Tài liệu hạn chế xem trước, để xem đầy đủ mời bạn chọn Tải xuống
1
/ 104 trang
THÔNG TIN TÀI LIỆU
Thông tin cơ bản
Định dạng
Số trang
104
Dung lượng
9,88 MB
Nội dung
W970SUW Preface Notebook Computer W970SUW Service Manual Preface I Preface Notice The company reserves the right to revise this publication or to change its contents without notice Information contained herein is for reference only and does not constitute a commitment on the part of the manufacturer or any subsequent vendor They assume no responsibility or liability for any errors or inaccuracies that may appear in this publication nor are they in anyway responsible for any loss or damage resulting from the use (or misuse) of this publication This publication and any accompanying software may not, in whole or in part, be reproduced, translated, transmitted or reduced to any machine readable form without prior consent from the vendor, manufacturer or creators of this publication, except for copies kept by the user for backup purposes Preface Brand and product names mentioned in this publication may or may not be copyrights and/or registered trademarks of their respective companies They are mentioned for identification purposes only and are not intended as an endorsement of that product or its manufacturer Version 1.0 May 2014 Trademarks Intel, Intel Core, Pentium and Celeron are trademarks of Intel Corporation Windows® is a registered trademark of Microsoft Corporation Other brand and product names are trademarks and /or registered trademarks of their respective companies II Preface About this Manual This manual is intended for service personnel who have completed sufficient training to undertake the maintenance and inspection of personal computers It is organized to allow you to look up basic information for servicing and/or upgrading components of the W970SUW series notebook PC The following information is included: Chapter 1, Introduction, provides general information about the location of system elements and their specifications Chapter 2, Disassembly, provides step-by-step instructions for disassembling parts and subsystems and how to upgrade elements of the system Preface Appendix A, Part Lists Appendix B, Schematic Diagrams Appendix C, Updating the FLASH ROM BIOS III Preface IMPORTANT SAFETY INSTRUCTIONS Follow basic safety precautions, including those listed below, to reduce the risk of fire, electric shock and injury to persons when using any electrical equipment: Preface Do not use this product near water, for example near a bath tub, wash bowl, kitchen sink or laundry tub, in a wet basement or near a swimming pool Avoid using a telephone (other than a cordless type) during an electrical storm There may be a remote risk of electrical shock from lightning Do not use the telephone to report a gas leak in the vicinity of the leak Use only the power cord and batteries indicated in this manual Do not dispose of batteries in a fire They may explode Check with local codes for possible special disposal instructions This product is intended to be supplied by a Listed Power Unit with an AC Input of 100 - 240V, 50 - 60Hz, DC Output of 19V, 3.42A (65 Watts) minimum AC/DC Adapter CAUTION This Computer’s Optical Device is a Laser Class Product FCC Statement This device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions: This device may not cause harmful interference This device must accept any interference received, including interference that may cause undesired operation IV Preface Instructions for Care and Operation The notebook computer is quite rugged, but it can be damaged To prevent this, follow these suggestions: Don’t drop it, or expose it to shock If the computer falls, the case and the components could be damaged Do not expose the computer to any shock or vibration Do not place anything heavy on the computer Keep it dry, and don’t overheat it Keep the computer and power supply away from any kind of heating element This is an electrical appliance If water or any other liquid gets into it, the computer could be badly damaged Do not leave it in a place where foreign matter or moisture may affect the system Don’t use or store the computer in a humid environment Do not place the computer on any surface which will block the vents Preface Do not expose it to excessive heat or direct sunlight Do not place it on an unstable surface Follow the proper working procedures for the computer Shut the computer down properly and don’t forget to save your work Remember to periodically save your data as data may be lost if the battery is depleted Do not turn off the power until you properly shut down all programs Do not turn off any peripheral devices when the computer is on Do not disassemble the computer by yourself Perform routine maintenance on your computer V Preface Avoid interference Keep the computer away from high capacity transformers, electric motors, and other strong magnetic fields These can hinder proper performance and damage your data Take care when using peripheral devices Use only approved brands of peripherals Unplug the power cord before attaching peripheral devices Preface Power Safety The computer has specific power requirements: VI • • Power Safety Warning • Before you undertake any upgrade procedures, make sure that you have turned off the power, and disconnected all peripherals and cables (including telephone lines and power cord) It is advisable to also remove your battery in order to prevent accidentally turning the machine on • • • Only use a power adapter approved for use with this computer Your AC adapter may be designed for international travel but it still requires a steady, uninterrupted power supply If you are unsure of your local power specifications, consult your service representative or local power company The power adapter may have either a 2-prong or a 3-prong grounded plug The third prong is an important safety feature; not defeat its purpose If you not have access to a compatible outlet, have a qualified electrician install one When you want to unplug the power cord, be sure to disconnect it by the plug head, not by its wire Make sure the socket and any extension cord(s) you use can support the total current load of all the connected devices Before cleaning the computer, make sure it is disconnected from any external power supplies Do not plug in the power cord if you are wet Do not use the power cord if it is broken Do not place heavy objects on the power cord Preface Battery Precautions • Only use batteries designed for this computer The wrong battery type may explode, leak or damage the computer • Do not continue to use a battery that has been dropped, or that appears damaged (e.g bent or twisted) in any way Even if the computer continues to work with a damaged battery in place, it may cause circuit damage, which may possibly result in fire • Recharge the batteries using the notebook’s system Incorrect recharging may make the battery explode • Do not try to repair a battery pack Refer any battery pack repair or replacement to your service representative or qualified service personnel • Keep children away from, and promptly dispose of a damaged battery Always dispose of batteries carefully Batteries may explode or leak if exposed to fire, or improperly handled or discarded • Keep the battery away from metal appliances • Affix tape to the battery contacts before disposing of the battery • Do not touch the battery contacts with your hands or metal objects Battery Guidelines Preface The following can also apply to any backup batteries you may have • If you not use the battery for an extended period, then remove the battery from the computer for storage • Before removing the battery for storage charge it to 60% - 70% • Check stored batteries at least every months and charge them to 60% - 70% Battery Disposal The product that you have purchased contains a rechargeable battery The battery is recyclable At the end of its useful life, under various state and local laws, it may be illegal to dispose of this battery into the municipal waste stream Check with your local solid waste officials for details in your area for recycling options or proper disposal Caution Danger of explosion if battery is incorrectly replaced Replace only with the same or equivalent type recommended by the manufacturer Discard used battery according to the manufacturer’s instructions Battery Level Click the battery icon in the taskbar to see the current battery level and charge status A battery that drops below a level of 10% will not allow the computer to boot up Make sure that any battery that drops below 10% is recharged within one week VII Preface Related Documents You may also need to consult the following manual for additional information: User’s Manual on CD/DVD This describes the notebook PC’s features and the procedures for operating the computer and its ROM-based setup program It also describes the installation and operation of the utility programs provided with the notebook PC System Startup Preface Remove all packing materials Place the computer on a stable surface Insert the battery and make sure it is locked in position Securely attach any peripherals you want to use with the computer (e.g keyboard and mouse) to their ports Attach the AC/DC adapter to the DC-In jack on the left of the computer, then plug the AC power cord into an outlet, and connect the AC power cord to the AC/DC adapter Use one hand to raise the lid/LCD to a comfortable viewing angle (do not exceed 130 degrees); use the other hand (as illustrated in Figure 1) to support the base of the computer (Note: Never lift the computer by the lid/LCD) Press the power button to turn the computer “on” 130º Figure Opening the Lid/LCD/ Computer with AC/DC Adapter Plugged-In Shut Down Note that you should always shut your computer down by choosing the Shut down command in Windows (see below) This will help prevent hard disk or system problems Click Settings in the Charms Bar (use the Windows Logo Key + C key combination to access the Charms Bar) and choose Shut down from the Power menu Or Choose Shut down or sign out > Shut down from the context menu (use the Windows Logo Key + X key combination to access the context menu) VIII Schematic Diagrams HDD, CCD, TPM, Power Con HDD CONNECTOR (CO-LAY) J_HDD1 D TPM 2.0 J_HDD2 Gen3 S1 S2 S3 S4 S5 S6 S7 SATA_TXP5_R SATA_TXN5_R C415 C411 0.01u_16V_X7R_04 0.01u_16V_X7R_04 SATA_TXP5 [14] SATA_TXN5 [14] SATA_RXN5_R SATA_RXP5_R C408 C407 0.01u_16V_X7R_04 0.01u_16V_X7R_04 SATA_RXN5 [14] SATA_RXP5 [14] S1 S2 S3 S4 S5 S6 S7 SATA_TXP5_R SATA_TXN5_R 3.3VS (W54) 5VS C383 PIN GND1~2=GND 1u_6.3V_X5R_04 0.1u_16V_Y5V_04 GND1 GND2 C166KG-12209-L C392 10u_6.3V_X5R_06 C391 (W94) [17,23,26,27,30] [15,30] [15,30] [15,30] [15,30] LPC_AD0 LPC_AD1 LPC_AD2 LPC_AD3 [22] PCLK_TPM 21 22 BUF_PLT_RST# 16 TPM_BADD 27 [15,30] LPC_FRAME# BUF_PLT_RST# [15,30] 5VS 26 23 20 17 LPC_SIRQ TPM_PP 12 13 14 15 28 13&7 PRXQW [16] PM_CLKRUN# [16] S4_STATE# *50813-0220P-001 R123 R139 *0_04 *0_04 R138 *10K_04 LAD0 LAD1 LAD2 LAD3 VSB NC_2 VDD3 VDD4 R94 6-21-C4790-122 (7.0mm HDD) LFRAME# LRESET# GPIO3/BADD SERIRQ PP 6-20-437H0-022 (9.5mm HDD) GPIO0/XOR_OUT GPIO1 NC_1 TEST NC_4 VSS_1 NC_5 NC_3 NC_6 VSS_2 CLKRUN#/GPIO4 VSS_3 LPCPD# TPM_GPIO 3.3VS D C150 0.1u_16V_Y5V_04 PIN10 PIN19 10u_6.3V_X5R_06 PIN24 11 18 25 Sheet 24 of 45 HDD, CCD, TPM, Power Con 3.3VS TPM_PP R93 *10K_04 R92 0_04 C TPM_BADD [31] V15AVLC0402 D23 *1K_04 R115 R137 LPC reset timing: PCLK_TPM LPCPD# inactive to LRST# inactive 32~96us J_SW2 85201-04051 C134 0.1u_16V_Y5V_04 0_04 R91 20mil M_BTN# 10u_6.3V_X5R_06 BUF_PLT_RST# *10K_04 Asserted before entering S3 3.3VS M_BTN# C133 0.1u_16V_Y5V_04 3.3VS LPC_SIRQ & PM_CLKRUN# must pull high at PCH side 3.3VS 3.3V 6/% PRXQW 13&7 XQPRXQW FOR POWER SW BOARD J_SW1 C135 C148 GPIO2/GPX 10/22 C 0_04 TPM LCLK SLB9655TT 3.3VS *0_04 6/% PRXQW 10 19 24 20mil M_BTN# TPM_PP HI: ACCESS LOW: NORMAL ( Internal PD ) TPM_BADD HI: 4E/ 4F H LOW: 2E/ 2F H C155 PCLK_TPM1 *33_04 *10p_50V_NPO_04 *85201-04051 M_BTN# R330 LID SWITCH IC W54 B W55 B CCD+Mic VDD3 VDD3 0_06 *0_06 VCC_CCD 1A 1A U2 VIN VIN VOUT EN GND 5V_CCD C3 C2 *1u_10V_Y5V_06 *0.1u_16V_Y5V_04 J_LID1 [12,30] LID_SW# C1 BAV99 RECTIFIER AC LID_SW# 85204-03001 *100p_50V_NPO_04 48 mil 6-02-00248-LC2 C5 C4 1u_6.3V_X5R_04 D5 LID_SW# A R469 GND R468 VDD3 LID_SW# C U1 *MH248-ALFA-ESO VCC OUT 3.3VS 5V 2 6-02-00268-LC1 2.2u_6.3V_X5R_04 NCT3522U [29] [29] [29] *0.1u_16V_Y5V_04 From KBC default HI CCD_EN R467 INT_MIC_OUT L54 L55 MIC_DAT MIC_CLK 0_04 [19] [19] USB_PN11 USB_PP11 3.3VS *HCB1005KF-121T20 *HCB1005KF-121T20 '0,& PRXQW / / 5 & & ! SB9B132B C458 *47p_50V_NPO_04 C7 100p_50V_NPO_04 6-53-3050B-042 POWER BUTTON SW5 TJG-532-V-T/R M_BTN# [2,12,19,21,23,26,27,31,32,34] 3.3V [25,31,33] VDD5 [25,27,31,32,34] 5V [12,13,14,19,27,28,29,31,35] 5VS [14,21,23,26,30,31,33,34,36] VDD3 [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,25,26,27,28,29,30,31,35] 3.3VS 85205-08001 Title for Debug $0,& PRXQW 5 5 & ! SB9B132B [24] HDD,CCD,TPM,POWER CON Size Document Number Custom 6-7P-W5409-003 Date: A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ C6 [30] A J_CCD1 Rev 3.0 6-71-W54S0-D03 Sheet Wednesday, April 09, 2014 24 of 45 HDD, CCD, TPM, Power Con B - 25 B.Schematic Diagrams P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 13&7 PRXQW R100 U3 SATA_RXN5_R SATA_RXP5_R 3.3VS P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 SLB9655TT & NPCT420 COLAY Schematic Diagrams USB3.0, LED, USB Charger USB Charger PORT [30,31,33] DD_ON R393 *0_04 R397 0_04 LED U12 USB_PP0 CB TDP VDD5 C406 PRE# TDM VCC SLG55583VTR DM DP CDP USB_DD_ON# USB_PN0_R USB_PP0_R R409 HDD LED R271 R270 220_04 220_04 VDD5 D15 R413 *10K_04 D14 RY-SP190YG34-5M RY-SP190YG34-5M C 0.1u_16V_Y5V_04 [14] Windows AIRPLAN_LED# SATA_LED# Windows [30] Co-lay with charger USB_PN0 USB_PP0 R403 R407 *0_04 *0_04 USB_PN0_R USB_PP0_R DD_ON# R396 *0_04 USB_DD_ON# BAT LED W/O USB CHARGER LED_PWR LED_ACIN VOUT3 EN# GND 7 C282 *0.1u_10V_X7R_04 RY-SP155HYYG4-1 1 D16 C283 0.1u_10V_X7R_04 D17 RY-SP155HYYG4-1 6-52-55002-04B 6-52-55001-040 6-52-55002-042 SY6288DCAC 10u_10V_Y5V_08 R457 100K_04 6-52-55002-04B 6-52-55001-040 6-52-55002-042 ഒ ྌ M - M S O P8⊭ U10 USB_OC#01 5V USBVCC3.0_2 CO-LAY B DD_ON# C390 100mils 10u_10V_Y5V_08 [27,31] 22u_6.3V_X5R_08 VOUT2 VIN2 VOUT3 EN# GND SY6288DCAC APL3518BXITRG uP7534BRA8-20 C280 22u_6.3V_X5R_08 VIN1 DD_ON# USBVCC01 60 MIL SY6288DCAC 10/4 del C284 FLG# VOUT1 C236 C237 *0.1u_10V_X7R_04 [19,25] *0_04 0.1u_10V_X7R_04 USB3.0 PORT(PORT1) USB Charger Port USB3.0 R217 C455 USB3_TX1_P [19] USB3_TX1_N [19] [19] C423 USB_PN0_R USB_PP0_R L47 USB3_RX1_P C425 0.1u_10V_X7R_04 0.1u_10V_X7R_04 *WCM2012F2S-161T03-short USB3_RX1_N Standard-A J_USB2 [19] B CO-LAY SSTX+ SHIELD VBUS SSTXDGND D+ SSRX+ GND_D SSRX- SHIELD USBVCC01 USB3.0 PORT(PORT2) GND2 377AH09FZTS4NVCB 22u_6.3V_X5R_08 C394 22u_6.3V_X5R_08 [19] USB3_TX2_P [19] USB3_TX2_N [19] USB_PN1 [19] [19] USB_PP1 USB3_RX2_P [19] USB3_RX2_N GND CLOSE TO CONNECTOR J_USB1 C249 0.1u_10V_X7R_04 C254 0.1u_10V_X7R_04 L19 *WCM2012F2S-161T03-short A GND Title [31,33] [24,27,31,32,34] [2,12,19,21,23,24,26,27,31,32,34] [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,26,27,28,29,30,31,35] B - 26 USB3.0, LED, USB Charger *220u_6.3V_6.3*6.3*4.2 C395 GND1 VDD5 5V 3.3V 3.3VS Size A3 Date: Standard-A VOUT2 VIN2 [30] [30] + C275 VIN1 4 ᶵ Ṗ Y USB_DD_ON# FLG# VOUT1 Ṗ Airplane OFF C Y ᶵ Ṗ Airplane ON 50 MIL SG 100 MIL *0_04 WLAN OFF USBVCC3.0_2 U13 R262 D RN9 220_8P4R_04 ഒ ྌ M - M S O P8⊭ [19,25] USB_OC#01 VDD5 Ṗ POWER ON LED [30] LED_BAT_CHG [30] LED_BAT_FULL USB POWER SWITCH C WLAN ON Sheet 25 of 45 USB3.0, LED, USB Charger SG B.Schematic Diagrams AIRPLAN LED WLAN LED 10K_04 A USB_PP0 USB_PN0 GND [19] D USB_PN0 [19] 3.3VS A SUSB# C [9,16,30,31,32] SSTX+ SHIELD VBUS SSTXDGND D+ SSRX+ GND_D SSRX- SHIELD GND1 GND2 377AH09FZTS4NVCB A GND ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ [25] USB3.0 CON, LED, USB Charger Document Number 6-7P-W5409-003 Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 25 of 45 Schematic Diagrams Card Reader / LAN RTL8411B LAN (RTL8411B) IN SOCKET SD/MMC/MS/MS Pro CO-LAY ᷀ 503 SI E ෑ Z Crystal RSET R159 meet realtek Freq tolerance 50ppm 2.49K_1%_04 R160 *1K_04 R161 10K_04 Switching Regulator close to PIN48 Ra XTAL2 R151 AVDD33 X1 C D6 XTAL2 XTAL1 MS_INS# SD_CD# EECS LED_CR FSX5L_25MHZ C166 27p_50V_NPO_04 27p_50V_NPO_04 E_PAD TO SB PCH WAKE# PCIE_WAKE# VDD10 (>20mil) *SWF2520CF-4R7M-M [16,23] La TO EC8587 PIN123 PME# LAN_WAKEUP# [17,30] LED1/GPO LED2 T18 T20 C149Ca C180Cb *4.7u_6.3V_X5R_06 *0.1u_16V_Y5V_04 VCC_CARD SD_CLK/MS_D0_R C409 SD_D0/MS_D1_R SD_D1_R MS_BS/SD_WP# 0.1u_16V_Y5V_04 LDO Mode : La, Ca, Cb ᶵ ᶲẞ,R a ᶲ ẞ ፗ ᶺ ⅒ క ࠤ ᢃ ៃ ,ෑ S H O RT VCC_CARD ẞ SD_D2/MS_CLK_R SD_D3/MS_D3_R MS_INS# SD_CMD/MS_D2_R SD_CLK/MS_D0_R SD_D0/MS_D1_R MS_BS/SD_WP# C412 BIOS pulls high or low to GPO pin, Please refer to LAN/PHY Disable Application Note HV_GIGA RSET LV_CEN CKXTAL2 CKXTAL1 MS_CD# SD_CD# LED0 LED_CR LANWAKEB LED1/GPO LED2 49 REGOUT 0.1u_16V_Y5V_04 R180 1K_04 P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 P21 3.3VS CD_SD DAT2_SD CD/DAT3_SD CMD_SD VSS_SD VDD_SD CLK_SD VSS_SD DAT0_SD DAT1_SD WP_SD VSS_MS VCC_MS SCLK_MS DAT3_MS INS_MS DAT2_MS SDIO/DAT0_MS DAT1_MS BS_MS VSS_MS LAN_MDIP0 LAN_MDIN0 LAN_MDIP0 LAN_MDIN0 VDD10 C [28] [28] [28] [28] LAN_MDIP1 LAN_MDIN1 LAN_MDIP2 LAN_MDIN2 [28] [28] LAN_MDIP3 LAN_MDIN3 LAN_MDIP1 LAN_MDIN1 LAN_MDIP2 LAN_MDIN2 VDD10 LAN_MDIP3 LAN_MDIN3 AVDD33 3.3VS 10 11 12 MDIP0 MDIN0 AVDD10 MDIP1 MDIN1 MDIP2 MDIN2 AVDD10 MDIP3 MDIN3 HV_GIGA VDD3 QFN48 0.1u_16V_Y5V_04 CARD_3V3 B VDD10 REGOUT REGOUT D3V3 ENSWREG VDD10 VDD10 C152 ISOLATEB PERSTB R194 CLKREQB MS_BS/SD_WP# RTL8411B_HSON RTL8411B_HSOP W540SU VDD10 AVDD33 J_CARD-REV2 *20mil_04 VDD33/18 BUF_PLT_RST# C195 C200 0.1u_10V_X7R_04 0.1u_10V_X7R_04 CLK_PCIE_GLAN# [22] CLK_PCIE_GLAN [22] PCIE_TXN4_GLAN [19] PCIE_TXP4_GLAN [19] LAN_CLKREQ# SD_CD# SD_D2/MS_CLK_R SD_D3/MS_D3_R SD_CMD/MS_D2_R [22] [19] [19] VCC_CARD P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 P21 SD_CLK/MS_D0_R PULL HIGH: SWR Mode C204 C191 0.1u_16V_Y5V_04 4.7u_6.3V_X5R_06 R174 R173 AVDD33 VCC_CARD SD_D2/MS_CLK_R SD_D3/MS_D3_R MS_INS# SD_CMD/MS_D2_R SD_CLK/MS_D0_R SD_D0/MS_D1_R MS_BS/SD_WP# *0_04 0_04 PULL LOW: LDO Mode ፗ ᶺ ⅒ క LDO M ෑS H O R T ẞ Near Cardreader CONN ODE O K ࠤ, C CD_SD DAT2_SD CD/DAT3_SD CMD_SD VSS_SD VDD_SD CLK_SD VSS_SD DAT0_SD DAT1_SD WP_SD VSS_MS VCC_MS SCLK_MS DAT3_MS INS_MS DAT2_MS SDIO/DAT0_MS DAT1_MS BS_MS VSS_MS GND GND P22 P23 3IN1 W550SU C164 B C381 0.1u_16V_Y5V_04 0.1u_16V_Y5V_04 0.1u_16V_Y5V_04 0.1u_16V_Y5V_04 PIN8 PIN32 PIN46 PIN13 C203 VDD33/18 VDD33/18 CARD_3V3 R218 R203 0.2_06 VCC_CARD Ḏ ᝤᜑ ho s tᢃ ᜨ / C A R D୬ ౪ , V C C _ C AR D ᢃū Ỷ ๔0.5ặᬑ , ҩᢈ ଉ ms ྷ ℏ Ӽ R202 SD_CMD/MS_D2 R211 *20mil_04 SD_CMD/MS_D2_R *150_06 SD_D0/MS_D1 R209 *20mil_04 SD_D0/MS_D1_R SD_D1 R208 *20mil_04 SD_D1_R 1u_6.3V_X5R_04 SD_D2/MS_CLK R213 *20mil_04 SD_D2/MS_CLK_R PIN20 SD_CLK/MS_D0 R210 *20mil_04 SD_CLK/MS_D0_R SD_D3/MS_D3 R212 *20mil_04 SD_D3/MS_D3_R EVDD10 Pin#27 PCIE_RXN4_GLAN PCIE_RXP4_GLAN *20mil_04 Sheet 26 of 45 Card Reader / LAN RTL8411B CARD_3V3 PIN3 *4.7u_6.3V_X5R_06 R193 ENSWREG 0.1u_16V_Y5V_04 C193 [17,23,24,27,30] SD_D0/MS_D1_R SD_D1_R MS_BS/SD_WP# C379 VDD10 P22 P23 Remind that using the main power (S0 power) VCC_CARD 13 SD_D1 14 SD_D0/MS_D1 15 SD_CLK/MS_D0 16 SD_CMD/MS_D217 SD_D3/MS_D3 18 SD_D2/MS_CLK 19 20 EVDD10 21 22 23 24 The Pin12 Power rise time must be controlled between 1mS and 100mS VDD10 36 35 34 33 32 31 30 29 28 27 26 25 CARD_3V3 SD_D1 SD_D0/MS_D1 SD_CLK/MS_D0 SD_CMD/MS_D2 SD_D3/MS_D3 SD_D2/MS_CLK VDDTX HSIP HSIN REFCLK_P REFCLK_N C196 60 mil REG_OUT VDDREG ENSWREG VDD1 VD33 ISOLATEBPIN PERSTBPIN CLKREQBPIN MS_BS/SD_WP# DV33_18 HSON HSOP RTL8411B GND GND *3IN1 R184 15K_04 [28] [28] D 0_06 C209 C215 0.1u_16V_Y5V_04 PIN20 C190 0.1u_16V_Y5V_04 VDD3 meet rising time >1ms Pin#27 AVDD33 VDD3 R186 *28mil_06 R198 *28mil_06 C192 C186 C163 C232 C230 C233 C228 C229 C231 *5p_50V_NPO_04 *5p_50V_NPO_04 Close to chip *5p_50V_NPO_04 PIN48 *5p_50V_NPO_04 0.1u_16V_Y5V_04 PIN32 *5p_50V_NPO_04 0.1u_16V_Y5V_04 PIN11 *5p_50V_NPO_04 0.1u_16V_Y5V_04 EMI confirm, change to SHORT A A L12 *HCB1608KF-121T25 3.3V D3V3 60 mil R152 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ *28mil_06 LDO Mode C173 C174 *4.7u_6.3V_X5R_06 *0.1u_16V_Y5V_04 PIN35 Title [2,12,19,21,23,24,27,31,32,34] 3.3V [14,21,23,24,30,31,33,34,36] VDD3 [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,27,28,29,30,31,35] 3.3VS PIN35 [26] CARD READER/ LAN RTL8411B Size Document Number Custom Date: Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 26 of 45 Card Reader / LAN RTL8411B B - 27 B.Schematic Diagrams U8 SD_CD# SD_D2/MS_CLK_R SD_D3/MS_D3_R SD_CMD/MS_D2_R VDD10 L13 LAN_WAKEUP# 48 47 46 45 44 43 42 41 40 39 38 37 C165 A RB751S-40C2 J_CARD-REV1 0_06 (>20mil) AVDD33 FOR S5 WAKE UP ON LAN T17 XTAL1 1M_04 VDD10 R148 D Schematic Diagrams TP/Audio Con, G-Sensor TP CONN R479 *0_06 R427 0_06 10/8 TP_VCC 3.3V C377 Q16A MTDK5S6R TP_CLK [30] TP_DATA [30] C417 47p_50V_NPO_04 47p_50V_NPO_04 [9,10,15] 3.3V Q16B MTDK5S6R C378 U29 0.1u_10V_X7R_04 3.3V_GSENSOR C418 SMB_CLK D S TP_CLK TP_DATA TPBUTTON_L TPBUTTON_R *20mil_04 G_I2CC 10K_04 R360 *0_04 R473 0_04 NC1 NC2 2.2K_04 D G_I2CD G_I2CC SDO/SA0 RES TP_CLK TP_DATA TPBUTTON_L TPBUTTON_R GND1 10/8 J_TP2 10/14 TP_CLK TP_DATA *85201-06051 88486-0801 W94 W97 12 J_TP3 INT1 INT2 FOR AUDIO BOARD R489 G_INT1 T43 G_INT2 [17] 0_06 R490 USBVCC03 11 ADC1 10 ADC2 [9,10,15] TP_VCC 0_06 USBVCC04 10/18 6-53-3050B-042 100g C LIFT KEY W54 SW1 *TJG-532-V-T/R C RIGHT KEY SW2 *TJG-532-V-T/R TPBUTTON_L TPBUTTON_R [19,27] USB_OC#89 SW3 TJG-532-V-T/R SW4 TJG-532-V-T/R FLG# VOUT1 C212 1u_6.3V_X5R_04 VIN1 VOUT2 VIN2 VOUT3 EN# GND 6-53-3050B-042 USB_PN4 USB_PP4 [19] [19] SPDIFO [29] 5VS 50578-0060N-001 SY6288DCAC RIGHT KEY TPBUTTON_L 6-53-3050B-042 W55/W97 J_AUDIO1 2A [25,27,31] DD_ON# 10/18 TPBUTTON_R 5V 100 MIL USBVCC04 W55 *0_04 2A 6 LIFT KEY USBVCC03 USBVCC03 U11 R228 5V 6-53-3050B-042 6-53-3050B-042 10/18 1.1A 60mils J_AUDIO2 10 11 12 13 14 USBVCC04 U30 4 RIGHT KEY SW7 *TJG-532-V-T/R TPBUTTON_L [19,27] R488 USB_OC#89 5V TPBUTTON_R B 6-53-3050B-042 A NC1 NC2 VIN2 VOUT3 EN# GND [29] [29] HEADPHONE-RR HEADPHONE-LL [29] MIC_SENSE [29] HP_SENSE [19] USB_PN9 [19] USB_PP9 [29] [29] DD_ON# MIC1-R MIC1-L MIC1-R MIC1-L SPKOUTR+_R SPKOUTR-_R R436 *0_06 *0_06 B 85201-14051-01 PCB Footprint = 85201-14x5_r Realtek Headphone Anti-Pop Circuit C448 *0.1u_10V_X7R_04 5V 10/18 HEADPHONE-RR C447 *0.1u_10V_X7R_04 1K_04 B Q19 BTD2444N3 E R432 PCIE_TXN1_CARD PCIE_TXP1_CARD [19] [19] PCIE_RXN1_CARD PCIE_RXP1_CARD [19] [19] USB_PN2 USB_PP2 CLK_PCH_CARD_N CLK_PCH_CARD_P R425 4.7K_04 [19] [19] E C [22] [22] CARD_CLKRQ6# [22] BUF_PLT_RST# [17,23,24,26,30] [29] EAPD [29] 3.3VS_AUD [24,25,31,32,34] 5V [12,13,14,19,24,28,29,31,35] 5VS [14,21,23,24,26,30,31,33,34,36] VDD3 [2,12,19,21,23,24,26,31,32,34] 3.3V [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,26,28,29,30,31,35] 3.3VS AUDG HEADPHONE-LL 3.3VS_AUD R431 Q17 BTB1590N3 1K_04 C424 10u_6.3V_X5R_06 AUDG B Q18 BTD2444N3 A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title Size A3 AUDG Date: B - 28 TP/Audio Con, G-Sensor *0.1u_16V_Y5V_04 C R444 C217 AUDG *FP225-022S10M HEADPHONE-RR HEADPHONE-LL 3.3VS J_CN1 10 11 12 13 14 15 16 17 18 19 20 21 22 *1u_6.3V_X5R_04 VOUT2 [29] [29] *SY6288DCAC B 3.3V C205 VIN1 2A FLG# VOUT1 6-53-3050B-042 [25,27,31] For 17" *0_04 2A C W94 SW6 *TJG-532-V-T/R E LIFT KEY B.Schematic Diagrams R366 2.2K_04 16 D S SMB_DATA 15 ADC3 GND2 G_I2CD TP_VCC Sheet 27 of 45 TP/Audio Con, G-Sensor CS SDA/SDI/SDO SCL/SPC 13 85201-06051 W54/W55 R381 LIS3DH G R472 14 1u_6.3V_X5R_04 VDD C419 *10u_6.3V_X5R_06 G C420 R428 10K_04 0.1u_10V_X7R_04 3.3V 3.3V_GSENSOR R429 J_TP1 D C376 3.3V_GSENSOR 5VS 10u_6.3V_X5R_06 VDD I/O 3.3VS G Sensor [27] TP/AUDIO CON,G_SENSOR Document Number 6-7P-W5409-003 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 27 of Rev 3.0 45 Schematic Diagrams HDMI, RJ45, Fan For ESD 1.5VS [6] [6] [6] [6] 0.1u_10V_X7R_04 0.1u_10V_X7R_04 C171 C169 C160 C157 0.1u_10V_X7R_04 0.1u_10V_X7R_04 0.1u_10V_X7R_04 0.1u_10V_X7R_04 C154 C151 HDMIC_CLKCP HDMIC_CLKCN 10 0.1u_10V_X7R_04 0.1u_10V_X7R_04 IN_D2p IN_D2n HPD_SRC IN_D1p IN_D1n IN_D0p IN_D0n I2C_CTL_EN IN_CKp IN_CKn 30 29 28 27 26 25 24 23 22 21 OUT_D2p OUT_D2n HPD_SNK OUT_D1p OUT_D1n OUT_D0p OUT_D0n CFG/I2C_ADDR1 OUT_CKp OUT_CKn PS8201A 41 SUSB 3.3VS 1.5VS GND 3.3VS 3.3VS *4.7K_04 22u_6.3V_X5R_08 22u_6.3V_X5R_08 R122 4.7K_04 R133 *4.7K_04 R121 *4.7K_04 TMDS_CLOCK#-R TMDS_CLOCK-R TMDS_CLOCK 12 10 *WCM2012F2S-161T03-short TMDS_DATA1# L41 TMDS_DATA1 HOT PLUG DETECT +5V DDC/CEC GND SDA SCL RESERVED CEC TMDS CLOCKCLK SHIELD TMDS CLOCK+ TMDS DATA0SHIELD0 TMDS DATA0+ TMDS DATA1SHIELD1 TMDS DATA1+ TMDS DATA2SHIELD2 TMDS DATA2+ DCIN_EN 1.5VS DDCBUF PRE R132 *4.7K_04 3.3VS R130 *4.7K_04 CFG 3.3VS R119 *4.7K_04 EQ R120 *4.7K_04 R181 *4.7K_04 R191 *4.7K_04 C181 3.3VS C144 C143 C142 0.1u_10V_X7R_04 0.1u_10V_X7R_04 0.1u_10V_X7R_04 0.1u_10V_X7R_04 Pin#19 Pin#19 Pin#20 Pin#40 C183 C182 HDMI_SCL-C HDMI_CEC 13 11 TMDS_DATA0# L40 TMDS_DATA0 TMDS_DATA0-R *WCM2012F2S-161T03-short TMDS_DATA2# L42 TMDS_DATA2 TMDS_DATA2-R *WCM2012F2S-161T03-short 0.01u_16V_X7R_04 0.01u_16V_X7R_04 0.01u_16V_X7R_04 Pin#11 Pin#37 Pin#12 Pin#31 C PIN GND1~4=GND 5VS LAN_MDIN1 LAN_MDIP1 LAN_MDIN0 LAN_MDIP0 TMDS_DATA2#-R CPU FAN CONTROL [26] [26] [26] [26] Sheet 28 of 45 HDMI, RJ45, Fan TMDS_DATA0#-R C184 0.1u_10V_X7R_04 L31 LAN_MDIN3 LAN_MDIP3 LAN_MDIN2 LAN_MDIP2 A 17 15 ISET GIGA LAN (RTL8411B) LAN POART [26] [26] [26] [26] C HDMI_HPD-C 19 C12822-100A 1.5VS C145 3.3VS 16 14 *WCM2012F2S-161T03-short TMDS_CLOCK# HDMI_SDA-C HDMI_HPD-C 18 4.99K_1%_04 D11 GND GND GND GND R134 D9 HDMI_SCL-C C375 HDMI_SDA-C TMDS_DATA1-R D10 *BAV99 RECTIFIER *BAV99 RECTIFIER *BAV99 RECTIFIER C373 L39 C D GND1 GND2 GND3 GND4 3.3VS R146 2.2K_04 PRE EQ C B EN# R145 2.2K_04 J_HDMI1 TMDS_DATA1#-R R131 VOUT3 SY6288DCAC 1.5VS DCIN_EN DDCBUF VOUT2 VIN2 *20K_04 11 12 13 14 15 16 17 18 19 20 Epad [31,34] TMDS_DATA2-R TMDS_DATA2#-R HDMI_HPD-C R140 TMDS_DATA1-R TMDS_DATA1#-R TMDS_DATA0-R TMDS_DATA0#-R CFG TMDS_CLOCK-R TMDS_CLOCK#-R VIN1 AC VDDRX SDA_SRC SCL_SRC VDD33 PD# GND ISET SDA_SNK SCL_SNK VDDTX C178 C176 FLG# VOUT1 LAN_MDIN3 LAN_MDIP3 LAN_MDIN2 LAN_MDIP2 12 11 LAN_MDIN1 LAN_MDIP1 LAN_MDIN0 LAN_MDIP0 10 40 mil TD4TD4+ TD3TD3+ MX4MX4+ MX3MX3+ TD2TD2+ TD1TD1+ MX2MX2+ MX1MX1+ TCT4 TCT3 TCT2 TCT1 MCT4 MCT3 MCT2 MCT1 13 14 16 17 LMX4LMX4+ LMX3LMX3+ LMX1+ LMX1LMX2+ LMX2- 19 20 22 23 LMX2LMX2+ LMX1LMX1+ LMX3+ LMX3LMX4+ LMX4- 15 18 21 24 NMCT_4 NMCT_3 NMCT_2 NMCT_1 L49 L50 L52 L51 U19 J_RJ1 DLMX1+ DLMX12 *WCM2012F2S-161T03-short DLMX2+ DLMX23 *WCM2012F2S-161T03-short DLMX3+ DLMX32 *WCM2012F2S-161T03-short DLMX4+ DLMX43 *WCM2012F2S-161T03-short DA+ DADB+ DB- shield shield GND1 GND2 5VS_FAN FON C366 1u_6.3V_X5R_04 FON VIN VOUT VSET GND GND GND GND DC+ DCDD+ DD- [30] CPU_FAN 5VS_FAN NCT3940S-A CPU_FAN B D02 CHANGE VALUE J_FAN1 NC2 NC1 PJS-08SO1B-1 C370 10u_10V_Y5V_08 85205-03701 6-20-51130-103 NS892402 C8 [30] 0.01u_16V_X7R_04 R13 R6 R4 R3 A 75_04 75_04 75_04 75_04 3.3VS NMCT_R 4.7K_04 A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ 100p_2KV_X7R_12_H125 Title [14,16,19,20,21,22,34] [12,13,14,19,24,27,29,31,35] [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,26,27,29,30,31,35] 1.5VS 5VS 3.3VS [28] HDMI,RJ45,FAN Size Document Number Custom 6-7P-W5409-003 Date: R333 C294 J_FAN1 CPU_FANSEN Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 28 of 45 HDMI, RJ45, Fan B - 29 B.Schematic Diagrams [6] [6] HDMIC_C0CP HDMIC_C0CN [17] DPC_HPD HDMIC_C1CP HDMIC_C1CN HDMIC_C2CP HDMIC_C2CN VDD33 VDDRX DCIN_EN/SCL_CTL DDCBUF/SDA_CTL GND PRE EQ/I2C_ADDR0 REXT VDDTA VDDTX [6] [6] A 40 39 38 37 36 35 34 33 32 31 U6 D 5VS_HDMI U4 C 5VS AC 1.5VS 5VS_HDMI A HDMI_CTRLCLK HDMI_CTRLDATA no level shief, D9,D10,D11 mount HDMI CONNECTOR ISET HDMI_SDA-C HDMI_SCL-C 3.3VS [17] [17] AC HDMI Repeater Schematic Diagrams Audio Codec VT1802S CODEC (ALC269Q_VB7) DVDD_IO 3.3VS R433 PVDD1_2 R430 *28mil_06 *20mil_04 5VS C431 C440 C429 C422 10u_6.3V_X5R_06 0.1u_16V_Y5V_04 0.1u_16V_Y5V_04 10u_6.3V_X5R_06 976 / XQPRXQW $/& 4 / PRXQW D D 5VS_AUD 3.3VS 3.3VS_AUD C428 C286 0.1u_16V_Y5V_04 10u_6.3V_X5R_06 L48 HCB1005KF-121T20 C292 *1u_6.3V_X5R_04 3.3VS_AUD C432 5VS_AUD C426 10u_6.3V_X5R_06 AZ_SDOUT_R AZ_BITCLK_R A C [14] AZ_RST#_R 0_04 MIC_DAT_R 0_04 MIC_CLK_R *47p_50V_NPO_04 *47p_50V_NPO_04 0.1u_16V_Y5V_04 R445 AZ_SDIN0_R 33_04 10 AZ_RST#_R BEEP_L R451 47K_04 R447 4.7K_04 BEEP_R C442 PC BEEP C445 25 38 AVDD1 AVDD2 39 46 MIC2-L MIC2-R SPK-RSPK-R+ Sense-B SPDIFC2/EAPD SPDIFO JDREF MONO-OUT GPIO0 GPIO1 DIGITAL A HDA_SPKR SPK-L+ SPK-L- 11 PCBEEP 12 1u_6.3V_X5R_04 MIC1-L MIC1-R ANALOG LINE1-L LINE1-R SDATA-OUT BIT-CLK VREF SDATA-IN LDO_CAP MIC1-VREFO-R MIC2-VREFO SYNC RESET# PCBEEP PVSS1 PVSS2 BEEP AZ_SYNC_R SPDIFO HDA_SDIN0 [14] 47 48 220K_04 R470 R471 C459 C460 [14] 44 45 100p_50V_NPO_04 42 43 [30] [14] [27] MIC_DAT MIC_CLK [14] [14] D25 BAT54CS3 10u_6.3V_X5R_06 Sense A MIC1-VREFO-L SPKOUTR+_R SPKOUTR-_R [27] SPKOUTR+_R [27] SPKOUTR-_R 0.1u_16V_Y5V_04 AUDG 976 5 . 5 PRXQW $/& 4 5 . 5 PRXQW AVSS1 AVSS2 [24] [24] C444 LINE2-L LINE2-R 26 37 976 5 PRXQW $/& 4 5 PRXQW C R434 SPKOUTR-_R SPKOUTR+_R PD# GND 3.3VS_AUD 40 41 49 EAPD SPKOUTL+ SPKOUTL- HP-OUT-L HP-OUT-R CBN CBP OPVEE C449 10u_6.3V_X5R_06 976 S PRXQW $/& 4 S XQPRXQW C450 *100p_50V_NPO_04 SENSE_A R452 R453 20K_1%_04 39.2K_1%_04 MIC2_L MIC2_R C290 C289 4.7u_6.3V_X5R_06 INT_MIC 4.7u_6.3V_X5R_06 976 X $/& 4 X 19 20 JDREF R454 C451 20K_1%_04 *100p_50V_NPO_04 976 5 .B $/& 4 5 .B 21 22 MIC1-L_R MIC1-R_R C288 C287 4.7u_6.3V_X5R_06 MIC1_L 4.7u_6.3V_X5R_06 MIC1_R 13 AUDG MIC_SENSE [27] HP_SENSE [27] 14 15 16 17 18 23 24 27 28 30 29 CODEC_VREF *10K_04 C443 C441 0.1u_16V_Y5V_04 1u_16V_X5R_06 32 33 976 XB9 $/& 4 XB9 976 X XQPRXQW $/& 4 X PRXQW AUDG HEADPHONE-LL HEADPHONE-RR R258 R256 0_04 0_04 CODEC_CBN C433 2.2u_6.3V_X5R_04 36 34 CODEC_CBP CODEC_OPVEE C435 2.2u_6.3V_X5R_04 HEADPHONE-LL HEADPHONE-RR [27] [27] AUDG 976 .B PRXQW $/& 4 PRXQW MIC1-VREFO-L 7KHUPDO 3DG SODFH 9LD KROH B Please Let LC Filter together and close to Codec.IF Speaker wire length is less than 8000mils It don't need the LC Filter 3.3VS_AUD L46 MIC2-VREFO R266 4.7K_04 INT_MIC 1K_04 R269 INT_MIC_OUT INT_MIC_OUT [24] B AUDG C291 *0.022u_16V_X7R_04 J_SPK1 SPKOUTL+ C 976 5 PRXQW $/& 4 5 XQPRXQW 10u_6.3V_X5R_06 35 & PRXQW & XQPRXQW 976 X $/& 4 X PCBEEP R449 LDO_CAP C439 MIC1-VREFO-R MIC2-VREFO AUDG ALC269Q_VB7 31 4.7K_04 976 5 . 5 PRXQW $/& 4 5 . 5 . 4 PRXQW [27] U27 Q8 D 2SK3018S3 S R264 PVDD1 PVDD2 A DVDD1 C Sheet 29 of 45 Audio Codec VT1802S 10K_04 A BAT54AS3 C427 0.1u_16V_Y5V_04 DVDD-IO *10K_04 D24 AZ_RST#_R KBC_MUTE# C430 R265 DVSS2 R435 G B.Schematic Diagrams AZ_RST# For 3.3V HDA Link De-pop PD# Control [30] 5VS L29 HCB1005KF-121T20 0_06 976 B PRXQW $/& 4 .B PRXQW AUDG MIC1_R R267 1K_04 MIC1_L R268 1K_04 SPKOUTL+_L J_SPKL1 C414 C421 976 .B PRXQW $/& 4 PRXQW NC1 NC2 *180p_50V_NPO_04 *1u_6.3V_X5R_04 MIC1-VREFO-L R440 2.2K_04 MIC1-VREFO-R R442 2.2K_04 MIC1-R [27] MIC1-L [27] 85204-02001 SPKOUTL- L45 0_06 SPKOUTL-_L C413 5VS EMI Require *180p_50V_NPO_04 20ms EMI Require JP2 *20mil_04 AZ_RST# A C446 0.1u_16V_Y5V_04 C437 0.1u_16V_Y5V_04 A J_SPKL2 PD# SPKOUTL+_L SPKOUTL-_L Speaker wire length less than 8000mils , It don't need LC Filter NC1 NC2 *85204-02001 SPKOUTR+,R-,L+,L- Trace width Layout note: Speaker ohm > 40mils Speaker ohm > 20mils ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ GND and AUDG space is 60mils ~ 100mils AUDG [27] 3.3VS_AUD [12,13,14,19,24,27,28,29,31,35] 5VS [12,13,14,19,24,27,28,29,31,35] 5VS [2,12,19,21,23,24,26,27,31,32,34] 3.3V [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,26,27,28,30,31,35] 3.3VS Title Date: B - 30 Audio Codec VT1802S [29] ALC269Q & VT1802S co-lay Size Document Number Custom 6-7P-W5409-003 Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 29 of 45 Schematic Diagrams KBC-ITE IT8587 KBC_AVDD VDD3 C137 0.1u_10V_X7R_04 C168 0.1u_10V_X7R_04 C158 0.1u_10V_X7R_04 KBC_WRESET# [28] C 23 15 SMI# SCI# 77 KBC_MUTE# CPU_FAN CPU_FAN 79 74 VBAT VSTBY1 VSTBY2 VSTBY3 VSTBY4 VSTBY5 VSTBY6 K/B MATRIX WRST# KSO0/PD0 KSO1/PD1 KSO2/PD2 KSO3/PD3 KSO4/PD4 KSO5/PD5 KSO6/PD6 KSO7/PD7 KSO8/ACK# KSO9/BUSY KSO10/PE KSO11/ERR# KSO12/SLCT KSO13 KSO14 KSO15 GPB5/GA20 GPB6/KBRST# GPC7/PWUREQ#/BBO/SMCLK2ALT GPE7/L80LLAT/5VT GPD3/ECSCI#/5VT GPD4/ECSMI# DAC GPJ1 IT8587 GPJ3/DAC3/TACH1B ADC BAT_DET BAT_VOLT BAT_DET BAT_VOLT THERM_VOLT TOTAL_CUR MODEL_ID 66 67 69 70 73 GPI0/ADC0 GPI1/ADC1 GPI3/ADC3 GPI4/ADC4 110 111 SMC_BAT SMD_BAT R102 R99 C136 [15] SML1CLK [3,18] H_PECI *0_04 43_1%_04 *10p_50V_NPO_04 117 5VT/SSCE1#/VCEN/TM/GPG0 5VT/( PD )DTR1#/SBUSY/ID7/GPG1 5VT/CTX1/SOUT1/DAT3/ID2/GPH2 GPF6/SMCLK2/PECI TACH0A/GPD6 GPA1/PWM1/5VT GPA5/PWM5/5VT GPA6/PWM6/SSCK/5VT GPA7/PWM7/RIG1#/5VT TMRI0/GPC4 TMRI1/GPC6 [9,16,25,31,32] [16,34] 86 88 SUSB# SUSC# 89 90 [27] TP_CLK [27] TP_DATA KB-SI0 KB-SI1 KB-SI2 KB-SI3 KB-SI4 KB-SI5 KB-SI6 KB-SI7 11 12 14 15 KB-SI0 KB-SI1 KB-SI2 KB-SI3 KB-SI4 KB-SI5 KB-SI6 KB-SI7 11 12 14 15 36 37 38 39 40 41 42 43 44 45 46 51 52 53 54 55 KB-SO0 KB-SO1 KB-SO2 KB-SO3 KB-SO4 KB-SO5 KB-SO6 KB-SO7 KB-SO8 KB-SO9 KB-SO10 KB-SO11 KB-SO12 KB-SO13 KB-SO14 KB-SO15 10 13 16 17 18 19 20 21 22 23 24 KB-SO0 KB-SO1 KB-SO2 KB-SO3 KB-SO4 KB-SO5 KB-SO6 KB-SO7 KB-SO8 KB-SO9 KB-SO10 KB-SO11 KB-SO12 KB-SO13 KB-SO14 KB-SO15 10 13 16 17 18 19 20 21 22 23 24 26 25 [15] [23] PWR_SW# LID_SW# LID_SW# 18 21 CTX0/TMA0/GPB2 GPF0/PS2CLK0/TMB0/CEC/5VT GPF2/PS2CLK1/DTR0#/5VT 5VT/L80HLAT/BAO/GPE0 GPF1/PS2DAT0/TMB1/5VT GPF3/PS2DAT1/RTS0#/5VT CCD_EN 107 [16] 33 PWR_BTN# [11] 28 29 30 26 25 [23] 5VT/FSCE#/GPG3 5VT/FMOSI/GPG4 5VT/FMISO/GPG5 5VT/FSCK/GPG7 INTERRUPT SMC_BAT AC D4 *BAV99 RECTIFIER A [25,31,33] BKL_EN [12] [30,36] SMD_BAT [30,36] BAT_DET AC D3 *BAV99 RECTIFIER A *CV-40mil BT_DET# WLAN_EN [31] [23] [23] IT8587 D 93 GPA2/PWM2/5VT GPA3/PWM3/5VT GPA4/PWM4/5VT BT_EN [31,33] [23] 96 97 98 99 82 83 84 5VT/EGAD/GPE1 5VT/EGCS#/GPE2 5VT/EGCLK/GPE3 GPA0/PWM0/5VT USB_CHARGE_EN 94 5VT/ID3/GPH3 5VT/ID4/GPH4 5VT/ID5/GPH5 5VT/ID6/GPH6 WLAN_PWR_EN 48 119 TACH1/TMA1/GPD7 5VT/CRX0/GPC0 CHG_JAP [36] ALL_SYS_PWRGD 128 CK32KE/GPJ7 CK32K/GPJ6 3G_POWER_EN [23] [12,16,35] [23] GPE4/PWRSW IT8587 VDD3 U25 X4 RTCVCC X1 VCC C Sheet 30 of 45 KBC-ITE IT8587 X2 SQW/OUT VBAT SCL GND SDA SMB_CLK_1338 R390 *0_04 SMC_BAT SMB_DATA_1338 R387 *0_04 SMD_BAT *IDT1338 95 35 17 VDD3 RSMRST# [16] SB_KBCRST# [17,18] 47 CPU_FANSEN 120 124 [28] LOT6_CHG [36] PM_PCH_PWROK [8,16] 123 LAN_WAKEUP# 19 SWI# LID_SW# DD_ON R1 R105 100K_04 *10K_04 BT_DET# 3G_DET# SMC_BAT SMD_BAT BAT_DET R438 R178 R104 R103 R192 47K_04 10K_04 1.5K_04 1.5K_04 10K_04 AC_IN# C141 C172 C185 C156 [17,26] 112 R176 [16] PCLK_KBC PMOSFET_CONTROL# [36] R163 *10_04 BAT_VOLT CPU_FAN R150 101 102 103 105 104 ALSPI_CE# ALSPI_MSI ALSPI_MSO ALSPI_SCLK R110 R109 R108 R107 0_04 0_04 0_04 0_04 HSPI_CE# HSPI_MSI HSPI_MSO HSPI_SCLK AIRPLAN_LED# *20mil_04 HSPI_MSI HSPI_MSO HSPI_SCLK R98 R97 R96 R95 0.1u_10V_X7R_04 *10p_50V_NPO_04 1u_6.3V_X5R_04 0.1u_10V_X7R_04 B KBC_WRESET# HSPI_CE# [15] HSPI_MSI [15] HSPI_MSO [15] HSPI_SCLK [15] [25] MODEL_ID RA RB W540SU Voltage 3.3V 10K X W550SU 0V X 10K W540SU-TPM 1.65V 10K 10K W550SU-TPM 2.18V 5.1K 10K VDD3 Close to EC HSPI_CE# C A KSO16/SMOSI/GPC3 KSO17/SMISO/GPC5 GPC1/SMCLK1/5VT GPC2/SMDAT1/5VT GPF7/SMDAT2/PECIRQT# AVSS VSS1 VSS3 VSS4 VSS5 VSS6 VSS7 75 [30,36] 5VT/DSR0#/GPG6 27 49 91 113 122 VCORE GPB0/RXD/SIN0/5VT GPB1/TXD/SOUT0/5VT IT8587E/FX PJ7 AUTO_LOAD_PWR 56 57 GPI5/ADC5/DCD1# 5VT/CLKRUN#/ID0/GPH0 GPI6/ADC6/DSR1# 5VT/CRX1/SIN1/SMCLK3/ID1/GPH1 [24] DD_ON GPI2/ADC2 C177 0.1u_10V_X7R_04 GPD5/GINT/CTS0#/5VT VDD3 C 125 3G_EN GPJ2/DAC2//TACH0B C397 *1.5p_50V_NPO_04 GPD0/RI1# GPD1/RI2#/5VT 12 108 109 [23] WLAN_DET# H_PROCHOT_EC 24 BRIGHTNESS GPF4/PS2CLK2/5VT GPF5/PS2DAT2/5VT UART [3] 1K_04 100 5VT/SSCE0#/GPG2 100K_04 5VT/RING#/PWRFAIL#/CK32KOUT/LPCRST#/GPB7 GP 115 116 R101 118 [11] SMC_EDP_CLK [11] SMD_EDP_DAT *0_04 SML1DATA WAKE UP [31] [12,24] 71 72 3G_DET# GPJ0/TACH2 GPJ4/DAC4/DCD0# GPJ5/DAC5/RIG0# VDD3 PS/2 85 87 80CLK 3IN1 80CLK 3IN1 58 59 60 61 62 63 64 65 106 R112 *1.5p_50V_NPO_04 GPB3/SMCLK0/5VT GPB4/SMDAT0/5VT PWM [23] [23] 68 J_KB2 *85208-24051 C398 5VT/RTS1#/GPE5 5VT/LPCPD#/GPE6 25 31 32 34 [29] BEEP [25] LED_BAT_CHG [25] LED_BAT_FULL [25] LED_PWR ME_WE W94 GPI7/ADC7/CTS1# SMBUS [30,36] [30,36] [14] 78 [30,36] [30,36] [2] [36] KSI0/STB# KSI1/AFD# KSI2/INIT# KSI3/SLIN# KSI4 KSI5 KSI6 KSI7 76 80 81 SUS_PWR_ACK 24 J_KB1 85208-24051 AVCC 11 26 50 92 114 121 127 GPM0/LAD0 GPM1/LAD1 GPM2/LAD2 GPM3/LAD3 GPM4/LPCCLK LPC GPM5/LFRAME# GPM6/SERIRQ GPD2/LPCRST#/5VT 10K_04 RA *10K_04 10K_04 *10K_04 *10K_04 R171 *10K_04 MODEL_ID R169 10K_04 A RB C AC D2 *BAV99 RECTIFIER KBC_AGND A C162 0.1u_10V_X7R_04 C [30,36] BAT_VOLT AC D8 *BAV99 RECTIFIER Title A [14,16,21] [14,21,23,24,26,31,33,34,36] [2,12,19,21,23,24,26,27,31,32,34] [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,26,27,28,29,31,35] RTCVCC VDD3 3.3V 3.3VS ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ [30] KBC-ITE IT8587 Size Document Number A3 Date: 6-7P-W5409-003 Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 30 of 45 KBC-ITE IT8587 B - 31 B.Schematic Diagrams 126 16 20 [18] GA20 [36] AC_IN# [25] LED_ACIN [16] AC_PRESENT [18] [18] 14 VCC 10 13 22 [15,24] LPC_AD0 [15,24] LPC_AD1 [15,24] LPC_AD2 [15,24] LPC_AD3 [22] PCLK_KBC [15,24] LPC_FRAME# [15,24] LPC_SIRQ [17,23,24,26,27] BUF_PLT_RST# B W54/W55 U5A [29] [16] KBC_AGND R111 U5B C167 *0.1u_10V_X7R_04 3.3VS D VDD3 10u_10V_Y5V_08 C139 0.1u_10V_X7R_04 VDD3 C146 C138 0.1u_10V_X7R_04 L14 HCB1005KF-121T20 *MC-306_32.768KHz Schematic Diagrams 5VS, 3VS, 3.3VM, 1.5VS CPU SUSB SLP_A NMOS SYS15V VDD3 D PR139 PR136 10K_04 100K_04 PQ14A MTNN20N03Q8 VDD3 VDD3 PR47 PC34 [28,34] SLP_A D D 5G SUSB# MTDN7002ZHS6R PC113 *30p_50V_NPO_04 S MTDN7002ZHS6R 3.3VS_EN1 [31,32] PQ33 PC36 [16,32] G SLP_A# 2SK3018S3 S PR137 PC116 [9,16,25,30,32] 0.1u_10V_X7R_04 PQ34A PR138 PC110 *0.1u_10V_X7R_04 4700p_50V_X7R_04 SUSB 100K_04 PQ34B S 100K_04 PR45 100_04 PQ14B MTNN20N03Q8 PR135 Sheet 31 of 45 5VS, 3VS, 3.3VM, 1.5VS CPU D PC37 1M_04 [25,27] DD_ON# D 2G DD_ON PQ12 100K_04 ON ON ON G SUSB ON 2SK3018S3 ON S 100K_04 ON ON 3.3V W/o USB charger 5VS C DD_ON# 470p_50V_X7R_04 PQ13B MTNN20N03Q8 1M_04 3.3V_EN1 2200p_50V_X7R_04 40mil PQ10 2SK3018S3 PJ10 3.3V_SPI PJ8 VIN1 PU5 PC117 [30,33] USB_CHARGE_EN R398 10K_04 R411 1K_04 0.1u_50V_Y5V_06 VA VIN VIN1 DD_ON_LATCH M_BTN# INSTANT-ON PWR_SW# GND R420 100K_04 R423 10K_04 R422 1K_04 DD_ON PC123 0.1u_50V_Y5V_06 VDD3 PWR_SW# C270 C262 *1u_6.3V_X5R_04 R234 *1M_04 R235 *100K_04 P2808B0 R404 [36] VA [15,21] 3.3V_SPI [33] VIN1 [25,33] VDD5 [32,33] SYS15V [24,25,27,32,34] 5V [12,32,33,34,35,36] VIN [12,13,14,19,24,27,28,29,35] 5VS [14,21,23,24,26,30,33,34,36] VDD3 [2,12,19,21,23,24,26,27,32,34] 3.3V [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,26,27,28,29,30,35] 3.3VS B - 32 5VS, 3VS, 3.3VM, 1.5VS CPU *0_04 R220 *0_04 AUTO_LOAD_PWR SLP_A [30] [31,32] A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title [31] 5VS,3VS,3.3VM,1.5VS_CPU Size Document Number Custom Rev 3.0 6-71-W54S0-D03 Date: R219 *2SK3018S3 *100K_04 A Q6 G [30] S 10/8 PC118 C265 3.3V_SPI *MTP3403N3 S D D VIN *0.1u_16V_Y5V_04 *10K_04 *0.1u_16V_Y5V_04 Q7 R399 M_BTN# ON VDD3 VIN [24] B 40mil ON 0.1u_50V_Y5V_06 *OPEN-1mm B VA DD_ON# 2200p_50V_X7R_04 G SUSB PQ15B MTNN20N03Q8 PC35 PC33 PJ11 PQ11B MTNN20N03Q8 PC38 PC32 0.1u_10V_X7R_04 5VS_EN1 PR48 *100_04 3A PR46 Power Plane 5V_EN1 PR43 100_04 3.3V G 1M_04 3A 1M_04 PQ15A MTNN20N03Q8 VIN SYS15V VDD3 PR44 6A PR49 VIN 1000p_50V_X7R_04 NMOS PQ13A MTNN20N03Q8 VIN 5VS 1000p_50V_X7R_04 C140 VIN PQ11A MTNN20N03Q8 C199 SYS15V NMOS EMI NMOS SYS15V VDD5 S 1000p_50V_X7R_04 C285 *OPEN-3mm 1000p_50V_X7R_04 C279 5V PJ9 D 5VS_LO VDD5 5V C B.Schematic Diagrams PR134 [25,30,33] 3.3VS 10u_10V_Y5V_08 VDD3 3.3VS D 3.3VS_LO DD_ON# 0.1u_10V_X7R_04 Wednesday, April 09, 2014 Sheet 31 of 45 Schematic Diagrams 1.05V Series 5V PR141 VIN 280K_04 PU6 D 24 VTT VR Output Voltages 1.1 V 1.05 V VIN VIN VIN VIN VIN TON PC124 VDD 17 18 19 20 31 1u_6.3V_X5R_04 PR153 PJ27 10K_04 *CV-40mil PJ29 PM_SLP_LAN# [9,16,25,30,31] SUSB# [16,31] SLP_A# *OPEN-1mm PJ30 *OPEN-1mm PJ32 *OPEN-1mm BST PC128 26 VCC 1u_6.3V_X5R_04 1.05SGND 23 PC129 0.1u_50V_Y5V_06 PR50 3.3V 0_06 29 28 1.05SGND EN_SKIP AGND 47K_04 [16] PR143 1.05V_LAN_PWRGD 4.7u_25V_X5R_08 6.49K_1%_04 LX LX LX LX LX LX LX PGND PGND PGND PGND PGND PGND PGND PGOOD NC OUT 1.05V_LAN_M PC122 30 10 11 12 13 14 15 16 0_06 0.1u_50V_Y5V_06 ILIM FB G5310QNIU 5A PL6 TMPC0603H-1R0M-Z01 2 PJ24 *OPEN-5mm PR140 2.2_06 PC125 2200p_50V_X7R_04 AGND PR144 C PC134 4.7u_25V_X5R_08 22 21 25 + PC114 PC112 PC111 22u_6.3V_X5R_08 PR151 0_04 C 27 PR152 Sheet 32 of 45 1.05V Series 8.06K_1%_04 PR51 *28mil_06 PR147 20K_1%_04 PC126 *100P_50V_NPO_04 1.05SGND 1.05SGND 1.05VM B 1.05V_LAN_M 1.05VM PJ25 SYS15V PR150 B 3A OPEN_2A PQ35A *MTNN20N03Q8 *5.1K_04 PR145 PC121 PC115 51.1_1%_04 *0.1u_10V_X7R_04 *10u_10V_Y5V_08 PQ35B *MTNN20N03Q8 D 1.05VS_VTT_EN1 PQ36 C416 G 2SK3018S3 S *2200p_50V_X7R_04 SLP_A A [31] A [20,21] 1.05VM [25,31,33] VDD5 [31,33] SYS15V [24,25,27,31,34] 5V [3,5,20,21,35] 1.05V_LAN_M [12,31,33,34,35,36] VIN [14,21,23,24,26,30,31,33,34,36] VDD3 [2,12,19,21,23,24,26,27,31,34] 3.3V ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title Size A3 Date: [32]1.05V series Document Number Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 32 of 45 1.05V Series B - 33 B.Schematic Diagrams Short [16] PC131 PR146 PR142 10_04 For CV test 3.3V D 1.05V_LAN_M IMAX:5A OCP:10A *22u_6.3V_X5R_08 VTT_SELECT low high (V1.1S_VTT) 220u_6.3V_6.3*6.3*4.2 Schematic Diagrams VDD3, VDD5 VDD3/VDD5 VREF PR173 *0_04 PR64 *20mil_04 PC51 A A 1u_6.3V_X5R_04 PR161 PR62 EN_3V EN_5V PC150 PR63 *20mil_04 VREG5 PR54 *0_04 PR55 *0_04 2_06 PR57 C PC42 C C PC47 M990125 PR176 30K_1%_04 B CSOD140SH A PC120 PR175 PC40 0.1u_10V_X7R_04 + R2 PR174 18.7K_1%_04 *1.5M_04 PD10 BAT54SS3 M-SOT323D PC46 A A Vout =2*(1+R1/R2) =2*(1+30K/18.7K) =5.208V SYS5V C SYS10V PC43 PC45 2200p_50V_X7R_04 PD9 BAT54SS3 M-SOT323D 1u_6.3V_X5R_04 PC44 RB751S-40C2 A A VDD5 1000p_50V_X7R_04 PR58 *0_04 VDD5 Short PJ12 *OPEN-5mm R1 PD17 PD18 PC50 PR59 *SK34SA A *5.1_06 PQ39B EMB17A03V 19 A 4.7u_25V_X5R_08 220u_25V_6.3*12 4.7u_25V_X5R_08 10 20 VREG5 PD8 VIN 7A SYS5V 0.01u_50V_X7R_04 VIN1 10/4 add PQ39A PL8 EMB17A03V BCIHP0730-4R7M 4.7UH 5.5A 7.3*6.8*3 PR52 VREF PC153 *28mil_06 PR60 18 17 16 *680K_1%_04 20K_1%_04 Vout =2*(1+R1/R2) =2*(1+13K/20K) =3.3V EMI 21 EN_ALL PR56 4.7u_25V_X5R_08 SYS5V 0.1u_10V_X5R_04 VCLK EN0 2nd: 6-02-5608-CQ0 PR155 *5.1_06 LGATE1 LDO5 LGATE2 VIN 12 PHASE1 GND PAD GND PHASE2 14 C A *SK34SA UGATE1 *20mil_04 PR168 UGATE2 SKIPSEL R2 23 22 + 220u_6.3V_6.3*6.3*4.2 CSOD140SH A 13K F 1/16W SMD0402 PQ38B EMB17A03V PC142 PR172 BOOT1 G5608E 25 15 10 10 11 PD16 *1000p_50V_X7R_04 PD15 R1 + 100p_50V_NPO_04 PC39 C PC151 PC119 B BOOT2 0.1u_10V_X5R_04 PL7 BCIHP0730-4R7M 4.7UH 5.5A 7.3*6.8*3 5A 0.1u_10V_X7R_04 Sheet 33 of 45 VDD3, VDD5 POK PC48 Short SYS3V PJ13 *OPEN-5mm LDO3 PC145 PQ38A EMB17A03V VDD3 1u_6.3V_X5R_04 PC139 *10K_04 4.7u_25V_X5R_08 13 4.7u_25V_X5R_08 VDD3 PC138 24 *1000p_50V_X7R_04 VO1 PC140 0.1u_50V_Y5V_06 EN1 VREF VFB1 VO2 PC148 VIN PC49 1000p_50V_X7R_04 PU2 PR61 220u_6.3V_6.3*6.3*4.2 6-13-18721-28C D03 C SYS15V 0.01u_50V_X7R_04 PC41 2200p_50V_X7R_04 C C VREG5 EN_5V PR53 Battery Mode VDD5 ᕭ Tur e of f a t syst m ᦹ e o ff S MTDN7002ZHS6R S MTDN7002ZHS6R D POWEROFF CHARGE: USB_CHARGE_EN = HI DDON = LO 2G PC130 100K_04 POWER ON: USB_CHARGE_EN = DDON=HI PJ28 *CV-40mil 0.1u_10V_X7R_04 PQ37B SUPPORT USB CHARGER D 5G 0_04 *0_04 PR148 USB_CHARGE_EN PR149 PR154 [30,31] DD_ON D PQ37A DD_ON_EN_VDD [25,30,31] 10K_04 D D [36] G AC_IN S B.Schematic Diagrams PC137 TONSEL PC136 VFB2 EN2 VREG3 VIN 130K_04 130K_04 1000p_50V_X7R_04 PQ16 *2SK3018S3 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ [31] VIN1 [31,32] SYS15V [25,31] VDD5 [12,31,32,34,35,36] VIN [14,21,23,24,26,30,31,34,36] VDD3 Title Size A3 Date: B - 34 VDD3, VDD5 [33]VDD3, VDD5 Document Number Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 33 of 45 Schematic Diagrams DDR 1.5V or 1.35V/0.75VS PCH 1.5VS VIN 1.5V or 1.35V/0.75VS PD4 24 VLDOIN VBST VTT DRVH 22 PC29 0.1u_10V_X5R_04 PR117 21 PR120 PC101 PC102 VTTGND LL 1.5V or 1.35V IMAX:8A OCP:15A PC94 PL4 1.0UH_BCIHP1040-1R0M_11.5*10.2*3 2.2_04 *OPEN-2mm A PC96 PQ30 MTB11N03Q8 0.1u_50V_Y5V_06 2A PC95 4.7u_25V_X5R_08 23 PJ20 PC93 VDDQ Short VDDQ_VTT C RB0540S2 4.7u_25V_X5R_08 PC103 10u_10V_Y5V_08 1000p_50V_X7R_04 A 5V PU4 G5616 VDDQ_VTT 20 Short VDDQ 19 VTTREF PC31 PGOOD S5 VDDQSET S3 C *20mil_04 PR119 6.19K_1%_06 15 14 PR121 13 11 PR126 PR132 10 GND NC *1000p_50V_X7R_04 5V 12 PC107 NC VDDQSET *10_04 PQ29 2_06 PC104 PC105 1.35V ICC_MAX_VDDQ=4.2A PC106 *0.1u_10V_X7R_04 PR125 PR131 5V *0_04 DDR1.5V_PWRGD 47K_04 PR127 10K_1%_04 D 5G 2G SUSC# D PQ31A [16] 8.2K_1%_04 PQ31B PC109 S MTDN7002ZHS6R *0.1u_16V_Y5V_04 S B PJ21 *CV-40mil MTDN7002ZHS6R [16,30] SUSC#_G5616 100K_04 D S PC108 0.1u_10V_X7R_04 PQ32 2SK3018S3 PR133 G SUSB PR112 *20mil_04 PR128 10K_04 VTTEN 10K_04 B [28,31,34] *5.1_06 PR130 PR111 3.3V *10K_1%_04 PR129 5V *1000p_50V_X7R_04 MTB02N03Q8 25 *1000p_50V_X7R_04 5V 3.3V VDDQSET 5V PCH_GPIO46 PCH_GPIO8 PR35 0_04 41.2K_04 3.3V 1.5VS 5V B PQ8 BTN3904N3 VIN VIN VIN VIN VIN VIN TON PC143 PR36 100_04 VDDQ C PR157 280K_04 PU7 24 S PJ5 *CV-40mil S PR42 100K_04 C PJ4 *CV-40mil D S PQ9B MTDN7002ZHS6R 5G D PR40 10K_04 PCH_GPIO24 [18] PQ9A 2G MTDN7002ZHS6R C 1.35V VDD 17 18 19 20 31 PC135 PC133 4.7u_25V_X5R_08 4.7u_25V_X5R_08 1.5VS IMAX:5A OCP:10A PR167 1u_6.3V_X5R_04 3.3V PR159 10_04 BST PC146 26 10K_04 VCC D PR156 PC149 1.5SGND 1u_6.3V_X5R_04 0.1u_50V_Y5V_06 PQ40 PR163 SUSB 0_04 G S [28,31,34] 2SK3018S3 23 EN_SKIP 3.3V 29 SUSC#_G5616 PR162 *0_04 PR165 10K_04 D [16] PR171 0_06 28 PCH1.5VS_PWRGD 1.5SGND PR160 6.49K_1%_04 AGND LX LX LX LX LX LX LX PGND PGND PGND PGND PGND PGND 22 PC144 30 10 11 12 13 14 15 16 0_06 0.1u_50V_Y5V_06 + PGND PGOOD ILIM FB *OPEN-5mm rise time= 3.3ms PC127 PC132 *22u_6.3V_X5R_08 22u_6.3V_X5R_08 PR158 0_04 PR170 *28mil_06 D 21 25 1.5SGND 27 PR164 20K_1%_04 PR169 20K_1%_04 [9,10] VDDQ_VTT [31,36] VA V_VDDQ_DIMM ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ [3,5,9,10] 1.5SGND PC141 220u_6.3V_6.3*6.3*4.2 PC152 2200p_50V_X7R_04 PC147 *100P_50V_NPO_04 PJ26 G5310QNIU 1.5VS PL9 TMPC0603H-1R0M-Z01 PR166 2.2_06 AGND NC OUT PQ7 2SK3018S3 G E 41.2K_04 1 PR41 100K_04 100K_04 PR39 10K_04 1.5V(DEDAULT) DDR1.5V_PWRGD PR34 PR38 PR33 100K_04 VDD3 DDR VOUT D PCH_GPIO24 PR37 Sheet 34 of 45 DDR 1.5V or 1.35V / 0.75VS PCH 1.5VS [25,31,33] VDD5 [24,25,27,31,32] 5V [14,16,19,20,21,22,28] 1.5VS [12,31,32,33,35,36] VIN [12,13,14,19,24,27,28,29,31,35] 5VS [14,21,23,24,26,30,31,33,36] VDD3 [2,12,19,21,23,24,26,27,31,32] 3.3V Title [34]DDR 1.5V or 1.35V/0.75VS PCH 1.5VS Size Document Number Custom Date: Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 34 of 45 DDR 1.5V or 1.35V/0.75VS PCH 1.5VS B - 35 B.Schematic Diagrams VDDQSNS PR118 16 1u_6.3V_X5R_04 COMP 18 17 1u_6.3V_X5R_04 *20mil_04 CS PVCC5 VCC5 PC97 0.1u_10V_X7R_04 PC30 0.1u_10V_X5R_04 PR124 PGND CS_GND MODE PC99 1000p_50V_X7R_04 A *0_04 *0_04 PR32 5V GND *20mil_04 PR123 + PC88 *330UF_2.5V_6.6*6.6*4.2 5V A PC91 PD12 DRVL VTTSNS CSOD140SH PR122 VDDQ *OPEN-10mm *10u_10V_Y5V_08 22u_6.3V_X5R_08 V_VDDQ_DIMM PJ19 15A *20mil_04 Schematic Diagrams VCore 3.3VS RT2 VIN PR78 PC62 PC55 PC69 PC4 G S PC80 PQ28 MDU1516 ULTRASO-8 4.7u_25V_X5R_08 1000p_50V_X7R_04 CSREF 0.1u_50V_Y5V_06 165K_1%_04 330p_50V_X7R_04 4.7u_25V_X5R_08 560p_50V_X7R_04 PC74 PC73 3900p_50V_X7R_04 1000p_50V_X7R_04 5VS C D S 37 APGND PR86 GND 2.2_06 PC16 2.2u_6.3V_X5R_04 1.05V_LAN_M PR84 VR_EN A EMI 2_06 PQ25 MDU1516 ULTRASO-8 PC54 PC57 PC60 PC14 G EMI APGND HG1 PQ26 MDU1512 ULTRASO-8 ROSC(ohm) *130_1%_04 *75_1%_04 *54.9_1%_04 PC27 FSW(Hz) + PC100 + PC98 VCCIN SWN1 PR30 5.1_06 PR114 PC23 10_04 G APGND APGND CSREF FM5822 A PR80 PC26 PR113 *20mil_04 LG1 PC15 0.1u_10V_X7R_04 S PR81 PC92 PL3 0.36UH_10*10*3.5 SW1 PD13 PR82 C PC59 0.22u_10V_X5R_04 0_04 H_CPU_SVIDDAT H_CPU_SVIDALRT# H_CPU_SVIDCLK B VCCIN VIN_CPU PR85 PR87 2_06 PR16 39.2K_1%_04 [35] 5VS PR17 45.3K_1%_04 APGND CSREF EMI 2.2u_6.3V_X5R_04 0.1u_50V_Y5V_06 0_04 PC19 4.7u_25V_X5R_08 0_04 PR88 PC85 0.22u_10V_X5R_04 2_06 PR101 4.7u_25V_X5R_08 PR90 19 17 16 15 14 11 12 10 13 *1000p_50V_X7R_04 VCC_SENSE 1K_04 BST3 SW3 LG3 PVCC PGND HG1 SW1 BST1 LG1 *1000p_50V_X7R_04 [5] PR89 ILIM IOUT VRMP COMP FB DIFFOUT VSN VSP VCC *1000p_50V_X7R_04 VSS_SENSE 0.1u_10V_X7R_04 PR116 10_04 *4.7u_25V_X5R_08 PC20 APGND [5,7] 28 29 30 31 32 33 34 35 36 0_04 C 6.8K_1%_04 PR95 SWN3 PC24 2200p_50V_X7R_04 D PR93 PR31 5.1_06 CSREF PU3 NCP81103MNTXG D APGND 1K_04 C VCCIN PR115 *20mil_04 FM5822 S 27 26 25 24 23 22 21 20 18 CSCOMP CSSUM CSREF CSP3 CSP2 CSP1 DRON PWM2/IMAX HG3 0.01u_50V_X7R_04 10p_50V_NPO_04 D *15u_25V_6.3*4.4 10/4 change G EN VRHOT# SDIO ALERT# SCLK VR_RDY ROSC TSENSE VBOOT 1000p_50V_X7R_04 APGND 25.5K_1%_04 PC154 PL5 0.36UH_10*10*3.5 PD14 PR22 + 330UF_25V SW3 PR100 6.8K_1%_04 PC18 PC89 PR96 2_06 PQ27 LG3 MDU1512 ULTRASO-8 470p_50V_X7R_04 PR92 EMI 27.4K_1%_06 1K_04 PC76 PC79 HG3 PR102 CSCOMP PR98 H_PROCHOT# DELAY_PWRGD6 TSENSE PC7 1000p_50V_X7R_04 CSREF [35] B 2200p_50V_X7R_04 H_CPU_SVIDDAT H_CPU_SVIDALRT# H_CPU_SVIDCLK [5] H_CPU_SVIDDAT [5] H_CPU_SVIDALRT# [5] H_CPU_SVIDCLK 49.9K 325K 34.8K 450K EMI TSENSE CSREF 5VS 5VS APGND 3.48K_1%_04 SWN3 PR110 CSREF PR104 PC81 *2K_1%_04 PR103 0.047u_10V_X7R_04 CSP1 *20K_04 PR29 PR99 3.48K_1%_04 SWN1 CSP3 2K_1%_04 CSP3 *20K_04 PR28 PR83 *75_1%_04 PR79 10K_04 RT1 100K_1%_NTC_04 30.9K PUT COLSE TO VCORE HOT SPOT CSP2 ASM for phase [3] H_PROCHOT# [16] DELAY_PWRGD A ASM for phase ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ [5,8] VCCIN [3,5,20,21,32] 1.05V_LAN_M [12,31,32,33,34,36] VIN [12,13,14,19,24,27,28,29,31] 5VS [3,6,9,10,11,12,13,14,15,16,17,18,20,21,22,23,24,25,26,27,28,29,30,31] 3.3VS Title B - 36 VCore [35]VCORE Size Document Number Custom Date: *20mil_04 3.3VS PR105 0.047u_10V_X7R_04 A PR13 1.05V_LAN_M PC82 B.Schematic Diagrams PC3 1000p_50V_X7R_04 Sheet 35 of 45 VCore PR91 49.9_1%_04 PC22 CSP3 CSP2 CSP1 CSSUM VIN_CPU EMI + 390uF_2.5V_10m_6.3*6 PC83 *4.7u_25V_X5R_08 VR_EN 0_04 PJ2 *4mm VIN_CPU D PR77 ALL_SYS_PWRGD PC53 4.7u_25V_X5R_08 APGND PC21 [12,16,30] PC2 *1000p_50V_X7R_04 75K_1%_04 D PC28 *1000p_50V_X7R_04 EMI PR106 PC78 300K_1%_0603 SWN1 PR108 PR107 PC25 *1000p_50V_X7R_04 PJ18 *CV-40mil 300K_1%_0603 SWN3 PR109 *1000p_50V_X7R_04 PUT COLSE TO VCORE Phase Inductor *390uF_2.5V_10m_6.3*6 100K_1%_NTC_04 100K_04 VIN Rev 3.0 6-71-W54S0-D03 Wednesday, April 09, 2014 Sheet 35 of 45 Schematic Diagrams Charger, DC IN PR23 *20mil_04 VA PR24 *470K_04 SMART CHARGER VIN D PQ21 EMB20P03V V_BAT D PR94 *10K_06 6-15-32023-7B0 PQ1 MTP3403N3 S D 14 LDR 16 C 10_04 G VAC VDDP 15 IACM IACP AC AV A PD11 MDL914S2 D PQ5 2SK3018S3 G 100K_04 LX HDR LDR ICHP BST ICHM VAC SDA VDDP SCL IACM IAC IACP COMP OZ8681LN-E ACAV PU1 100K_1%_04 S8254CTL VDDA 4.7u_25V_X5R_08 *4.7u_25V_X5R_08 0.1u_50V_Y5V_06 PC63 PC6 4.7u_25V_X5R_08 PC66 PC65 4.7u_25V_X5R_08 PC64 10_04 13 ICHP BTD-05TEAB/*BTD-06RC1B ICHM 11 OZ8681 : 6-02-08681-CQ0 OZ8681LN-E : 6-02-08681-CQ1 PR179 330_04 PR180 330_04 10 10/18 IAC1 COMP_PU12 VDDA_OZ [30] BAT_DET 10_04 SMC_BAT [30] SMD_BAT [30] TOTAL_CUR PMOSFET_CONTROL# PC58 PC68 *BTD-05TEAB/*BTD-06RC1B W540SU PC9 30p_50V_NPO_04 [30] PR7 100_04 PC5 1u_16V_X5R_06 1u_16V_X5R_06 GND_SIGNAL PC67 47p_50V_NPO_04 [30] Sheet 36 of 45 Charger, DC IN PC10 30p_50V_NPO_04 GND_SIGNAL 0.47u_10V_Y5V_04 0_04 Hi -Battery in Charge Low -Battery remove no charge EC GPIO PD pin EMI PR9 C JBAT1 L6 SMC_BAT HCB1005KF-121T20 SMD_BAT L5 HCB1005KF-121T20 BAT_DET PR178 0_04 L4 HCB1005KF-121T20 PR18 0_04 PR76 *28mil_06 1u_25V_Y5V_08 1000p_50V_X7R_04 PR26 *0_04 PC56 100K_04 LOT6_CHG JBAT2 PC77 G S [30] PR21 D PQ2 2SK3018S3 17 S PR20 12 PR6 C RB0540S2 PR4 W550SU PR177 LX BST PD2 A 300K_1%_04 10_04 4700p_50V_X7R_04 BASE VA 4.7u_25V_X5R_08 HDR *0_06 PR3 PC13 PC75 0.1u_50V_Y5V_06 PR2 C PR11 EMI PR14 0_06 4.7u_25V_X5R_08 PC61 PR97 4.7u_25V_X5R_08 PC86 PQ23B EMB17A03V PR12 0.01_1%_32 4.7u_25V_X5R_08 PC87 EMI BTD-05TEAB for W540SU1 BTD-06RC1B for W94SU ᣨ ᅙ JBATTA PL2 8.2UH_6.8*7.3*3 PC17 2200p_50V_X7R_04 PR19 2_06 4.7u_25V_X5R_08 10 4.7u_25V_X5R_08 PC71 10_04 PC8 4700p_50V_X7R_04 PC72 PR70 15K_1%_04 PR73 PR69 100K_04 10_04 4.7u_25V_X5R_08 0.1u_50V_Y5V_06 PR1 470K_04 PR67 0.01_1%_32 PR74 PC1 PQ23A EMB17A03V VA1 PQ19 EMB20P03V PC52 VA PC70 10/18 VJACK PL10 HCB2012KF-800T80 PR10 24K_1%_04 PC11 30p_50V_NPO_04 GND_SIGNAL GND_SIGNAL GND_SIGNAL D PQ20 EMB20P03V PR75 100K_04 VDD3 G S PR27 PC12 60.4K_1%_04 *0.1u_16V_Y5V_04 A PD20 A *MMSZ5232BS PD7 PR8 PD19 A PD6 *SS1040WG PR5 100K_04 VDD3 C C [30] G A PD1 ZD5245BS2 PQ3 2SK3018S3 10K_04 PR66 PR68 100K_04 10K_04 PR72 20K_1%_04 PD3 VA C A AC_IN PQ6 DTC114EUA B AC_IN# [30] C VDD3 C B BAT_DET BAT_VOLT 10/18 PD5 *SS1040WG V_BAT PR15 300K_1%_04 A PJ1 *OPEN-4mm PQ4 MTP3J15N3 S D A PR25 *0_04 *SS1040WG VA C 10/21 C 10/18 SMD_BAT VJACK *MMSZ5232BS B C SMC_BAT W/O PEAK SHIFT [30] CHG_JAP E D PQ18 2N3904 PQ17 G PR71 10K_04 S A E C ZD5245BS2 B EC GPIO (PD) pin; Hi -Pmosfet open; Low Pmosfet turn on 2SK3018S3 AC_IN PR65 100K_04 [33] A BAT DET(BATTERY INTERNAL) : 2S / 5K / NT1912 2S / 10K / NT1908 3S / 2K 3S/2800mAH / 4.02K 4S / 390 W/ PEAK SHIFT 4S/2800mAH /7.15K ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title [31] [12,31,32,33,34,35] [14,21,23,24,26,30,31,33,34] VA VIN VDD3 Date: [36]CHARGER,DC IN Size Document Number Custom Rev 3.0 6-71-W54S0-D03 Sheet Wednesday, April 09, 2014 36 of 45 Charger, DC IN B - 37 B.Schematic Diagrams GND1 GND2 HDR_R J_DC_JACK1 50932-00301-001 Schematic Diagrams Audio Board USB PORT 4ASR1 *0_04 2ASR1 *0_04 5ASR1 *0_04 D Port3 3ASR1 *0_04 6ASR1 *0_04 60 mil ASC4 0.1u_16V_Y5V_04 D ASJ_USB1 ASGND ASL6 ASUSB_PN1 ASUSB_PP1 *WCM2012F2S-161T03-short ASUSB_PN1_R ASUSB_PP1_R DATA_L DATA_H GND B.Schematic Diagrams GND1 GND2 GND3 GND4 V+ GND1 GND2 GND3 GND4 *0_04 ASC2 22u_6.3V_X5R_08 1ASR1 ASC3 22u_6.3V_X5R_08 AS_USBVCC PCBA CHECK US04036BCA081 6-21-B49C0-104 6-21-B49B0-104 ASGND TO M/B Sheet 37 of 45 Audio Board AUDIO JACK ASJ_MIC1 R C AS_USBVCC ASHEADPHONE-R ASHEADPHONE-L ASMIC_SENSE ASHP_SENSE ASUSB_PN1 ASUSB_PP1 ASSPKOUTR+ ASSPKOUTRAS_AUDG ASGND FCM1005KF-121T03 ASMIC1-L FCM1005KF-121T03 ASL2 C ASC6 ASC5 L 2SJ-T351-S23 680p_50V_X7R_04 680p_50V_X7R_04 MIC IN ASJ_AUDIO1 10 11 12 13 14 ASMIC1-R ASMIC1-L ASMIC_SENSE ASMIC1-R ASL1 6-20-B2800-106 BLACK AS_AUDG ASHP_SENSE ASHEADPHONE-R ASR2 56_04 ASL3 FCM1005KF-121T03 ASHEADPHONE-L ASR3 56_04 ASL4 FCM1005KF-121T03 85201-14051-01 PCB Footprint = 85201-14X5_L ASJ_HP1 R ASR4 ASR1 ASC8 *1K_04 *1K_04 680p_50V_X7R_04 L 2SJ-T351-S23 ASC7 680p_50V_X7R_04 HEADPHONE 6-20-B2800-106 BLACK B B AS_AUDG ASC9 *0.1u_16V_Y5V_04 ASC11 *0.1u_16V_Y5V_04 ASC1 *0.1u_16V_Y5V_04 ASC10 *0.1u_16V_Y5V_04 ASGND ASSPKOUTR+ ASR5 0_04 ASSPKOUTR- ASR6 0_04 ASC13 *1u_6.3V_X5R_04 ASSPKOUTR+_R ASSPKOUTR-_R ASC14 *180p_50V_NPO_04 AS_AUDG ASC12 *180p_50V_NPO_04 ASJ_SPKR1 J_SPK1 2 85204-02001 85204-02R 6-20-43150-102 6-20-43110-102 Close to AJ_AUDIO1 A ASH5 O6X4_5B3X1_5D3X1_5 ASH1 C59D59N ASH2 ASGND A ASH3 MTH8_0D2_8 ASGND AS_AUDG Title MTH8_0D2_8 ASGND ASGND ASGND Size A3 Date: B - 38 Audio Board DMFWP!DP/!!ᙔ Ϻ ႝ တ [37]AUDIO BOARD 6-71-W54S8-D02 Document Number Wednesday, April 09, 2014 Sheet 37 Rev 2.0 of 45 Schematic Diagrams Power Switch Board PCBA CHECK POWER SW & LED SS_3.3VS POWER SWITCH LED 1SSMR *0_04 4SSMR *0_04 2SSMR *0_04 5SSMR *0_04 3SSMR *0_04 6SSMR *0_04 SSR1 D D 220_04 20mil A SSC2 *0.1u_16V_Y5V_04 SSJ_SW1 SSMGND SSD2 RY-SP150DBW71-5A 20mil SS_3.3VS 6-52-56001-023 6-52-56001-028 6-52-56000-020 6-52-56001-022 SSMGND C C SSMH1 6-53-3050B-042 POWER BUTTON SSPWR_SW1 TJG-532-V-T/R MTH6_0D2_2 SSM_BTN# SSMGND SSMGND SSC1 SSMH2 SSD1 0.1u_50V_Y5V_06 *V15AVLC0402 SSH1 H2_2B4_2D2_2 VARISTOR MTH6_0D2_2 SSMGND Sheet 38 of 45 Power Switch Board 6-24-30003-006 SSMGND SSMGND SSMGND B B A A DMFWP!DP/!!ᙔ Ϻ ႝ တ Title Size A3 Date: [38] POWER SWITCH BOARD Document Number 6-7P-W5409-003 Rev 2.0 6-71-W54SS-D02 Wednesday, April 09, 2014 Sheet 38 of 45 Power Switch Board B - 39 B.Schematic Diagrams 85201-04051 SSMGND SSM_BTN# C ... User’s Manual Information about dri-vers (e.g VGA & audio) is also found in the User’s Manual The manual is shipped with the computer Operating systems (e.g Window 8, etc.) have their own manuals... /or registered trademarks of their respective companies II Preface About this Manual This manual is intended for service personnel who have completed sufficient training to undertake the maintenance... HDD) C-2 X Introduction Chapter 1: Introduction Overview This manual covers the information you need to service or upgrade the W970SUW series notebook computer Information about operating the