (5) If you have no TOYOTA hand–held tester, connect ... Select the ACTIVE TEST mode on the TOYOTA hand– held tester. (d) Please refer to the TOYOTA hand–held tester operator’s manual for further details. (e) If you have no TOYOTA hand–held tester, connect ... the TOYOTA hand– held tester (j) Please refer to the TOYOTA hand–held tester operator’s manual for further details AuthorĂ: DateĂ: 1456 SF–24 SFI (5S–FE) (k) – INJECTOR If you have no TOYOTA

Ngày tải lên: 28/04/2014, 13:35

... Painting Procedures Fundamental Body Repair Procedures Electrical Wiring Diagram (Ex USA and Canada) (USA and Canada) CAMRY Chassis and Body Repair Manual CAMRY Repair Manual (USA and Canada) 36438E ... specifications and repair procedures other than collision-damaged body components of the TOYOTA CAMRY, refer to the following repair manuals. All information contained in this manual is the most ... Trang 1Manual Name Pub No.1S, 1S-E, 2S, 2S-C, 2S-E, 3S-FE & 3S-GE Engine Repair Manual (Ex USA and Canada) 1C, 2C & 2C-T Engine Repair Manual (Ex USA and Canada) Fundamental

Ngày tải lên: 29/04/2014, 08:46

... listed in this manual, refer to the following manuals; Manual Name Pub. No. S1990 Camry Repair Manual Volume 1 Volume 2 STCCS (3S–FE) Diagnosis Manual SECT (A140E) Diagnosis Manual SECT (A540E) ... diagram manual has been prepared to provide information on the electrical system of the 1990 TOYOTA CAMRY. Applicable models: SV21, 25 series VZV21 series For service specifications and repair ... change without notice. TOYOTA MOTOR CORPORATION 2 INTRODUCTION This manual consists of the following 12 sections: No. Section Description 1 INDEX Index of the contents of this manual. 2 INTRODUCTION

Ngày tải lên: 29/04/2014, 08:54

... compressed air NOTICE: Never use water to clean the evaporator CHECK FITTINGS FOR CRACKS OR SCRATCHES Repair as necessary ASSEMBLY OF COOLING UNIT INSTALL COMPONENTS ON EVAPORATOR (a) Connect the expansion ... compressed air NOTICE: Never use water to clean the evaporator CHECK FITTINGS FOR CRACKS OR SCRATCHES Repair as necessary ASSEMBLY OF COOLING UNIT INSTALL COMPONENTS ON EVAPORATOR (a) Connect the expansion ... that there is no continuity between each terminal and the VSV body If a short circuit is found, repair or replace the VSV CHECK FOR OPEN CIRCUIT Using an ohmmeter, measure the resistance between

Ngày tải lên: 29/04/2014, 09:07

... motor Check switch Repair as necessary Wipers do not operate i n... Wiper motor faulty Wiring or ground faulty Washers do not operate Check relay Check switch Check motor Repair as necessary ... faulty Wiring faulty BE–3 BE–28 BE–26 BE–3 BE–29 BE–29 BE–26 BE–28 BE–26 Repair as necessary Replace motor Check switch Repair as necessary BE–29 BE–29 BE–29 BE–29 Front Wiper and Washer Switch ... HINT: Specifications may vary depending on the type of tester, so refer to the tester’s instruction manual before per- forming the inspection. Check LED (Light Emitting Diode) in the same manner as

Ngày tải lên: 29/04/2014, 09:47

... Replace brake shoes Replace pads Repair leak Repair or replace master cylinder Bleed brake system Repair wheel cylinder Repair cylinder Repair brake cylinder Repair or replace adjuster Air in ... Replace brake shoes Replace pads Repair leak Repair or replace master cylinder Bleed brake system Repair wheel cylinder Repair cylinder Repair brake cylinder Repair or replace adjuster Air in ... brake Repair as necessary Adjust push rod Replace spring Repair as necessary Replace shoe Replace pad Repair as necessary Replace pads Replace drum or disc Replace spring Repair wheel cylinder Repair

Ngày tải lên: 29/04/2014, 09:55

... alternator faulty Wiring faulty Adjust or replace drive belt Repair or replace cables Check ”ENGINE” fuse Replace fusible link Check charging system Repair wiring Check ”CHARGE” and ”IGN” fuses Replace ... alternator faulty Wiring faulty Adjust or replace drive belt Repair or replace cables Check ”ENGINE” fuse Replace fusible link Check charging system Repair wiring Check ”CHARGE” and ”IGN” fuses Replace ... ammeter. Standard amperage: 30 A or more If the ammeter reading is less than standard amperage, repair the alternator. (See page CH–6) HINT: With the battery fully charged, the indication will

Ngày tải lên: 29/04/2014, 09:57

... Bleed clutch system Repair release cylinder Repair master cylinder Loose part inside housing Release bearing worn or dirty Repair as necessary Replace clutch cover TROUBLESHOOTING Repair as necessary ... disc Replace clutch cover Align clutch diaphragm spring Repair as necessary Adjust pedal freeplay Bleed clutch system Repair release cylinder Repair master cylinder Inspect clutch disc Air in clutch ... bearing assembly together with the fork, and then separate them (b) Remove the boot INSPECTION AND REPAIR OF CLUTCH PARTS 1 INSPECT CLUTCH DISC FOR WEAR OR DAMAGE Using calipers, measure the rivet

Ngày tải lên: 29/04/2014, 09:57

... Replace hose Replace water pump Check radiator and cap Repair as necessary TROUBLESHOOTING CO–12, 13 IG–17, 20 CO–20, 22 Clean radiator or condenser Repair as necessary Engine overheats Possible cause ... Replace hose Replace water pump Check radiator and cap Repair as necessary TROUBLESHOOTING CO–12, 13 IG–17, 20 CO–20, 22 Clean radiator or condenser Repair as necessary Engine overheats Possible cause ... Water leakage will result if the bottom of the core plate groove is damaged or dented Therefore, repair or replace if necessary CO–18 COOLING SYSTEM – Radiator 3 INSTALL TANK Install a new

Ngày tải lên: 29/04/2014, 10:00

... item to be repaired. At the beginning of each section, PRECAUTIONS are given that pertain to all repair operations contained in that section. Read these precautions before starting any repair task. ... problem and find the cause. The repair for each possible cause is referenced in the remedy column to quickly lead you to the solution. REPAIR PROCEDURES Most repair operations begin with an overview ... model year full–time 4WD Camry is equipped with two types of transaxle – either the manual transaxle or the automatic transaxle The center differential system of the manual transaxle is the

Ngày tải lên: 29/04/2014, 10:09

... Crankshaft bearing faulty Connecting rod bearing faulty Oil filter clogged Repair as necessary Repair relief valve Repair oil pump Replace engine oil Replace bearing Replace bearing Replace oil ... LU–9,16 LU–7 EM–116, 149 EM–114, 147 LU–7 TROUBLESHOOTING Repair as necessary Replace oil seal EM–125, 160 LU–13 Relief valve faulty Repair relief valveHigh oil pressure Low oil pressure Replace ... CROSSMEMBER 7. REMOVE ENGINE MOUNTING CENTER MEMBER OIL PUMP (3S–FE) REMOVAL OF OIL PUMP HINT: When repairing the oil pump, the oil pan and strainer should be removed and cleaned. –LUBRICATION SYSTEM

Ngày tải lên: 29/04/2014, 10:10

... DIFFERENTIAL OIL (FLUID) A (M/T) Check manual transaxle oil (fluid) (a)Visually check the transaxle for oil (fluid) leakage If leakage is found, check for cause and repair (b) Remove the filler plug ... SCHEDULE A. Service interval (Odometer reading or months, whichever comes first) Maintenance items Manual transaxle, automatic transaxle and differential (3) Brake pads and discs (Front and rear ... schedule. Service interval (Odometer reading or months, whichever comes first) Maintenance items Manual transaxle, automatic transaxle and differential Brake pads and discs (Front and rear) Bolts

Ngày tải lên: 29/04/2014, 10:11

... the repair procedures and specifications other than collisiondamaged body components of the TOYOTA CAMRY refer to the repair manuals If you require the above manuals, please contact your TOYOTA ... FOREWORD This repair manual has been prepared to provide essential information on body panel repair methods (including cutting and welding operations, but excluding painting) for the TOYOTA CAMRY Applicable ... Gloves INTRODUCTION IN-2 PRECAUTIONS FOR REPAIRING BODY STRUCTURE PANELS Toyota prohibits the use of the heat repair method on body structure panels when repairing a vehicle damaged in a collision

Ngày tải lên: 24/05/2014, 13:18

... (Worn or damaged) MX-40 - MX-79 - MX-89 MX–2 E351 MANUAL TRANSAXLE – MANUAL TRANSAXLE OIL MX MANUAL TRANSAXLE OIL ON-VEHICLE INSPECTION 1. INSPECT MANUAL TRANSAXLE OIL (a) Stop the vehicle on a ... ABS SPEED SENSOR SIGNAL See page BC-11 MX MX–33 E351 MANUAL TRANSAXLE – MANUAL TRANSAXLE UNIT MANUAL TRANSAXLE UNIT E351 MANUAL TRANSAXLE TRANSMISSION COMPONENTS 5.5 (56, 48 ... bolts, clutch line and bracket C132979 E351 MANUAL TRANSAXLE – MANUAL TRANSAXLE ASSEMBLY MX–17 MANUAL TRANSAXLE ASSEMBLY E351 MANUAL TRANSAXLE TRANSMISSION COMPONENTS FRONT

Ngày tải lên: 24/05/2014, 13:31