THÔNG TIN TÀI LIỆU
Electrical Wiring Diagrams Defender (LHD) VIN: 751063 > BY APPOINTMENT TO HER MAJESTY QUEEN ELIZABETH II MANUFACTURERS OF LAND ROVER VEHICLES LAND ROVER, WARWICK BY APPOINTMENT TO HIS ROYAL HIGHNESS THE DUKE OF EDINBURGH MANUFACTURERS OF LAND ROVER VEHICLES LAND ROVER, WARWICK BY APPOINTMENT TO HIS ROYAL HIGHNESS THE PRINCE OF WALES MANUFACTURERS OF LAND ROVER VEHICLES LAND ROVER, WARWICK Electrical Wiring Diagrams Defender (LHD) Published by Technical Communications, Land Rover Publication Part No JLR 13 30 21_2E, 08 2008 PREFACE While every effort is made to ensure accuracy, design changes to the vehicle may be made in the period between the completion of this publication and the introduction of vehicles PREFACE All rights reserved No part of this publication may be reproduced, stored in a retrieval system or transmitted in any form, electronic, mechanical, recording or other means without prior written permission from Land Rover Paper copies of this document are uncontrolled, always refer to the electronic source material for the latest information © 2008 Land Rover CONTENTS ABBREVIATIONS 415-00 - INFORMATION AND ENTERTAINMENT SYSTEM USING THIS PUBLICATION 50 417-01 - EXTERIOR LIGHTING Health and safety Using this publication Section numbering Circuit sheet numbering Understanding the circuit diagrams 3 3 206-09 - ANTI-LOCK CONTROL Rear fog guard lamps 51 Turn signal indicators and hazard flashers 53 Trailer socket 56 Stop and reverse lamps 58 Headlamp levelling 61 Head/Side lamps 62 417-02 - INTERIOR LIGHTING 65 303-06 - STARTING SYSTEM Starting and charging - D4 418-00 - MODULE COMMUNICATIONS NETWORK Diagnostic socket 67 303-14 - ELECTRONIC ENGINE CONTROLS D4 419-01 - ANTI-THEFT SYSTEM Active 68 Passive 71 412-01 - CLIMATE CONTROL 13 412-02 - AUXILIARY CLIMATE CONTROL 501-10 - SEATING Heated - front 72 Windshield heater 15 Rear window heater 16 Non air conditioning 17 413-00 - INSTRUMENT CLUSTER AND PANEL ILLUMINATION 501-11 - GLASS, FRAMES AND MECHANISMS Window lift 73 501-12 - INSTRUMENT PANEL AND CONSOLE 18 413-01 - INSTRUMENT CLUSTER 20 Cigar lighter 74 75 501-16 - WIPERS AND WASHERS Rear 76 Front 77 413-06 - HORN 23 413-07 - CLOCK 24 414-01 - BATTERY, MOUNTING AND CABLES Header joints Battery junction box Splices Ground distribution 25 30 36 44 ABBREVIATIONS ABBREVIATIONS Abbreviation Description ABS Anti-lock braking system ADRC Adaptive damping AFS Adaptive front lighting system AUTO Automatic transmission CAN Controller area network DAB Digital audio broadcasting DSC Dynamic stability control D4 Diesel engine - Straight-four DV6 Diesel engine - V6 DV8 Diesel engine - V8 EGR Exhaust gas recirculation FBH Fuel burning heater FET Field effect transistor GPS Global positioning system HS CAN High speed controller area network bus IC Instrument cluster IP Instrument panel PV6 Petrol engine - V6 PV8 Petrol engine - V8 PV8NA Naturally aspirated engine - V8 PV8SC Super charged engine - V8 LH Left-hand LIN Local interconnect network MAF/IAT Mass air flow / intake air temperature IBOC In band on channel MS CAN Medium speed controller area network bus NAS North American specification PDC Park distance control RH Right-hand SAI Secondary air injection SCL Steering column locking SDARS Satellite digital audio receiver system TCM Traction control module TPMS Tire pressure monitoring system DEFENDER (LHD) - VIN: 751063 > - Abbreviation Description TSD Touch screen display ULEV Ultra low emission vehicle USB Universal serial bus VICS Vehicle information control system USING THIS PUBLICATION USING THIS PUBLICATION Health and safety Section numbering Always follow health and safety guidelines, specifically those detailed in the Workshop Manual The sections in this publication are ordered to match the Global Outline numbering system as found in the current Workshop Manual The Power and Ground distribution circuits can be found under section 414-01, BATTERY, MOUNTING AND CABLES Note: Where circuit diagrams show more than one sub-system, the circuit will be located in the section that carries the first-named sub-system, for example: Starting and Charging will be located under section 303-06 Starting System, since 'Starting' is the firstnamed sub-system Using this publication The information provided in this publication is for use only by competent, qualified autoelectricians Good product knowledge is assumed, as well as the ability to access and use recommended test equipment and other reference material provided Test equipment and other reference material The information in this publication should be used in conjunction with the recommended test equipment; refer to Workshop Manual Other reference material includes: Technical Service Bulletins (TSB) and the Workshop Manual Circuit sheet numbering The Electrical Reference Library (ERL) may also prove useful since it provides detailed connector information Understanding the circuit diagrams Battery disconnection and reconnection It is imperative that any information relating to battery disconnection and reconnection is followed; refer to the appropriate sections in the Workshop Manual Fault Diagnosis Always use the recommended test equipment for correct and reliable fault diagnosis, refer to the Workshop Manual Harness Repair Repairs should only be undertaken for connectors where a Service Repair Kit is available; refer to the appropriate Electrical Reference Library (ERL) Note: Fibre Optic circuits cannot be repaired; refer to the Workshop Manual The figures in brackets to the left of the page number indicate a circuit sheet number and the total number of sheets per circuit, for example (01 / 05) represents sheet of Components Engine controlmodule (ECM) (D131) C0331-28 NS,0.35 C0331-7 NG,0.35 C0787-1 C0331-12 UG,0.35 C0787-2 C0331-14 YG,0.35 C0787-3 After each component description, a translation code is displayed in brackets, for example: Starter relay (R102), Engine control-module (ECM)(D131) The codes can be ignored Note: A dotted outline indicates that the component identified is not shown in its entirety Connectors Connectors and header joints are identified by their corresponding connector number with a numbered suffix to indicate the pin-out detail of the wire, i.e C0292-1 identifies connector 292, pin number Wire insulation colours are listed in a table at the end of this section Where wires have a predominant colour with a secondary colour tracer, the main colour is identified first, i.e WH-BK - white with a black tracer Wire length (Power and Ground Distribution only) The wire length (in millimetres) is displayed after the colour and cross sectional area; for example, SR,0.35,480 In this example, the figure, 480 indicates the approximate position of the harness splice is 480mm from connector C2335 DEFENDER (LHD) - VIN: 751063 > - USING THIS PUBLICATION Line Types Colour Codes Eject box-Telephone (F170) CODE COLOUR C1252-1 WR,MCGA C1646-1 C1644-1 BK or B BLACK C1252-2 U,MCGA C1646-2 C1644-2 BN or N BROWN BU or U BLUE GN or G GREEN Phone EAR+ Phone EAR- Crossed wires as illustrated above show an example of how a twisted pair of wires may be represented on the circuits GY or S GREY (slate) OG or O ORANGE Sheet2 PK or K PINK Sheet2 RD or R RED Header (K109) C0294-0 UR,0.35 C0463-23 C0322-23 UR,0.35 A C0294-0 UR,0.35 C0459-23 C0336-23 UR,0.35 B The arrows illustrated above show an example of the page break symbols, identifying that the circuit continues at the corresponding letter on the sheet number indicated VT or P PURPLE WH or W WHITE YE or Y YELLOW Wheel speed SensorRear-RH (T151) C0503-2 C0503-1 Diagnostic socket (V100) C0040-9 The cup and ball symbol represents the male and female halves of connector Most connectors plug directly into a component but some are wired directly to the component using a ‘flylead’ as with C0503 above Ground points Ground points are identified with an eyelet symbol and a connector number, except where components are grounded through its fixings, when only the eyelet is shown DEFENDER (LHD) - VIN: 751063 > - 206-09 - ANTI-LOCK CONTROL 206-09 - ANTI-LOCK CONTROL Battery (P100) C0192-1 C0045-1 B,40.0D C1661-1 Relay-ABSReturn pump (R173) N,10.0D 12.0 Volts C0508-3 WO,0.5D C0508-2 Pump-Return-ABS (M152) C0508-1 NR,4.0D C0508-4 B,0.5D A501 NR,4.0D C0507L-1 C0507L-2 B,3.0D Header-Earth (K108) C0550-2 C0550-1 Header (K109) C0289-5 C0289-4 B,1.5D Junction box-Battery (P147) C0632-1 LINK LINK 100.0 Amps 30.0 Amps FUSE C0571-2 NW,4.0D ABS module (D125) C0506-15 NR,1.5D C0506-1 SW,1.0D C0501L-1 C0506-2 SR,1.0D C0501L-2 C0506-3 B,1.0D C0501L-8 C0506-4 SG,1.0D C0501L-10 C0506-5 SU,1.0D C0501L-11 C0506-6 RB,1.0D C0501L-9 C0506-7 SY,1.0D C0501L-13 C0506-8 SN,1.0D C0501L-12 C0506-10 SP,1.0D C0501L-5 C0506-11 SK,1.0D C0501L-4 C0504-10 SP,0.5D C0872-B1 C0504-11 YK,0.5D C0872-K1 C0504-5 K,0.5D C0040L-7 C0504-12 B,1.5D Modulator-ABS (D124) C0573-4 NW,2.5D C0504-1 BATT 30.0 Amps LINK C0504-8 C0570-2 NW,4.0D A462 60.0 Amps NW,4.0D C0500L-1 B,2.5D C0434-1 Switch-Ignition (S176) C0028L-1 AUX IN1 2B IGN 2A IN2 CRANK C0094L-1 W,4.0D SJ3 Engine controlmodule (ECM) (D131) W,4.0D Junction box-Central (P101) C0580L-1 FUSE C0580L-4 Diagnostic socket (V100) GO,1.0D C0504-2 10.0 Amps GND DEFENDER (LHD) - VIN: 751063 > - C0362-1 (01 / 02) 206-09 - ANTI-LOCK CONTROL Wheel speed SensorFront-LH (T150) Wheel speed SensorFront-RH (T149) ABS module (D125) C0516-1 W,0.5D C0505-1 C0505-4 G,0.5D C0517-1 C0516-2 W,0.5D C0505-2 C0505-5 G,0.5D C0517-2 Wheel speed SensorRear-LH (T152) Wheel speed SensorRear-RH (T151) C0502-1 W,0.5D C0505-7 C0505-3 G,0.5D C0503-1 C0502-2 W,0.5D C0505-8 C0505-6 G,0.5D C0503-2 C0504-17 YS,0.5D C1040L-15 C0504-18 RS,0.5D C1040L-11 Instrument cluster (J100) BW,0.5D C0504-9 C1040L-12 Header (K109) Switch-Brakefluid level (S212) C0026L-1 DEFENDER (LHD) - VIN: 751063 > - C0288-19 C0288-18 BW,0.5D C0288-20 C0288-17 WY,0.5D Switch-Handbrake (S213) BW,0.5D C0091-1 (02 / 02) ... HIGHNESS THE PRINCE OF WALES MANUFACTURERS OF LAND ROVER VEHICLES LAND ROVER, WARWICK Electrical Wiring Diagrams Defender (LHD) Published by Technical Communications, Land Rover Publication Part... Manual Circuit sheet numbering The Electrical Reference Library (ERL) may also prove useful since it provides detailed connector information Understanding the circuit diagrams Battery disconnection... distribution circuits can be found under section 414-01, BATTERY, MOUNTING AND CABLES Note: Where circuit diagrams show more than one sub-system, the circuit will be located in the section that carries
Ngày đăng: 01/09/2018, 12:54
Xem thêm: