Clevo N240JU N241JU service manual

N240JU / N241JU Preface Notebook Computer N240JU / N241JU Service Manual Preface I Preface Notice The company reserves the right to revise this publication or to change its contents without notice Information contained herein is for reference only and does not constitute a commitment on the part of the manufacturer or any subsequent vendor They assume no responsibility or liability for any errors or inaccuracies that may appear in this publication nor are they in anyway responsible for any loss or damage resulting from the use (or misuse) of this publication This publication and any accompanying software may not, in whole or in part, be reproduced, translated, transmitted or reduced to any machine readable form without prior consent from the vendor, manufacturer or creators of this publication, except for copies kept by the user for backup purposes Preface Brand and product names mentioned in this publication may or may not be copyrights and/or registered trademarks of their respective companies They are mentioned for identification purposes only and are not intended as an endorsement of that product or its manufacturer Version 1.0 September 2015 Trademarks Pentium and Celeron are trademarks of Intel Corporation Windows® is a registered trademark of Microsoft Corporation Other brand and product names are trademarks and /or registered trademarks of their respective companies II Preface About this Manual This manual is intended for service personnel who have completed sufficient training to undertake the maintenance and inspection of personal computers It is organized to allow you to look up basic information for servicing and/or upgrading components of the N240JU / N241JU series notebook PC The following information is included: Chapter 1, Introduction, provides general information about the location of system elements and their specifications Chapter 2, Disassembly, provides step-by-step instructions for disassembling parts and subsystems and how to upgrade elements of the system Preface Appendix A, Part Lists Appendix B, Schematic Diagrams Appendix C, Updating the FLASH ROM BIOS III Preface IMPORTANT SAFETY INSTRUCTIONS Follow basic safety precautions, including those listed below, to reduce the risk of fire, electric shock and injury to persons when using any electrical equipment: Preface Do not use this product near water, for example near a bath tub, wash bowl, kitchen sink or laundry tub, in a wet basement or near a swimming pool Avoid using a telephone (other than a cordless type) during an electrical storm There may be a remote risk of electrical shock from lightning Do not use the telephone to report a gas leak in the vicinity of the leak Use only the power cord and batteries indicated in this manual Do not dispose of batteries in a fire They may explode Check with local codes for possible special disposal instructions This product is intended to be supplied by a Listed Power Unit with an AC Input of 100 - 240V, 50 - 60Hz, DC Output of 19V, 2.1A (40 Watts) minimum AC/DC Adapter FCC Statement This device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions: This device may not cause harmful interference This device must accept any interference received, including interference that may cause undesired operation IV Preface Instructions for Care and Operation The notebook computer is quite rugged, but it can be damaged To prevent this, follow these suggestions: Don’t drop it, or expose it to shock If the computer falls, the case and the components could be damaged Do not expose the computer to any shock or vibration Do not place anything heavy on the computer Keep it dry, and don’t overheat it Keep the computer and power supply away from any kind of heating element This is an electrical appliance If water or any other liquid gets into it, the computer could be badly damaged Do not leave it in a place where foreign matter or moisture may affect the system Don’t use or store the computer in a humid environment Do not place the computer on any surface which will block the vents Preface Do not expose it to excessive heat or direct sunlight Do not place it on an unstable surface Follow the proper working procedures for the computer Shut the computer down properly and don’t forget to save your work Remember to periodically save your data as data may be lost if the battery is depleted Do not turn off the power until you properly shut down all programs Do not turn off any peripheral devices when the computer is on Do not disassemble the computer by yourself Perform routine maintenance on your computer V Preface Avoid interference Keep the computer away from high capacity transformers, electric motors, and other strong magnetic fields These can hinder proper performance and damage your data Take care when using peripheral devices Use only approved brands of peripherals Unplug the power cord before attaching peripheral devices Preface Power Safety The computer has specific power requirements:  VI • • Power Safety Warning • Before you undertake any upgrade procedures, make sure that you have turned off the power, and disconnected all peripherals and cables (including telephone lines and power cord) It is advisable to also remove your battery in order to prevent accidentally turning the machine on • • • Only use a power adapter approved for use with this computer Your AC adapter may be designed for international travel but it still requires a steady, uninterrupted power supply If you are unsure of your local power specifications, consult your service representative or local power company The power adapter may have either a 2-prong or a 3-prong grounded plug The third prong is an important safety feature; not defeat its purpose If you not have access to a compatible outlet, have a qualified electrician install one When you want to unplug the power cord, be sure to disconnect it by the plug head, not by its wire Make sure the socket and any extension cord(s) you use can support the total current load of all the connected devices Before cleaning the computer, make sure it is disconnected from any external power supplies Do not plug in the power cord if you are wet Do not use the power cord if it is broken Do not place heavy objects on the power cord Preface Battery Precautions • Only use batteries designed for this computer The wrong battery type may explode, leak or damage the computer • Do not continue to use a battery that has been dropped, or that appears damaged (e.g bent or twisted) in any way Even if the computer continues to work with a damaged battery in place, it may cause circuit damage, which may possibly result in fire • Recharge the batteries using the notebook’s system Incorrect recharging may make the battery explode • Do not try to repair a battery pack Refer any battery pack repair or replacement to your service representative or qualified service personnel • Keep children away from, and promptly dispose of a damaged battery Always dispose of batteries carefully Batteries may explode or leak if exposed to fire, or improperly handled or discarded • Keep the battery away from metal appliances • Affix tape to the battery contacts before disposing of the battery • Do not touch the battery contacts with your hands or metal objects Battery Guidelines Preface The following can also apply to any backup batteries you may have • If you not use the battery for an extended period, then remove the battery from the computer for storage • Before removing the battery for storage charge it to 60% - 70% • Check stored batteries at least every months and charge them to 60% - 70%  Battery Disposal The product that you have purchased contains a rechargeable battery The battery is recyclable At the end of its useful life, under various state and local laws, it may be illegal to dispose of this battery into the municipal waste stream Check with your local solid waste officials for details in your area for recycling options or proper disposal Caution Danger of explosion if battery is incorrectly replaced Replace only with the same or equivalent type recommended by the manufacturer Discard used battery according to the manufacturer’s instructions Battery Level Click the battery icon in the taskbar to see the current battery level and charge status A battery that drops below a level of 10% will not allow the computer to boot up Make sure that any battery that drops below 10% is recharged within one week VII Preface Related Documents You may also need to consult the following manual for additional information: User’s Manual on CD/DVD This describes the notebook PC’s features and the procedures for operating the computer and its ROM-based setup program It also describes the installation and operation of the utility programs provided with the notebook PC System Startup Preface Remove all packing materials Place the computer on a stable surface Insert the battery and make sure it is locked in position Securely attach any peripherals you want to use with the computer (e.g keyboard and mouse) to their ports Attach the AC/DC adapter to the DC-In jack at the rear of the computer, then plug the AC power cord into an outlet, and connect the AC power cord to the AC/DC adapter Use one hand to raise the lid/LCD to a comfortable viewing angle (do not exceed 127 degrees); use the other hand (as illustrated in Figure 1) to support the base of the computer (Note: Never lift the computer by the lid/LCD) Press the power button to turn the computer “on” 127 ? Figure Opening the Lid/LCD/ Computer with AC/DC Adapter Plugged-In  Shut Down Note that you should always shut your computer down by choosing the Shut down command in Windows (see below) This will help prevent hard disk or system problems Click Settings in the Charms Bar (use the Windows Logo Key + C key combination to access the Charms Bar) and choose Shut down from the Power menu Or Choose Shut down or sign out > Shut down from the context menu (use the Windows Logo Key + X key combination to access the context menu) VIII Schematic Diagrams VDDQ_VTT, 1.5VS, 1.8VS VIN VDDQ VLDOIN VBST VTT DRVH 22 21 Z3710 PC38 0.1u_10V_X5R_04 PR180 0_04 VDDQ Z3718 *20mil_04 Z3704 Z3705 Z3708 VTTREF COMP VDDQSNS S5 VDDQSET S3 *1000p_50V_X7R_04 PR60 16 Z3714 PR65 15 14 Z3715 PR63 Z3716 PC41 PC40 C PR179 *5.1_06 PR43 3.3V PC29 PC30 PR61 GND 10K_04 *0_04 5V 47K_04 [6,29] B PR52 100K_04 PR55 PR51 PJ53 *CV-40mil VTTEN SUSC#_G5616 PC39 PR57 *0.1u_10V_X7R_04 [6,24,28] 0_04 G SUSC# PQ2 *MTN7002ZHS3 ^,KZd PC148 *10mil_04 G PR59 G SUSB CSOD140SH PR50 5V S [15,17,25] Z3717 2_06 *10K_04 + D PQ1B S MTDK5S6R 8.2K_1%_04 0_04 [10,25] [2,9,13,14] [13,14] 1.8VA V_VCCDDQ VDDQ_VTT [3,4,5,6,7,13,14,15,16,17,18,19,20,21,22,23,24,25,30] [3,6,7,16,17,19,20,21,25] [2,5,6,7,10,17,21,24,25,26,28,29,31] [17,20,25,29,30] [6,16,25,26,28,29,30,31] [2,20,25,26,28] [26,28] 3.3VS 3.3V VDD3 5V VIN VDD5 VDD5_LDO5 D PQ1A S MTDK5S6R PR56 PC37 *0_04 *0.1u_10V_X7R_04 PJ7 *CV-40mil PR62 10 10K_1%_04 PD1 VDDQ_PW RGD *10K_1%_04 PR54 5V 22.6K_1%_04 13 11 *1000p_50V_X7R_04 *20mil_04 D 5V PR53 NC NC Z3706 PC32 VDDQSET *10_04 B 5V PGOOD Z3713 PR44 *1000p_50V_X7R_04 CS PVCC5 VCC5 18 17 14A PC143 PQ36B EMB17A03V 25 PC33 MODE Z3712 1u_6.3V_X5R_04 PR45 0.1u_10V_X5R_04 PGND CS_GND Z3711 1u_6.3V_X5R_04 5V Z3703 GND 20 19 A *20mil_04 *0_04 *0_04 DRVL 12 PR47 PR48 PR49 LL VTTSNS 0.1u_16V_Y5V_04 VTTGND 0.1u_16V_Y5V_04 A V_VCCDDQ PJ22 *OPEN-10mm 330uF_2.5V_12m_6.6*6.6*4.2 *20mil_04 Z3702 VDDQ PL10 BCIHP0730-1R0M PR46 *10u_10V_Y5V_08 PC34 Sheet 27 of 38 VDDQ_VTT, 1.5VS, 1.8VS 24 PC35 VDDQ 5V PR58 *100K_04 [2,27] DDR_VTT_PG_CTRL [2,27] DDR_VTT_PG_CTRL C C 1.8VA VDD3 1A PC166 0.1u_10V_X5R_04 VDD5_LDO5 PR189 PC162 D02 PR188 D PC170 S D02 ෑᶵᶲẞ G *0_04 PR185 PJ28 *2200p_50V_X7R_04 *40mil PC168 PQ34 *1u_6.3V_X5R_04 SLP_SUS 0_04 *MTN7002ZHS3 D [25] PR192 VA_EC_EN VCNTL POK VOUT *100K_04 VDD3 [24,25,28] VIN NC VFB PJ27 *OPEN-2mm 1A 1.8VA EN GND GND V1.8 Ra PC169 PC165 PC164 PC163 12.7K_1%_04 PR187 Rb ^,KZd PR186 10u_6.3V_X5R_06 1.8V_PWRGD 0.1u_16V_Y5V_04 PJ54*40mil 1u_10V_Y5V_06 ଉ⊓ᣨᅙPIN6˻ PU10 G9661-25ADJF11U 10u_6.3V_X5R_06 47K_04 82p_50V_NPO_04 PC167 10u_6.3V_X5R_06 B.Schematic Diagrams Z3701 PC146 PC31 22u_6.3V_X5R_06 ^,KZd 1A PC144 0.1u_50V_Y5V_06 PC36 10u_6.3V_X5R_06 PC145 4.7u_25V_X5R_08 PJ6 *OPEN-2mm PC147 4.7u_25V_X5R_08 VDDQ_VTT PQ36A EMB17A03V Z3709 23 A C RB0540S2 0.1u_50V_Y5V_06 VDDQ_VTT 10 PD2 A 5V PU2 G5616 10K_1%_04 D ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title Size A3 Date: B - 28 VDDQ_VTT, 1.5VS, 1.8VS [27] VDDQ,VDDQ_VTT,1.5VS,1.8VS Document Number N240JU_N250JU 6-71-N24J0-D02A Thursday, August 27, 2015 Sheet 27 Rev 1.0 of 39 Schematic Diagrams 1.0V Series 1.0V For CV test PJ2 PR39 VDD3 100K_04 *CV-40mil VIN 1mm PC108 ^,KZd 16 PR145 0.1u_10V_X7R_04 BST TON DH VOUT LX 13 EN_PSV PL6 BCIHP0730-1R0M ILIM VFB VDD 11 PGOOD DL 10 VDD5_LDO5 G5602R41U 10K_04 PR136 VDD3 [25,29] + PC132 1u_6.3V_X5R_04 PR42 14 C 17 1.0VA ^,KZd PQ37B EMB17A03V NC PGND PGND NC AGND PJ19 *OPEN-10mm PR142 8.87K_1%_04 PC100 14A V1.0 330uF_2.5V_12m_6.6*6.6*4.2 1u_6.3V_X5R_04 VCC D 0_04 C Sheet 28 of 38 1.0V Series 1.0VA_PW RGD 1.0VA_PW RGD PR144 10K_1%_04 PC101 *15p_50V_NPO_04 ^,KZd 1.0DX_MODPHY 1.0VA PR143 30K_1%_04 3A B PR176 1.0DX_MODPHY 3A PQ27 *AP9430GYT-HF VDD5 3.3VA PJ21 *OPEN-3mm PC142 PQ28B *NDC7001C B *1u_6.3V_X5R_04 PR174 *10K_04 *10K_04 PR172 *1.5K_04 D MPHY_PW REN# 2nd source G5016 EM5290 PCBfootprint: TDFN14-2X3MM-A [6,24,27] 1.05DX_EN1 PC141 PR173 *330_04 PR171 *0.01u_50V_X7R_04 *100_04 D *100K_04 1.0VS G PC129 10 0.1u_16V_Y5V_04 PC131 220p_50V_NPO_04 1.0VS PQ26 *MTN7002ZHS3 D02 ෑᶵᶲẞ A 0109 PR40 VDD3 SUSC# PC27 PC139 1u_6.3V_X5R_04 0.1u_10V_X7R_04 1.0VA 5A PQ28A *NDC7001C PQ29 *MTN7002ZHS3 0109 PR41 10K_04 A G S CT2 MPHY_PW REN PR175 PJ16 0.1u_16V_Y5V_04 *OPEN-5mm EN2 PC133 220p_50V_NPO_04 OUT2 OUT2 CT1 [6] 1.0VA PC130 1.0VT OUT1 OUT1 VBIAS 12 0.1u_16V_Y5V_04 IN2 IN2 13 14 PC134 IN1 IN1 GND 4A 1.0VT GND 0.1u_16V_Y5V_04 EM5209 11 PJ20 *OPEN-3mm EN1 1.0VA PU9 15 PC138 S 1.0VA 10K_04 SUSB# PC26 0.1u_10V_X7R_04 [6,16,20,24,25,28,29] [10] 1.0DX_MODPHY [5,8,10,29,31] 1.0VA [5,9,25,29] 1.0VS [5,6,8,9,30] 1.0VT [2,5,6,7,10,17,21,24,25,26,27,29,31] VDD3 [3,6,7,16,17,19,20,21,25,27] 3.3V [3,4,5,6,7,13,14,15,16,17,18,19,20,21,22,23,24,25,30] 3.3VS [2,20,25,26] VDD5 [17,20,25,27,29,30] 5V [6,16,25,26,27,29,30,31] VIN [4,5,6,7,10,24,25] 3.3VA [26,27] VDD5_LDO5 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title Size A3 Date: [28] 1.0V SERIES Document Number N240JU_N250JU 6-71-N24J0-D02A Thursday, August 27, 2015 Sheet 28 Rev 1.0 of 39 1.0V Series B - 29 B.Schematic Diagrams PC103 12 0_04 PC107 PC99 VA_EC_EN D02 ᦘᷱECి⇞PIN 15 VDD5_LDO5 [24,25,27] 1mm PC105 0.1u_10V_X7R_04 C PJ52 PR146 0_06 PC95 PD15 1mm A PJ1 [6,16,20,24,25,28,29] SUSB# VTT_SELECT VTT VR Output Voltages low 1.1 V PJ3 high (V1.1S_VTT) 1.05 V [6,24,25] SLP_SUS# PQ37A EMB17A03V 4.7u_25V_X5R_08 PU5 4.7u_25V_X5R_08 1.0VA_EN *1mm D CSOD140SH PJ4 DD_ON 10 [20,24,25,26] 820K_1%_06 0.1u_50V_Y5V_06 PR148 Schematic Diagrams VCore, VCCGT, VCCSA, VCCIO PC175 CSN_GT1 [30] PQ15 MDU1512 ULTRASO-8 G ^,KZd 2200p_50V_X7R_04 [30] LG_GT2 PR193 VCCGT EMI่Ķ EC8 + PC58 *25TQC15MYFB PC174 PR140 2200p_50V_X7R_04 220u_25V_6.3*12 SW N_GT2 *20mil_04 [30] s'd D VCCGT_L CSN_GT2 *20mil_04 [30] PC135 *330uF_2.5V_12m_6.6*6.6*4.2 PC117 330uF_2.5V_12m_6.6*6.6*4.2 2.2_06 PR194 2.2_06 PC23 PC24 PC25 CSN_SA PQ18B EMB17A03V 2.2u_6.3V_X5R_04 5A PR34 [30] 2.2_06 [30] PR195 2.2_06 ^,KZd [30] SW _CORE [30] LG_CORE PR164 PQ22 *MDU1512 ULTRASO-8 G [6,16,20,24,25,28] SUSB# SUSB# VOUT VOUT VOUT *M5938 OPEN_4mil PJ13 EN VBIAS PR151 *200_04 PJ14 *CV-40mil *RB0540S2 C PJ15 *OPEN-3mm GATE GND [30] 3A ĞĨĂƵůƚ ^,KZd PC124 [3,8,9] VCCIO_OUT [11,30] VCCGT [9,30] VCCSA [9,30] VCCIN *1u_6.3V_X5R_04 PD16 1.0VA_PW RGD + VCCIO_OUT 3A 5V ^,KZd PC140 s/KͺKhd 1.0VS PC121 A *0_04 A [25,28] PC120 PR156 *10K_04 PR159 PC119 ᦘᷱ₅ཷ VCCIO_EN PC28 + B *10u_6.3V_X5R_06 *10u_6.3V_X5R_06 VOUT *10u_6.3V_X5R_06 *10u_6.3V_X5R_06 VIN VCCIN PJ18 *OPEN-10mm VCCIO_OUT ᦘᷱ₅ཷ ON PU8 *MC74VHC1G08DFT2G PC128 C EMI ෑᶲẞ 0.1u_50V_Y5V_06 VDDQ_PW RGD PC126 [6,27] CRB:DDR1.2V_PWRGD PDG:SUSB# *0.1u_16V_Y5V_04 PC125 PJ12 *OPEN-3mm PU7 VDD3 PR163 *20mil_04 CSN_CORE s/KͺKhd 1.0VA [30] 2.2_06 D02A B *25TQC15MYFB PC177 2200p_50V_X7R_04 PR196 s/E *20mil_04 29A EMI ෑᶲẞ D02A 220u_25V_6.3*12 t,ϭDϮϮϭϭϮKd SW N_CORE PL9 CMME063T-R15MS0R907 VCCIN_L SW _CORE PQ23 MDU1512 ULTRASO-8 G 4.7u_25V_X5R_08 4.7u_25V_X5R_08 D G HG_CORE *20mil_04 2200p_50V_X7R_04 PAD PC106 PJ5 *OPEN-5mm S LG_SA [30] VCCSA_L D LG PQ21 MDU1516 ULTRASO-8 S VCC PR158 5A + PC59 330uF_2.5V_12m_6.6*6.6*4.2 GND PC176 PC116 + VCCSA SW N_SA PL8 BCIHP0730-R47M SW _SA PC118 EMI่Ķ EC9 330u_2.5V_V_B POWER SLOUTION 5V EN SW _SA *20mil_04 22u_6.3V_X5R_06 SW PR157 22u_6.3V_X5R_06 DRON HG PWM PQ18A EMB17A03V HG_SA PR149 2.2_06 BST [30] PW M_SA 0.22u_16V_Y5V_04 1 [30] 10 PC111 PU6 NCP81253 PC115 s^ S 2.2_04 4.7u_25V_X5R_08 4.7u_25V_X5R_08 PR147 C D02A VIN PC113 *1000p_50V_X7R_04 Sheet 29 of 38 VCore, VCCGT, VCCSA, VCCIO EMI ෑᶲẞ D02A VIN PC114 D EMI ෑᶲẞ D02A 22u_6.3V_X5R_06 B.Schematic Diagrams + PL5 PR141 CMME063T-R15MS0R907 SW _GT2 SW _GT2 PJ11 *OPEN-5mm [30] PC77 + VCCGT SW N_GT1 [30] PJ17*OPEN-10mm VCCGT_L *20mil_04 PR139 2.2_06 G HG_GT2 4.7u_25V_X5R_08 [30] 57A *20mil_04 4.7u_25V_X5R_08 PQ13 MDU1516 ULTRASO-8 PC93 S s'd PC83 + D D02A S LG_GT1 VIN EMI่Ķ S [30] PR160 PL7 CMME063T-R15MS0R907 PR161 SW _GT1 PQ20 MDU1512 ULTRASO-8 G *25TQC15MYFB D 4.7u_25V_X5R_08 SW _GT1 4.7u_25V_X5R_08 HG_GT1 [30] S [30] G *1000p_50V_X7R_04 PR150 2.2_06 PC110 + *1000p_50V_X7R_04 PQ19 MDU1516 ULTRASO-8 D PC109 EC7 1000p_50V_X7R_04 PC112 EC5 D D02A VIN D [5,9,25,28] [3,4,5,6,7,13,14,15,16,17,18,19,20,21,22,23,24,25,30] [17,20,25,27,30] [6,16,25,26,27,28,30,31] [5,8,10,28,31] [2,5,6,7,10,17,21,24,25,26,27,28,31] 1.0VS 3.3VS 5V VIN 1.0VA VDD3 A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title PC127 [29] VCORE,VCCGT,VCCSA,VCCIO *0.1u_10V_X7R_04 Size A3 Date: B - 30 Document Number N240JU_N250JU 6-71-N24J0-D02A Thursday, August 27, 2015 Sheet 29 Rev 1.0 of 39 Schematic Diagrams NCP81206 Regulator 3.3VS PR190 100K_04 PJ29 *CV-40mil PJ30 [6,16,24] D ALL_SYS_PWRGD VR_EN D OPEN_4mil ^,KZd CSN_SA PR36 CSP_GT1 PC17 1K_1%_04 7.87K_1%_04 PC84 0.022u_25V_X7R_04 PR132 [29] B VIN CSREF_GT PR133 [29] TSENSE_GT 10_04 CSN_GT1 10_04 PR155 CSN_GT2 0_04 0.01u_50V_X7R_04 SWN_GT1 2_04 5V PU1 15000P_50V_X7R_06 1000p_50V_X7R_04 VCCSA VCCSA_SENSE [9] VSSSA_SENSE 100_04 0_04 RT1 7.87K_1%_04 5V D02 VSP_SA PC3 1000p_50V_X7R_04 499_1%_04 PR13 100_04 PR92 PC2 C CSN_CORE RT5 PR128 Sheet 30 of 38 NCP81206 Regulator [29] 100k_1%_04_NTC PR169 PC172 PC137 CSN_CORE CSP_CORE 14K_1%_04 PR165 SWN_CORE [29] 7.5K_1%_06 PR178 PC15 *2200p_50V_X7R_04 POWER SLOUTION 100_04 PR30 1K_1%_04 D02 [29] [29] [29] VSP_CORE PR31 PR38 HG_GT2 [29] SW_GT2 [29] LG_GT2 [29] VSN_SA *2200p_50V_X7R_04 POWER SLOUTION place close to L3 H_CPU_SVIDCLK HG_CORE SW_CORE LG_CORE BST_GT2 D02 H_CPU_SVIDDAT BST_CORE 22K_1%_04 POWER SLOUTION 19.1K_1%_04 SWN_GT2 100k_1%_04_NTC [29,30] place close PR154 to PQ19 PR1 49.9_1%_04 HG_GT1 SW_GT1 LG_GT1 PR130 0.022u_25V_X7R_04 CSP_GT2 2200p_50V_X7R_04 PC1 PR93 [9] VCC_SENSE [9] B 2.43K_1%_04 PR33 VSS_SENSE PC16 POWER SLOUTION 0.1u_16V_X7R_04 PC85 PR123 VSN_GT 1K_1%_04 2.37K_1%_04 PR12 0.1u_10V_X7R_04 DRON [29] H_CPU_SVIDCLK [9] H_CPU_SVIDALRT# [9] PR19 10_1%_04 H_CPU_SVIDDAT [9] PR23 100_1%_04 H_PROCHOT# [5,31] IOUT_CORE PC11 470p_50V_X7R_04 CSP_CORE PC79 1000p_50V_X7R_04 CSN_CORE PR29 51K_1%_04 ILIM_CORE PR119 36.5K_1%_04 COMP_CORE PC81 15P_50V_NPO_04 VSN_CORE VSP_CORE TSENSE_CORE PC87 1500p_50V_04 PC20 PR127 2.49K_1%_04 PR16 [9] PR14 PR21 100_04 51K_1%_04 FOR CV TEST PC8 VSN_CORE BST_GT1 [29] [29] [29] 39 38 37 36 35 34 33 32 31 30 29 28 27 14 15 16 17 18 19 20 21 22 23 24 25 26 1u_10V_Y5V_06 PR32 PR131 [29,30] DRON SCLK ALERT# SDIO VR_HOT# IOUT_1a CSP_1a CSN_1a ILIM_1a COMP_1a VSN_1a VSP_1a TSENSE_1ph [29] 100_04 2200p_50V_X7R_04 PC19 43.2K_1%_04 IOUT_2ph DIFFOUT_2ph/IccMax_2ph FB_2ph COMP_2ph ILIM_2ph CSCOMP_2ph CSSUM_2ph NCP81206A CSREF_2ph CSP2_2ph CSP1_2ph TSENSE_2ph VRMP VCC DIFFOUT_GT FB_GT COMP_GT PR4 0.022u_25V_X7R_04 D02 D02 PWM_SA PR191 VSSGT_SENSE [29] PC173 PJ32 *CV-40mil PR8 52 51 50 49 48 47 46 45 44 43 42 41 40 53 EPAD IOUT_GT PR26 12.7K_1%_04 ILIM_GT CSSUM_GT CSREF_GT PC80 0.01u_50V_X7R_04 CSP_GT2 CSP_GT1 10 PC14 0.1u_50V_Y5V_06 TSENSE_GT 11 12 VRMP 13 PR121 60.4K_1%_06 470p_50V_X7R_04 [11] PR10 7.5K_1%_06 1.0VT [6] VSP_GT 0_04 VCCGT_SENSE PC4 1000p_50V_X7R_04 SWN_SA EMI 100_04 PR11 [11] 0.1u_50V_Y5V_06 ^,KZd JL 6/11PJ31 *CV-40mil 26.1K_1%_04 VSN_2ph VSP_2ph PSYS VSP_1b VSN_1b COMP_1b ILIM_1b CSN_1b CSP_1b IOUT_1b VR_RDY EN PWM/ADDR_VBOOT SWN_GT2 *100p_50V_NPO_04 SWN_GT1 [29,30] PC12 PR27 165K_1%_04 1000p_50V_X7R_04 100k_1%_04_NTC [29,30] PR138 60.4K_1%_06 PC9 BST1 HG1 SW1 LG1/ROSC PVCC LG2/ICCMAX_1a SW2 HG2 BST2 LG3/ICCMAX_1b SW3 HG3 BST3 PR20 PC13 PR153 14K_1%_04 PR152 H_VR_READY VR_EN CSCOMP_GT PR24 75K_1%_04 D02 VSN_GT COMP_GT EC2 VSP_SA VSN_SA VSP_GT CSN_SA CSP_SA IOUT_SA *20K_1%_04 VCCGT PR2 place close to PL7 45.3_1%_04 PR113 PR7 PC73 220p_50V_NPO_04 PR115 C 1000p_50V_X7R_04 3.3VS PSYS PC76 2200p_50V_X7R_04 RT3 PC123 CSP_SA 1000p_50V_X7R_04 [31] PR110 3K_1%_04 PC75 15P_50V_NPO_04 Place close to PL6 PC122 CSN_SA [29] PC18 PR177 VCCIN 11K_1%_04 100_04 1.82K_1%_04 1000p_50V_X7R_04 PR129 TSENSE_CORE BST_GT1 5V 22.6K_1%_04 BST_GT2 BST_CORE PR167 0_04 PR35 PR37 PR134 2_06 2_06 PC22 2_06 2.2u_6.3V_X5R_04 CSP_GT2 PC102 PR166 0.22u_10V_X5R_04 0.22u_10V_X5R_04 SW_GT1 0.22u_10V_X5R_04 SW_GT2 SW_CORE place close to PQ23 RT4 100k_1%_04_NTC PC98 19.1K_1%_04 PC21 *1K_04 [3,4,5,6,7,13,14,15,16,17,18,19,20,21,22,23,24,25] 3.3VS [5,6,8,9,28] 1.0VT [6,16,25,26,27,28,29,31] VIN [17,20,25,27,29] 5V [3,6,7,16,17,19,20,21,25,27] 3.3V [11,29] VCCGT [9,29] VCCIN [5,8,10,28,29,31] 1.0VA [9,29] VCCSA A A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title [30] NCP81206 Regulator Size Document Number Custom N240JU_N250JU Date: 6-71-N24J0-D02A Tuesday, September 01, 2015 Sheet 30 Rev 1.0 of 39 NCP81206 Regulator B - 31 B.Schematic Diagrams FB_GT 1000p_50V_X7R_04 COMP_SA PC71 470p_50V_X7R_04 D02 100k_1%_04_NTC PC6 20.5K_1%_04 PR114 PC69 15P_50V_NPO_04 program IccMax_2ph RT2 750_1%_04 PC74 PR103 1K_1%_04 10K_04 PR104 JL 6/10 49.9_1%_04 PR102 100K_1%_04 PR100 PJ55 OPEN_4mil VR_ON 15000P_50V_X7R_06 [24] 63.4K_1%_04 DIFFOUT_GT Schematic Diagrams Charger, DC-In VA PR124 PC89 *470K_04 SMART CHARGER PC88 PC86 1500p_50V_04 D VA1 A 4700p_50V_X7R_04 PC65 PR126 0_04 PR125 0_04 PMOSFET_CONTROL# Z4106 PJ10 *3mm PR112 33_04 PR28 12K_1%_04 47K_04 D02A FORℙ่᷀Ķ VA C A ZD5245BS2 PR84 *20K_1%_04 PR198 PQ5 *2N3904 PQ25 MTE1K0P15KN3 V_BAT S PC57 *0.047u_10V_X7R_04 PR162 AC_IN PC136 C 4S/2800mAH /7.15K 0.1u_16V_Y5V_04 G C C 2S / 10K / NT1908 3S / 2K 3S/2800mAH / 4.02K 4S / 390 PR170 VDD3 A SS1040WG A A SS1040WG BAT DET(BATTERY INTERNAL) : BAT_VOLT [24] Z4107 D02A FORℙ᷀ᦘᷱᶵᶲ Option close to EC 2S / 5K / NT1912 Z4108 100K_04 D02A FORℙ᷀ᦘᷱᶵᶲ S [26] GND_SIGNAL PR168 300K_1%_04 D [24] B GND_SIGNAL D02 ຦ֈ⅒కᇖ PQ8 2N3904 PC55 *0.1u_50V_Y5V_06 PJ9 *CV-40mil C B TOTAL_CUR PC92 Need to modify for 2,3,4 cells battery PR116 10K_1%_04 [24] D02A FORℙ᷀ෑ3904 PQ10 PR111 *2SK3018S3 *100K_04 E PR106 *10K_04 PR197 10K_04 10K_04 D G S CHG_JAP AC_IN# FOR 15" 1u_25V_X5R_06 PD7 PR85 *100K_04 PR108 *47K_04 [24] PR25 *15mil_short_06 PSYS 10_04 PR17 24K_1%_04 PC10 GND_SIGNAL [30] *C144DF-105A8-L BAT_DET [24] SMD_BAT [24] SMC_BAT [24] PR22 GND_SIGNAL PR90 C V_BAT D02A FORℙ᷀ෑ47K PR107 *100K_04 EC GPIO (PD) pin; Hi -Pmosfet open; Low Pmosfet turn on 4.7u_6.3V_X5R_06 [5,30] PR15 24.9K_1%_04 GND_SIGNAL 0.1u_10V_X7R_04 *0_04 A PD9 *ZD5245BS2 PR86 C VDD3 PC70 PC171 VDD3 PQ7 *EMB20P03V H_PROCHOT# G PR95 *0_04 PR9 100K_1%_04 PR18 470K_04 PR120 0_04 60.4K_1%_04 D B PR96 *51_04 Close to VDDP pin VA PD6 PD5 PD10PD8 12 47p_50V_NPO_04 ^,KZd 330_04 JBATTA1 HCB1005KF-121T20 HCB1005KF-121T20 HCB1005KF-121T20 *MMSZ5232BS 100K_04 PU4 PC104 GND_SIGNAL VJACK PROCHOT# 1u_25V_X5R_06 4.7u_25V_X5R_06 D S Hi -Battery in Charge Low -Battery remove no charge EC GPIO PD pin [24] VAC IBSET PR98 IAC1 PL3 PL2 PL1 SMC_BAT 30p_50V_NPO_04 *0_04 G LOT6_CHG PC90 SMD_BAT 330_04 C144DF-105A8-L 1.0VA ACAV PC56 1000p_50V_X7R_04 [24] PR91 PR87 10 EC6 30p_50V_NPO_04 PQ14 MTN7002ZHS3 IAC PR97 30p_50V_NPO_04 IACP ICHM 11 FBV S 30 SCL ACAV 0_04 100K_1%_04 OZ8685 IACM ICHP JBATTA2 EMC2 PR89 31 FOR 14" EMC3 G 32 IACP D02A BAT CONN FOR DXF EMC1 PQ6 MTN7002ZHS3 IACM SDA GNDA GNDA D PD14 MDL914S2 ICHM VDDP PSYS 300K_1%_04 BST 28 35 A VDDP_DC_IN 29 C PR122 13 10_04 PD13 PMON PQ12 MTE1K0P15KN3 G PR118 BST C C 24 25 26 ICHP VAC + PC82 A *MMSZ5232BS C MDL914S2 COMP A D PC63 4700p_50V_X7R_04 4700p_50V_X7R_04 LX LX LX LX LX LX 0.22u_16V_X7R_06 4700p_50V_X7R_04 4700p_50V_X7R_04 PR137 S GNDP GNDP GNDP *0_06 VA PC64 PC72 PC60 0.1u_50V_Y5V_06 Sheet 31 of 38 Charger, DC-In PC91 VSYS VSYS VSYS VSYS VSYS VSYS VSYS PC94 34 14 15 16 17 18 19 PC97 20 21 22 23 27 33 PC78 PR109 PC5 PC7 C FMS3004-AS-H PC96 PC66 22u_25V_X5R_08 PR101 15K_1%_04 PD12 Z4104 PC61 4.7u_25V_X5R_08 PC62 4.7u_25V_X5R_08 PC53 PR6 0_04 22u_25V_X5R_08 PR5 0_04 1000p_50V_X7R_04 A PR135 FMS3004-AS-H2.2_04 PR99 100K_04 22u_25V_X5R_08 C PQ9 EMB20P03V PR117 0.01_1%_32 1500p_50V_04 0.1u_50V_Y5V_06 0.1u_50V_Y5V_06 0.1u_50V_Y5V_06 PR105 470K_04 PL4 BCIHP-0730 8R2M PD11 15u_25V_6.3*4.4_C PC67 PR88 0.01_1%_32 22u_25V_X5R_08 0.1u_50V_Y5V_06 PC68 20K_04 VA PC54 W TJ-020-71C B.Schematic Diagrams VJACK EML1 HCB2012KF-800T80 GND1 GND2 4.7u_25V_X5R_08 J_DC_JACK1 V_BAT PR3 PQ11 EMB20P03V 0.1u_50V_Y5V_06 D 0.1u_50V_Y5V_06 VIN PQ24 MTN7002ZHS3 AC_IN [25] [6,16,25,26,27,28,29,30] [2,5,6,7,10,17,21,24,25,26,27,28,29] [5,8,10,28,29] A VA VIN VDD3 1.0VA A ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title [31] CHARGER,DC IN Size Document Number Custom N240JU_N250JU Date: B - 32 Charger, DC-In 6-71-N24J0-D02A Sheet 31 Thursday, August 27, 2015 Rev 1.0 of 39 Schematic Diagrams USB Board U_USBVCC_1 UU1 U_5V VIN GND 10u_10V_Y5V_08 EN# 16 15 14 13 12 11 10 UC2 OC# UJ_USB1 100 MIL VOUT UC1 UC3 22u_6.3V_X5R_08 0.1u_16V_Y5V_04 UC4 22u_6.3V_X5R_08 + UC5 *220u_6.3V_6.3*6.3*4.2 SY6288DAAC U_GND D [32] U_GNDU_GND UDD_ON# U_GND U_USBVCC_1 60 mil UC6 0.1u_16V_Y5V_04 U_5V D UUSBH1_USB_DP2 UUSBH1_USB_DN2 UUSBH1_USB_DP4 UUSBH1_USB_DN4 UDD_ON# [32] UUSB_PN2R UUSBH1_USB_DP2 UUSB_PP2R 10 U_GND *WCM2012F2S-161T03-short D02 0518 C UUSB_PN2_RJ UUSB_PP2_RJ U_GND V+ DATA_H GND U_GND PUSB3F96 USB2.0 ESD ᢈᶲẞ 2014/5/27 PIN GND3~4=GND PN:6-21-B4900-004 PCBfootprint: dfn10-2_5x1mm-short UH1 UH3 USB-04AP0B MTH6_0D2_8 U_GND U_GND FOR 15' UU2 VIN VOUT MTH6_0D2_8 U_GND U_GND D02 0526 UC7 GND *10u_10V_Y5V_08 EN# OC# UH4 C79D79N 100 MIL UC8 *0.1u_16V_Y5V_04 UC9 *22u_6.3V_X5R_08 UC10 *22u_6.3V_X5R_08 C UH2 o98x79d98x79n + UC11 *220u_6.3V_6.3*6.3*4.2 *SY6288DAAC B U_GND [32] U_GNDU_GND UDD_ON# Sheet 32 of 38 USB Board U_USBVCC_2 U_5V B D02 0514 U_GND DATA_L GND1 GND2 GND3 GND4 GND1 GND2 GND3 GND4 UL1 UUSBH1_USB_DN2 FP225H-016S10M U_GND U_USBVCC_2 60 mil PCBA CHECK UC12 *0.1u_16V_Y5V_04 1UUR *0_04 4UUR *0_04 2UUR *0_04 5UUR *0_04 3UUR *0_04 6UUR *0_04 UJ_USB2_2 UUSBH1_USB_DP4 UUSB_PN3R UUSB_PP3R *WCM2012F2S-161T03-short D02 0518 A 10 U_GND UUSB_PN3_RJ UUSB_PP3_RJ U_GND *PUSB3F96 USB2.0 ESD ᢈᶲẞ 2014/5/27 PCBfootprint: dfn10-2_5x1mm-short V+ DATA_L DATA_H GND U_GND PIN GND3~4=GND PN:6-21-B4900-004 GND1 GND2 GND3 GND4 UL2 UUSBH1_USB_DN4 GND1 GND2 GND3 GND4 UD2 U_GND ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ *USB-04AP0B Title [32] USB BOARD Size A4 Document Number Date: A Rev 3.0 6-71-N2403-D04 Thursday, August 27, 2015 Sheet 32 of 39 USB Board B - 33 B.Schematic Diagrams UJ_USB2_1 UD1 Schematic Diagrams CRT CRT MDAC_RED ML9 *0402_short ML12 FCM1005MF-600T01 MFRED MDAC_GREEN ML10 *0402_short ML13 FCM1005MF-600T01 MFGRN ML11 *0402_short ML14 FCM1005MF-600T01 MC51 MC54 MC55 MC56 MC61 MFBLUE MC62 MC63 15p_50V_NPO_04 15p_50V_NPO_04 15p_50V_NPO_04 *5p_50V_NPO_04 *5p_50V_NPO_04 *5p_50V_NPO_04 15p_50V_NPO_04 M_5VS MR50 MR53 POWER 2.2K_04 2.2K_04 M_3.3VS MR51 36 MVGA_HS_R ML1 MR52 36 MVGA_VS_R MAVCC_33 D GZ1005D600TF MC59 *1u_6.3V_X5R_04 MC60 M_GND M_3.3VS ML3 1000p_50V_X7R_04 1000p_50V_X7R_04 M_GND MC57 10p_50V_NPO_04 D02 0514 MC26 D01 to D01 MVGA_SCL MC58 M_GND MD1 RB751S-40C2 C A MVGA_SDA 10p_50V_NPO_04 MVDD_DAC_33 GZ1005D600TF MC48 *1u_6.3V_X5R_04 M_GND M_GND M_GND MC41 2.2u_6.3V_X5R_04 0.1u_16V_Y5V_04 MC37 M_GND M_GND 30 MLANE1_P 31 MLANE1_N 32 33 [33] MVCCK_V12 MXTLO MXTLI 18 17 XI/CKIN XO LANE0N BLUE_N LANE1P BLUE_P LANE1N VDD_DAC_33 EPAD_GND M_GND 14 M_GND 13 M_GND MC35 11 D01 to D01 MU4 74AHCT1G125GW MVGA_VS_R M_GND M_GND MDAC_BLUE 10 B MVDD_DAC_33 MR43 MC44 0.1u_16V_Y5V_04 *0_04 MC45 10u_6.3V_X5R_06 MH6 M_GND MVGA_HS 100K_04 MVGA_VS MR18 M_GND 4.7K_04 M_GND MVGA_VS MDAC_GREEN 12 MH5 MVGA_HPD M_GND M_3.3VS 19 DVCC_33 22 21 GREEN_P M_GND LDO_EN 23 LANE0P MR44 MDAC_RED MLANE0_N GREEN_N M_GND 29 GND_DAC RTD2168 RRX 16 15 HSYNC MLANE0_P AUX_N VSYNC 28 *0_04 M_5VS_CRT RED_P DVCC_33 [33] [33] 27 MRRX M_GND MTH7_0D2_8 0.1u_16V_Y5V_04 M_GND MH7 C79D79N [33] A [33] MVGA_AUX_CH_N [33] MVGA_AUX_CH_P [33] MVGA_LANE0N [33] MVGA_LANE0P [33] MVGA_LANE1N [33] Power On Configuration M_3.3VS MVGA_HPD MVGA_HPD Rc MC22 0.1u_10V_X5R_04 MAUX_CH_N MC23 0.1u_10V_X5R_04 MAUX_CH_P MC20 0.1u_10V_X5R_04 MLANE0_N M_GND M_GND M_GND MR23 0.1u_10V_X5R_04 MLANE0_P MC18 0.1u_10V_X5R_04 MLANE1_N MC19 MVGA_LANE1P RTD2168 Slave Address 0x64 / 0x65 and 0x68 / 0x69 M_GND POL1_SDA MR16 4.7K_04 POL1_SDC Rom only mode Rc L Rf H [33] MCSDA ep mode Rd H Re L [33] MCSCL Rd H Rf L 0.1u_10V_X5R_04 MLANE1_P EEPROM MODE *0_04 4MMR *0_04 2MMR *0_04 5MMR *0_04 3MMR *0_04 6MMR *0_04 Rf *4.7K_04 MPOL2_SDC MR17 1MMR M_3.3VS M_3.3VS Re MC21 *4.7K_04 MR26 MR21 *4.7K_04 *4.7K_04 [34] [34] B - 34 CRT A M_VDD3 M_3.3VS ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ MCSDA Title [33] MULTI BOARD CRT(RTD2168) Size A3 Document Number MCSCL Date: D02 0519 PCBA CHECK I2C Control Debug Port connect to EC/PCH Rd 4.7K_04 MPOL1_SDA MR24 MH1 H7_0D2_8 MTH7_0D2_8 M_GND D02 0526 DP Signals from SOC C M_GND MR40 MU2 RED_N [33] [33] MAUX_CH_N MVGA_HS_R MU3 74AHCT1G125GW AUX_P MVGA_SDA MVGA_HPD 12K_1%_04 D01 to D01 M_GND AVCC_12 VGA_SCL MVGA_LANE1N MVGA_LANE1P MVGA_AUX_CH_N MVGA_AUX_CH_P MR14 26 M_GND [33] [33] 25 MAUX_CH_P [33] [33] MVGA_LANE0N MVGA_LANE0P MVCCK_V12 M_3.3VS MCSDA MCSCL 0.1u_16V_Y5V_04 MVGA_SCL M_GND D02 0514 POL2_SCL MC24 [34] SMB_SDA MSUSB MLAN_W AKEUP# [34] MPCIE_W AKE# [34] POL1_SDA 10u_6.3V_X5R_06 MLAN_CLKREQ# [34] MBUF_PLT_RST# [34] SMB_SCL MC27 M_GND MVGA_HS 0_04 MAVCC_33 0.1u_16V_Y5V_04 MC25 M_GND MCLK_PCIE_LAN [34] MCLK_PCIE_LAN# [34] MCSDA [34] [34] MPOL2_SDC 24 MPCIE_RXN0_LAN MPCIE_RXP0_LAN MPOL1_SDA AVCC_33 [34] [34] 20 M1.2V_LDO_EN MPCIE_TXN0_LAN MPCIE_TXP0_LAN 4.7K_04 MR57 Ra R1496 pull up VCCK_V12 from LDO enable Rb R1497 pull down VCCK_V12 from external M_3.3VS M_5VS_CRT MR41 4.7K_04 MR27 *4.7K_04 MR56 *0_04 VCCK_12 MR29 D02 to D02a Ra MCSCL M_GND 0.1u_16V_Y5V_04 M1.2V_LDO_EN M_GND M_VDD3 M_GND MC39 HPD B Rb M_3.3VS M_GND C 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 GND2 MJ_MUX1 M_5VS VGA_SDA GND1 M_3.3VS Sheet 33 of 38 CRT T40 0.5P 2.0H FPC W/COVER PCB Footprint = FP201-040X1-0M B.Schematic Diagrams MC53 15p_50V_NPO_04 75_1%_04 75_1%_04 75_1%_04 15p_50V_NPO_04 MR47 MR48 MR49 D MC52 M_5VS_CRT MJ_CRT1 108AH15FST04A4C3 10 11 12 MVGA_HSYNC 13 MVGA_VSYNC 14 15 GND1 GND2 MDAC_BLUE 2 Rev 3.0 6-71-N2407-D04 Thursday, August 27, 2015 Sheet 33 of 39 Schematic Diagrams RTL8411B Crystal ෑ᷀HSX321S(3.2X2.5X0.65) meet realtek Freq tolerance 50ppm MRSET D01 to D02 M_GND MT6 MT1 TO SB PCH WAKE# MPCIE_WAKE# M_GND M_GND MT4 MT2 48 47 46 45 44 43 42 41 40 39 38 37 MU1 49 BIOS pulls high or low to GPO pin, Pkease refer to LAN/PHY Disable Application Note E_PAD M_GND [33] MR20 1K_04 MR55 MSUSB G *0402_short M_3.3VS MVDD10 MLAN_MDIP3 MLAN_MDIN3 MVDD33 M_3.3VS C RTL8411B QFN48 MC30 0.1u_16V_Y5V_04 PIN12 M_GND RTL8411B 6-03-08411-032 MCARD_3V3 MVDD10 MVDD10 MC34 0.1u_16V_Y5V_04 B MVDD10 MC32 PIN8 M_GND MVDD33/18 MVDD33/18 MC28 MC31 *4.7u_6.3V_X5R_06 MVDD10 MC36 0.1u_16V_Y5V_04 PIN3 M_GND 36 35 34 33 32 31 30 29 28 27 26 25 REG_OUT VDDREG ENSWREG VDD1 VD33 ISOLATEBPIN PERSTBPIN CLKREQBPIN MS_BS/SD_WP# DV33_18 HSON HSOP MREGOUT MRTL8411B_HSON MRTL8411B_HSOP MR45 MC5 MC7 Connect VAULE FOR REFERENCE BY PROJECT D02 0514 10K_04 [33] MR15 0_04 MLAN_CLKREQ# MSD_D2/MS_CLK_R MSD_D3/MS_D3_R MSD_CMD/MS_D2_R [33] P9 P1 P2 P3 P4 P5 P6 P7 P8 WP CD COM GND1 GND2 LAN_CLKREQ#Țᶵἧ᷀⎗๏ᜓ,๔PCH⎇ᾌఽPULL DOWN MPCIE_RXN0_LAN MPCIE_RXP0_LAN MVCC_CARD [33] [33] MSD_CLK/MS_D0_R MC1 0.1u_16V_Y5V_04 MVDD33 PULL HIGH: SWR Mode MVCC_CARD MENSWREG MR28 *0_04 MR30 0_04 MSD_D0/MS_D1_R MSD_D1_R MMS_BS/SD_WP# MSD_CD# MPCIE_TXN0_LAN MPCIE_TXP0_LAN MC8 MC10 0.1u_16V_Y5V_04 4.7u_6.3V_X5R_06 *10u_6.3V_X5R_06 [33] [33] PULL LOW: LDO Mode SDSR09-A0-0015 D02 0515 M_GND ፗᶺ⅒కLDO MODE OKࠤ, ෑSHORT᡾ẞ M_GND Near Cardreader CONN V3.6 ࠝDVT EMI⅒కࠤ ᔒв໇⏎ᾌఽ₅ཷ MC16 0.1u_16V_Y5V_04 C Sheet 34 of 38 RTL8411B 6-21-XXXXX-XXX M_GND MC3 DAT2 CD/DAT3 CMD VSS VDD CLK VSS DAT0 DAT1 W/P CD COM GND1 GND2 MCARD_3V3 MR8 0.2_06 MVCC_CARD 0.1u_16V_Y5V_04 Ḏᝤᜑhostᢃᜨ/ CARD ୬౪໚,VCC_CARD ᢃū੡Ỷ๔0.5ặᬑ,྘ҩᢈଉ1msྷ᜛ PIN13 M_GND MR9 B *150_06 M_GND 0.1u_16V_Y5V_04 GIGA LAN 0_06 VDD3 meet rising time >1ms M_VDD3 MC4 MJ_CARD1 MBUF_PLT_RST# 0.1u_10V_X7R_04 0.1u_10V_X7R_04 MCARD_3V3 PIN46 M_GND ౓ἧ᷀VSᢃ MC6 M_GND M_GND M_GND M_GND M_GND M_GND M_GND MEVDD10 MR7 MVDD33/18 MC13 MC14 MC2 M_GND capacitors must be close to pin side Pin#27 M_GND Pin#27 M_GND MVDD10 Remind that R109 using the main power (S0 power) MVDD10 M_GND MVDD33 MISOLATEB MPERSTB MR22 *0402_short MCLKREQB MMS_BS/SD_WP# MCLK_PCIE_LAN# [33] MCLK_PCIE_LAN [33] MC42 0.1u_16V_Y5V_04 PIN32 M_GND MR19 MREGOUT MD3V3 MENSWREG CARD_3V3 SD_D1 SD_D0/MS_D1 SD_CLK/MS_D0 SD_CMD/MS_D2 SD_D3/MS_D3 SD_D2/MS_CLK VDDTX HSIP HSIN REFCLK_P REFCLK_N MLAN_MDIP1 MLAN_MDIN1 MLAN_MDIP2 MLAN_MDIN2 MDIP0 MDIN0 AVDD10 MDIP1 MDIN1 MDIP2 MDIN2 AVDD10 MDIP3 MDIN3 HV_GIGA VDD3 13 MSD_D1 14 MSD_D0/MS_D1 15 MSD_CLK/MS_D016 MSD_CMD/MS_D2 17 MSD_D3/MS_D3 18 MSD_D2/MS_CLK19 20 MEVDD10 21 22 23 24 MVDD10 10 11 12 D MC11 Close to chip MQ1 MTN7002ZHS3 M_3.3VS MR25 15K_04 MLAN_MDIP0 MLAN_MDIN0 ໸ℏӼ MC12 0.1u_16V_Y5V_04 1u_6.3V_X5R_04 PIN20 M_GND *28mil_short-p MR46 PIN20 M_GND MVDD33 *28mil_short-p MC33 MC43 MLAN_MDIP0 MLAN_MDIN0 MLAN_MDIP1 MLAN_MDIN1 11 12 MLAN_MDIP2 MLAN_MDIN2 MLAN_MDIP3 MLAN_MDIN3 MC29 MTCT 0.1u_16V_Y5V_04 PIN11 M_GND 60 mil MR31 A 0.1u_16V_Y5V_04 PIN32 M_GND MD3V3 0.1u_16V_Y5V_04 PIN48 M_GND 10 TD4+ TD4TD3+ TD3- MX4+ MX4MX3+ MX3- TD2+ TD2TD1+ TD1- MX2+ MX2MX1+ MX1- TCT4 TCT3 TCT2 TCT1 MCT4 MCT3 MCT2 MCT1 14 13 17 16 MLMX1+ MLMX1MLMX2+ MLMX2- MLMX1+ MLMX1MLMX2+ MLMX2- 20 19 23 22 MLMX3+ MLMX3MLMX4+ MLMX4- MLMX3+ MLMX3MLMX4+ MLMX4- 15 18 21 24 MC40 +- PINྌ౳ LDO Mode MC9 *4.7u_6.3V_X5R_06 *WCM2012F2S-161T03-short PIN35 M_GND M_GND Transformer VAULE FOR REFERENCE BY PROJECT MJ_RJ_1 DA+ DADB+ DB- shield shield GND1 GND2 DC+ DCDD+ DD- M_GND 130456-161 6-20-B4P20-008 D02 0520 Connect VAULE FOR REFERENCE BY PROJECT MNMCT_1 MR13 MNMCT_2 MR12 MNMCT_3 MR11 MNMCT_4 MR10 D02 0518 75_1%_04 75_1%_04 75_1%_04 75_1%_04 ූ⛐TOPᣪ *0.1u_16V_Y5V_04 0.01u_16V_X7R_04 PIN35 M_GND NS892402 GST5009 LF *28mil_short-p MC38 ML6 *WCM2012F2S-161T03-short MDLMX1+ ML7 MDLMX1MDLMX2+ MDLMX2*WCM2012F2S-161T03-short ML8 MDLMX3+ MDLMX3*WCM2012F2S-161T03-short MDLMX4+ ML5 MDLMX4- ML4 MC15 [33] [33] MC17 100p_2KV_X7R_12_H125 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ 6-07-1012C-HB0 M_GND BY LAYOUT, TRANSFORMER⎇◜⇍⎗ҥే Ữዕҥ( IN/OUT⎴໚ҥే) P->+ , N->- ṵྡଉᓚ Title [34] MULTI BOARD-CR/LAN Size Document Number Custom Date: A M_VDD3 M_3.3VS Rev 3.0 6-71-N2407-D04 Thursday, August 27, 2015 Sheet 34 of 39 RTL8411B B - 35 B.Schematic Diagrams HV_GIGA RSET LV_CEN CKXTAL2 CKXTAL1 MS_CD# SD_CD# LED0 LED_CR LANWAKEB LED1/GPO LED2 M_GND ࠝEMI⅒కФ,ෑSHORT *5p_50V_NPO_04 ፗᶺ⅒కࠤᢃៃ,ෑᥒSHORT᡾ẞ *5p_50V_NPO_04 LDO Mode໚: La,Ca,Cb ᶵᶲẞ,Raᶲẞ [33] 18p_50V_NPO_04 D01 to D02 M_GND MSD_D1_R MSD_CLK/MS_D0 *0.1u_16V_Y5V_04 MSD_D2/MS_CLK_R ML15 FCM1005MF-600T01 MSD_CLK/MS_D0_R ML16 FCM1005MF-600T01 MSD_D3/MS_D3_R 0_04 *5p_50V_NPO_04 MLED1/GPO MLED2 MLAN_WAKEUP# MSD_D0/MS_D1_R 0_04 MSD_D3/MS_D3MR6 [33] D02 0514 TO EC8987 PIN123 LAN_WAKEUP# MLAN_WAKEUP# MC49 Cb *4.7u_6.3V_X5R_06 MSD_CMD/MS_D2_R 0_04 MSD_D1 *5p_50V_NPO_04 MC46 MC50 La 0_04 MSD_D0/MS_D1MR2 MR1 D02 to D02a MSD_D2/MS_CLK (>20mil) *SWF2520CF-4R7M-MCa FOR S5 WAKE UP ON LAN MSD_CMD/MS_D2 MR3 75_04 PCBfootprint: HSX321G 18p_50V_NPO_04 MVDD10 MVDD10 *5p_50V_NPO_04 MC47 A RB751S-40C2 0_06 ML2 MREGOUT MVDD33 6-06-75140-065 C MD2 MR42 (>20mil) *5p_50V_NPO_04 MX1 FSX3L 25MHZ 10K_04 D MVDD33 0_04 MXTAL1 M_GND S M_GND MR35 M_GND *1K_04 MR54 D 1M_04 2.49K_1%_04 MR34 Switching Regulator close to PIN48 Ra MR38 MR32 MXTAL2 MXTAL1 MMS_INS# MSD_CD# MEECS MLED_CR MR39 0_04 MXTAL2 MVDD10 MR36 ἧ᷀INTEL PLAYFORMᶼSUPPER RTC WAKE ON LAN(S5)⎗=ᾙ᷽Dedeo AD6 , Ữᢈᖀধ໇⏎ឧᢃ⓷᧔ LAN (RTL8411B) Schematic Diagrams Power SW Board S_VDD3 POWER SW & LED POWER SWITCH LED D01 to D02 SR2 100K_04 SJ_SW1 D S_VDD3 20mil SU2 SMGND S_3.3VS *YB8251 VCC SMGND SMGND SM_BTN# SMGND SLID_SW# OUT GND FOR 15" D SMGND FP226H-008S10M S_3.3VS S_3.3VS S_3.3VS D02A 0611 C SR4 SR1 SR3 470_04 470_04 20mil SMGND A A A *0.1u_10V_X5R_04 SMGND SMGND SMGND 6-02-08251-LC0 1SSR *0_04 4SSR *0_04 2SSR *0_04 5SSR *0_04 3SSR *0_04 6SSR *0_04 SMGND C C C PCBA CHECK *0.1u_10V_X5R_04 SD4 SMGND RY-SP190DBW71-5A B SMGND SC8 SD3 SMGND SC6 *100p_50V_NPO_04 SC7 *0.1u_10V_X5R_04 SC3 0.1u_16V_Y5V_04 ᏼᥒ‫ᦘݸٽ‬ᷱ ( 06 SIZE ) 20mil SC5 FOR 14" 470_04 20mil SD2 SC4 *1u_10V_Y5V_06 SLID_SW# OUT Sheet 35 of 38 Power SW Board YB8251 VCC GND SU1 C B.Schematic Diagrams RY-SP190DBW71-5A RY-SP190DBW71-5A B SMGND SMGND SMH1 SMH5 H6_0D2_8 SMH4 C79D79N SMH2 C79D79N MTH6_0D2_8 SPWR_SW1 T4BJB10-Q-T/R A SMGND 6-53-31500-B40 SC1 SC2 0.1u_50V_Y5V_06 *0.1u_50V_Y5V_06 Size A Date: B - 36 D02 0514 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title SMGND SMGND D02 0526 D02A 0611 SMGND SMGND SM_BTN# A [35] POWER SW BOARD 6-71-N240S-D05 Document Number Thursday, August 27, 2015 Sheet Rev 4.0 of 35 39 Schematic Diagrams Click Board CLICK BOARD FOR 14"(old) FOR 14"(old) D CR1 CR3 CR5 0_06 0_04 0_04 CTP_VCC CJ_TP2 CTP_VCC CC6 0.1u_16V_Y5V_04 CGND CTP_CLK CTP_DATA CGND CJ_TP1 CTP_CLK CTP_DATA CTPBUTTON_L CTPBUTTON_R D CGND 0_04 0_04 0_06 CTPBUTTON_L CTPBUTTON_R CGND CGND CJ_TP5 FOR 15" CSW4 *T4BJB10-Q-T/R D01 to D01 CSW1 T4BJB10-Q-T/R D02 0514 CTPBUTTON_L CTPBUTTON_R 6-53-31500-B40 FOR 14" and 15" CH5 CH6 CTP_VCC FP225H-006S10M 6-20-94K00-006 6-53-31500-B40 FOR 14" CGND CGND CH9 5 FOR 14"(new and 0.5mm) CTP_VCC CC3 0.1u_16V_Y5V_04 0.1u_16V_Y5V_04 CC4 C CGND CTP_CLK CTP_DATA CSW2 T4BJB10-Q-T/R CSMB_CLK CSMB_DATA C D02 to D02a Sheet 36 of 38 Click Board FOR 14"(new and 0.5mm) FOR 15"(old) CH10 CJ_TP3 CGND D02 to D02A CC7 *0.1u_16V_Y5V_04 B CGND CTP_CLK CTP_DATA CTPBUTTON_L CTPBUTTON_R CGND CSMB_CLK CSMB_DATA FP225H-008S10M MTH7_0D2_8 CGND CGND CH1 MTH7_0D2_8 CGND CGND MTH6_0D2_3 CGND CGND CH2 A MTH6_0D2_3 MTH7_0D2_8 CH4 C87D87N CH8 O106X87D106X87N PCBA CHECK 1CCR *0_04 4CCR *0_04 2CCR *0_04 5CCR *0_04 3CCR *0_04 6CCR *0_04 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title MTH7_0D2_8 CGND CGND D02 0526 Size A Date: A [36] CLICK BOARD 6-71-N2402-D04 Document Number Thursday, August 27, 2015 Sheet Rev 3.0 of 36 39 Click Board B - 37 B.Schematic Diagrams CR2 CR4 CR6 20mil 5mil 20mil 20mil FP226H-004S10M D02 0526 CGND CGND 85201-06051 B CC5 *0.1u_16V_Y5V_04 Schematic Diagrams LED Board LED BOARD [37] [37] L_LED_BAT_FULL L_LED_BAT_CHG L_LED_ACIN L_LED_PWR [37] [37] D D 3 LD1 LD2 Y SG RY-SP155HYYG4-1 RY-SP155HYYG4-1 Y Sheet 37 of 38 LED Board SG LGND LGND LGND LGND C C POWER ON LED/ AC IN FULL LED/ BAT CHARGE L3.3VS D01 to D02 D01 to D02 L3.3VS LJ_LED1 LR2 220_04 220_04 A LR1 LD3 FP226H-008S10M D02 0514 [37] RY-SP190YG34-5M 6-52-55001-021 L_LED_HDD# L_AIRPLAN_LED# HDD LED LH2 A 1LLR *0_04 4LLR *0_04 5LLR *0_04 6LLR LH4 C71D71N LH1 C71D71N MTH6_0D2_8 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ Title *0_04 LGND 3LLR AIRPLANE LED *0_04 MTH6_0D2_8 2LLR *0_04 LGND LGND D02 0526 Size A Date: B - 38 LED Board [37] LH3 PCBA CHECK B LD4 RY-SP190YG34-5M 6-52-55001-021 C B LGND L_LED_BAT_CHG [37] L_LED_BAT_FULL [37] L_LED_ACIN [37] L_LED_PWR [37] L_LED_HDD# [37] L_AIRPLAN_LED# [37] A C B.Schematic Diagrams LRN1 220_8P4R_04 A [37] LED BOARD Document Number Thursday, August 27, 2015 Rev 6-71-N2404-D03 Sheet 3.0 37 of 39 Schematic Diagrams HDD Board H_3.3VS FOR 15" HGND HR23 HR22 *4.7K_04 *4.7K_04 HR24 HR21 *4.7K_04 *4.7K_04 D02 to D02a D HC2 HC1 HR6 *0.01u_16V_X7R_04 *0.1u_16V_Y5V_04 *1u_6.3V_X5R_04 10 16 20 TX2N TX2P SN75LVCP601 ASM1466 *4.7K_04 *4.7K_04 *4.7K_04 HR7 HR20 HR9 *4.7K_04 *4.7K_04 *4.7K_04 17 HR8 HR19 HR10 H_3.3VS H_5VS RX2N RX2P HDE_B HDE_A 12 11 *0.01u_16V_X7R_04 *0.01u_16V_X7R_04 HSATA_TXP0 HSATA_TXN0 HSATA_RXN0_R HC8 HSATA_RXP0_R HC7 *0.01u_16V_X7R_04 *0.01u_16V_X7R_04 HSATA_RXN0 HSATA_RXP0 HSDA1 HR4 HSCK1 HR5 HR1 HR2 HREXT H_3.3VS *SN75LVCP601 *4.7K_04 *100K_04 *4.7K_04 SN75LVCP601 *0_04 SN75LVCP601 *452301-1 HGND HH1 H6_0D2_2 HSATA_TXP0_L HR12 *0_04 HR11 *0_04 HSATA_TXP0_R HSATA_TXN0_L HR14 *0_04 HR13 *0_04 HSATA_TXN0_R NC1 NC2 HGND *51824-0227A-001 HGNDP/N = 6-20-437J0-022 B HSATA_RXN0_L HR18 *0_04 HR17 *0_04 HSATA_RXN0_R HSATA_RXP0_L HR16 *0_04 HR15 *0_04 HSATA_RXP0_R PCBA CHECK HH3 C79D79N 1HHR *0_04 4HHR *0_04 2HHR *0_04 5HHR *0_04 3HHR *0_04 6HHR *0_04 ᙔ!Ϻ!ႝ!တ!!DMFWP!DP/ HH2 C79D79N Title Size A Date: HGND HC10 Sheet 38 of 38 HDD Board HGND HGNDHGNDHGND HGND PCB Footprint = 50887-0220A-XXX HGND HH4 H6_0D2_2 HGND + D02 to D02a ᢈΏICᏻɔፕḢ A D01 to D02 HC12 HC4 HC11 HC3 C P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 H_5VS HGND HGND HJ_HDD2 S1 S2 S3 S4 S5 S6 S7 H_3.3VS Closed TO REDRIVER IC GND1 GND2 B P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 DE2 EQ1 H_3.3VS C TX1P TX1N DEVICE HC5 HC6 *0.1u_10V_X7R_04 HOST HSATA_TXP0_R HSATA_TXN0_R *0.1u_10V_X7R_04 RX1P RX1N 15 14 *1u_6.3V_X5R_04 HSATA_RXN0_L HSATA_RXP0_L EN *10u_6.3V_X5R_06 GND EQ2 HSATA_TXP0_L HSATA_TXN0_L DEW2 VCC33 DEW1 VCC33 HGND DE1 HGND A [38] HDD BOARD(FOR 15") Document Number Thursday, August 27, 2015 Rev 6-71-N250N-D04 Sheet 38 3.0 of 39 HDD Board B - 39 B.Schematic Diagrams HGND 18 19 HU1 HJ_HDD1 S1 S2 S3 S4 S5 S6 S7 *4.7K_04 PIN16 T-PAD GND GND PIN10 21 13 PIN6 D *100u_6.3V_B_A HC9 B.Schematic Diagrams Schematic Diagrams B - 40 BIOS Update Appendix C:Updating the FLASH ROM BIOS To update the FLASH ROM BIOS, you must: • • • • • • • Download the BIOS Go to www.clevo.com.tw and point to E-Services and click E-Channel Use your user ID and password to access the appropriate download area (BIOS), and download the latest BIOS files (the BIOS file will be contained in a batch file that may be run directly once unzipped) for your computer model (see sidebar for important information on BIOS versions) Unzip the downloaded files to a bootable CD/DVD/ or USB Flash drive Insert a bootable CD/DVD/USB flash drive into the CD/DVD drive/USB port of the computer containing the downloaded files Use a tool such as Winzip or Winrar to unzip all the BIOS files and refresh tools to your bootable CD/DVD/USB flash drive (you may need to create a bootable CD/DVD with the files using a 3rd party software) BIOS Version Make sure you download the latest correct version of the BIOS appropriate for the computer model you are working on You should only download BIOS versions that are V1.01.XX or higher as appropriate for your computer model Note that BIOS versions are not backward compatible and therefore you may not downgrade your BIOS to an older version after upgrading to a later version (e.g if you upgrade a BIOS to ver 1.01.05, you MAY NOT then go back and flash the BIOS to ver 1.01.04) Set the computer to boot from the external drive With the bootable CD/DVD/USB flash drive containing the BIOS files in your CD/DVD drive/USB port, restart the computer and press F2 (in most cases) to enter the BIOS Use the arrow keys to highlight the Boot menu Use the “+” and “-” keys to move boot devices up and down the priority order Make sure that the CD/DVD drive/USB flash drive is set first in the boot priority of the BIOS Press F4 to save any changes you have made and exit the BIOS to restart the computer C - C:BIOS Update Download the BIOS update from the web site Unzip the files onto a bootable CD/DVD/USB Flash Drive Reboot your computer from an external CD/DVD/USB Flash Drive Use the flash tools to update the flash BIOS using the commands indicated below Restart the computer booting from the HDD and press F2 at startup enter the BIOS Load setup defaults from the BIOS and save the default settings and exit the BIOS to restart the computer After rebooting the computer you may restart the computer again and make any required changes to the default BIOS settings  BIOS Update Use the flash tools to update the BIOS Make sure you are not loading any memory management programs such as HIMEM by holding the F8 key as you see the message “EFI Shell” You will then be prompted to give “Y” or “N” responses to the programs being loaded by EFI Shell Choose “N” for any memory management programs You should now see DISK fsX:\> (X is the designated drive number for the CD/DVD drive/USB flash drive) Type the following command: C:BIOS Update fsX:\> Flash.nsh The utility will then proceed to flash the BIOS You should then be prompted to press any key to restart the system or turn the power off, and then on again but make sure you remove the CD/DVD/USB flash drive from the CD/DVD drive/USB port before the computer restarts Restart the computer (booting from the HDD) With the CD/DVD/USB flash drive removed from the CD/DVD drive/USB port the computer should restart from the HDD Press F2 as the computer restarts to enter the BIOS Use the arrow keys to highlight the Exit menu Select Load Setup Defaults (or press F3) and select “Yes” to confirm the selection Press F4 to save any changes you have made and exit the BIOS to restart the computer Your computer is now running normally with the updated BIOS You may now enter the BIOS and make any changes you require to the default settings C-2 ...Preface Notebook Computer N240JU / N241JU Service Manual Preface I Preface Notice The company reserves the right to revise this publication... C-2 X Introduction Chapter 1: Introduction Overview This manual covers the information you need to service or upgrade the N240JU / N241JU series notebook computer Information about operating... User’s Manual Information about dri-vers (e.g VGA & audio) is also found in the User’s Manual The manual is shipped with the computer Operating systems (e.g Window 8.1, etc.) have their own manuals