ECU của xe tích hợp một hệ thống tự chẩn đoán cho phép báo ra các hư hỏng của động cơ và các bộ phận khác mà không cần phải tháo rời các chi tiết để kiểm tra. Điều đó thực hiện nhờ các cảm biến theo dõi tình trạng của xe, gửi tín hiệu đến ECU để so sánh với các thông số chính xác mà nhà sản xuất đã tính toán từ trước. Nếu phát hiện sự sai khác hệ thống sẽ báo lỗi thông qua một bóng đèn nháy sáng, hoặc đưa ra một mã chẩn đoán đã được lưu trong bộ nhớ chương trình của vi điều khiển đến một thiết bị giao diện khác.
5E-FHE EXY10 TOYOTA SERA ECU phase I (march 1990 to may 1991) 26 pin plug ~ NSW THW PIM THA IGT IGF G1 G10 OX 11 STA 12 #10 13 E01 14 DISC 15 ~ 16 E2 17 PSW 18 VC 19 IDL 20 G2 21 NE 22 E21 23 KNK 24 E1 25 #20 26 E02 16 pin plug +B1 BATT CCO FC ELS AC2 ~ T +B 10 W 11 EGW 12 ~ 13 SPD 14 ACT 15 AC1 16 VF ~ Neutral Starter Switch Water Temparature Signal Pressure Intake Manifold Intake Air Temparature Ignition Timing Ignition Feedback from the Ignitor-Coil Distributor Distributor Crank Angle Oxygen Sensor (Lambda Sensor) Engine Cranking Signal (Starter Switch) Injector Pulse & Computer Ground Aux Control Valve or Idle-Up System Vacuum Switching Valve ~ Sensor Ground Throttle Position Sensor Throttle Position Sensor (Signals ECU throttle position is at idle) Distributor Part of the IIA (Intergrated Ignition Assembly) (RPM) Sensor Ground Knock Sensor Computer Ground Injector Pulse & Computer Ground Switched Battery Power (12V) Switched Battery Power (+12V) (EFI Main Relay) Check Connector Outputs Circuit Opening Relay (Fuel Cut) Electrical Load Signal System Taillight Relay 12V To Aircon Computer ~ Switched Battery Power (12V) Warning Light Catalytic Converter Temparature Warning Light (Combination Meter) ~ Speed Signal A/C Cut Control System A/C Switch Signal System (12V to Aircon Computer) Check Connector Outputs 5E-FHE EXY10 TOYOTA SERA ECU phase II & III (may 1991-June 1992 / June 1992 – December 1995) 26 pin plug IPV NSW THW PIM THA IGT IGF G1 G10 OX 11 STA 12 #10 13 E01 14 DISC 15 ~ 16 E2 c17 PSW 18 VC 19 IDL 20 G2 21 NE 22 E21 23 KNK 24 E1 25 #20 26 E02 16 pin plug +B1 BATT CCO FC ELS AC2 ~ T +B 10 W 11 EGW 12 ~ 13 SPD 14 ACT 15 AC1 16 VF Neutral Starter Switch Water Temparature Signal Pressure Intake Manifold Intake Air Temparature Ignition Timing Ignition Feedback from the Ignitor-Coil Distributor Distributor Crank Angle Oxygen Sensor (Lambda Sensor) Engine Cranking Signal (Starter Switch) Injector Pulse & Computer Ground Aux Control Valve or Idle-Up System Vacuum Switching Valve ~ Sensor Ground Throttle Position Sensor Throttle Position Sensor (Signals ECU throttle position is at idle) Distributor Part of the IIA (Intergrated Ignition Assembly) (RPM) Sensor Ground Knock Sensor Computer Ground Injector Pulse & Computer Ground Switched Battery Power (12V) Switched Battery Power (+12V) (EFI Main Relay) Check Connector Outputs Circuit Opening Relay (Fuel Cut) Electrical Load Signal System Taillight Relay 12V To Aircon Computer ~ Switched Battery Power (12V) Warning Light Catalytic Converter Temparature Warning Light (Combination Meter) ~ Speed Signal A/C Cut Control System A/C Switch Signal System (12V to Aircon Computer) Check Connector Outputs 4E-FTE EP82 ECU 89661-10040 GREEN STICKER ma-5450 26 pin plug ~ NSW THW PIM THA IGT IGF G1 G10 OX 11 STA 12 #10 13 E01 14 DISC 15 VSV1 16 E2 17 PSW 18 VC 19 IDL 20 G2 21 NE 22 E21 23 KNK 24 E1 25 #20 26 E02 16 pin plug +B1 BATT CCO FC ELS AC2 BC T +B 10 W 11 EGW 12 ~ 13 SPD 14 ACT 15 AC1 16 VF ~ Neutral Starter Switch Water Temparature Signal Pressure Intake Manifold Intake Air Temparature Ignition Timing Ignition Feedback from the Ignitor-Coil Distributor Distributor Crank Angle Oxygen Sensor (Lambda Sensor) Engine Cranking Signal (Starter Switch) Injector Pulse & Computer Ground Aux Control Valve or Idle-Up System Vacuum Switching Valve Air Control Vacuum Switching Valve Sensor Ground Throttle Position Sensor Throttle Position Sensor (Signals ECU throttle position is at idle) Distributor Part of the IIA (Intergrated Ignition Assembly) (RPM) Sensor Ground Knock Sensor Computer Ground Injector Pulse & Computer Ground Switched Battery Power (12V) Switched Battery Power (+12V) (EFI Main Relay) Check Connector Outputs Circuit Opening Relay (Fuel Cut) Electrical Load Signal System Taillight Relay 12V To Aircon Computer Boost Control Switched Battery Power (12V) Warning Light Catalytic Converter Temparature Warning Light (Combination Meter) ~ Speed Signal A/C Cut Control System A/C Switch Signal System (12V to Aircon Computer) Check Connector Outputs 4E-FTE EP82 ECU 89661-10100 BLACK STICKER 211000-0550 12v 4E-FTE EP82 ECU 89661-10100 GREEN STICKER ma-5970 26 pin plug IPV NSW THW PIM THA IGT IGF G1 G10 OX 11 STA 12 #10 13 E01 14 DISC 15 VSV1 16 E2 17 PSW 18 VC 19 IDL 20 G2 21 NE 22 E21 23 KNK 24 E1 25 #20 26 E02 16 pin plug +B1 BATT CCO FC ELS AC2 TE2 TE1 +B 10 W 11 EGW 12 AC1 13 SPD 14 ACT 15 BC 16 VF Vacuum Switching Valve Neutral Starter Switch Water Temparature Signal Pressure Intake Manifold Intake Air Temparature Ignition Timing Ignition Feedback from the Ignitor-Coil Distributor Distributor Crank Angle Oxygen Sensor (Lambda Sensor) Engine Cranking Signal (Starter Switch) Injector Pulse & Computer Ground Aux Control Valve or Idle-Up System Vacuum Switching Valve Air Control Vacuum Switching Valve Sensor Ground Throttle Position Sensor Throttle Position Sensor (Signals ECU throttle position is at idle) Distributor Part of the IIA (Intergrated Ignition Assembly) (RPM) Sensor Ground Knock Sensor Computer Ground Injector Pulse & Computer Ground Switched Battery Power (12V) Switched Battery Power (+12V) (EFI Main Relay) Check Connector Outputs Circuit Opening Relay (Fuel Cut) Electrical Load Signal System Taillight Relay 12V To Aircon Computer Check Connector Check Connector Switched Battery Power (12V) Warning Light Catalytic Converter Temparature Warning Light (Combination Meter) A/C Switch Signal System (12V to Aircon Computer) Speed Signal A/C Cut Control System Boost Control Check Connector Outputs 4E-FTE EP82 automatic ECU / part no 89661-10110 / code 211000-0630 13 26 12 25 11 24 10 23 26 pin plug IPV STA IGF NE G1 L SL S2 10 DISC 11 VSV1 12 #10 13 E02 14 ~ 15 NSW 16 SP2 17 G18 G2 19 DG 20 BC 21 S1 22 IGT 23 OD2 24 E1 25 #20 26 E01 22 26 PIN PLUG 21 20 19 18 17 16 15 14 16 15 14 16 PIN PLUG 13 12 11 Vacuum Switching Valve Engine Cranking Signal (Starter Switch) Ignition Feedback from the Ignitor-Coil Part of the IIA (Intergrated Ignition Assembly) (RPM) Distributor ECT "L" Selection Signal Shift Position Switch ECT "2" Selection Signal Shift Position Switch ECT Solenoid ECT Solenoid Aux Control Valve or Idle-Up System Vacuum Switching Valve Air Control Vacuum Switching Valve Injector Pulse & Computer Ground ~ Neutral Starter Switch No Vehicle Speed Sensor ECT in Auto-Transmission Distributor Crank Angle Distributor Check Connector Boost Control ECT Solenoid Ignition Timing Cruise Control Computer Computer Ground Injector Pulse & Computer Ground 16 pin plug STP Stop Light Switch PIM Pressure Intake Manifold THA Intake Air Temparature THW Water Temparature Signal 75 P Shift Position Switch (Parking) OX Oxygen Sensor (Lambda Sensor) TE2 Check Connector VF Check Connector Outputs E2 Sensor Ground 10 VTA/PSW Throttle Position Sensor 11 VCC Throttle Position Sensor (pin 1) 12 IDL Throttle Position Sensor (Signals ECU throttle position is at idle) 13 M Shift Position Switch 14 KNK Knock Sensor 15 TE1 Check Connector 16 E21 Sensor Ground 12 pin plug +B1 BATT CCO FC AC2 ACT +B W EGW 10 AC1 11 SPD 12 ELS Switched Battery Power (12V) Switched Battery Power (+12V) (EFI Main Relay) Check Connector Outputs Circuit Opening Relay (Fuel Cut) 12V To Aircon Computer A/C Cut Control System Switched Battery Power (12V) Warning Light Catalytic Converter Temparature Warning Light (Combination Meter) A/C Switch Signal System (12V to Aircon Computer) Speed Signal Electrical Load Signal System Taillight Relay 10 12 12 PIN PLUG 11 10 4E-FTE EP91 ECU pinout / part no 89661-10200 / code 211000-4290 13 26 12 25 11 24 10 23 26 pin plug IPV STA IGF NE G1 L SL S2 10 DISC 11 VSV1 12 #10 13 E02 14 ~ 15 NSW 16 SP2 17 G18 G2 19 DG 20 BC 21 S1 22 IGT 23 OD2 24 E1 25 #20 26 E01 22 26 PIN PLUG 21 20 19 18 17 16 15 14 16 15 14 16 PIN PLUG 13 12 11 10 12 12 PIN PLUG 11 10 Vacuum Switching Valve Engine Cranking Signal (Starter Switch) Ignition Feedback from the Ignitor-Coil Part of the IIA (Intergrated Ignition Assembly) (RPM) Distributor ECT "L" Selection Signal Shift Position Switch ECT "2" Selection Signal Shift Position Switch ECT Solenoid ECT Solenoid Aux Control Valve or Idle-Up System Vacuum Switching Valve Air Control Vacuum Switching Valve Injector Pulse & Computer Ground ~ Neutral Starter Switch No Vehicle Speed Sensor ECT in Auto-Transmission Distributor Crank Angle Distributor Check Connector Boost Control ECT Solenoid Ignition Timing Cruise Control Computer Computer Ground Injector Pulse & Computer Ground 16 pin plug STP Stop Light Switch PIM Pressure Intake Manifold THA Intake Air Temparature THW Water Temparature Signal P Shift Position Switch (Parking) OX Oxygen Sensor (Lambda Sensor) TE2 Check Connector VF Check Connector Outputs E2 Sensor Ground 10 VTA/PSW Throttle Position Sensor 11 VCC Throttle Position Sensor (pin 1) 12 IDL Throttle Position Sensor (Signals ECU throttle position is at idle) 13 M Shift Position Switch 14 KNK Knock Sensor 15 TE1 Check Connector 16 ~ ~ 12 pin plug +B1 BATT CCO FC AC2 ACT +B W EGW 10 AC1 11 SPD 12 ELS Switched Battery Power (12V) Switched Battery Power (+12V) (EFI Main Relay) Check Connector Outputs Circuit Opening Relay (Fuel Cut) 12V To Aircon Computer A/C Cut Control System Switched Battery Power (12V) Warning Light Catalytic Converter Temparature Warning Light (Combination Meter) A/C Switch Signal System (12V to Aircon Computer) Speed Signal Electrical Load Signal System Taillight Relay as you can see pin 16 on 16 pin connector isn't used That's the only difference between the two ecus except the size of them 1995 US Paseo 5E-FE (AUTOMATIC) CALIFORNIA 13 26 12 25 11 24 10 23 26 pin plug SL STA IGF NE+ ~ ~ S2 ~ RSC 10 RSO 11 HT2 12 #10 13 E01 14 HT1 15 NSW 16 EGR 17 NE18 G2 19 20 L 21 IGT2 22 IGT1 23 SP2 24 E1 25 #20 26 S1 16 pin plug DG PIM THA THW OX2 OX1 TE2 VF E2 10 VTA 11 VCC 12 IDL 13 THG 14 KNK 15 TE1 16 ~ 12 pin plug STP BATT OD1 FC ~ ACT +B W OD2 10 AC1 11 SPD 12 ~ 22 26 PIN PLUG 21 20 19 18 17 16 15 14 16 15 14 16 PIN PLUG 13 12 11 10 12 12 PIN PLUG 11 10 1995 US Paseo 5E-FE (MANUAL) CALIFORNIA 26 pin plug RSC ~ THW PIM IGT2 IGT1 IGF KNK ne10 ox1 11 sta 12 #10 13 e01 14 rso 15 THA 16 E2 17 VTA 18 VCC 19 IDL 20 G2 21 NE+ 22 THG 23 OX2 24 E1 25 #20 26 ~ 16 pin plug ~ BATT ~ FC HT2 HT1 TE2 TE1 +B 10 W 11 ~ 12 AC1 13 SPD 14 ACT 15 EGR 16 VF Water Temparature Signal Pressure Intake Manifold Ignition Feedback from the Ignitor-Coil Knock Sensor 1995 US Paseo 5E-FE (MANUAL) NOT CALIFORNIA 26 pin plug FPU NSW THW PIM THA IGT IGF G G10 OX 11 STA 12 #10 13 E01 14 DISC 15 ~ 16 E2 17 VTA 18 VCC 19 IDL 20 NE21 NE 22 ~ 23 ~ 24 E1 25 #20 26 E02 16 pin plug ~ BATT ~ FC ELS ~ ~ T +B 10 W 11 AC1 12 ~ 13 SPD 14 ACT 15 ~ 16 VF Water Temparature Signal Pressure Intake Manifold Ignition Feedback from the Ignitor-Coil 1995 US Paseo 5E-FE (AUTO) NOT CALIFORNIA 26 PIN PLUG 13 26 12 25 11 24 10 23 26 pin plug SL S1 IGF NE G TWS TOV FPU 10 DISC 11 #20 12 #10 13 E01 14 E1 15 S2 16 SP2 17 NE18 G19 L 20 IDL 21 ~ 22 ~ 23 EGR 24 ~ 25 ~ 26 E02 16 pin plug VCC PIM THA THW ~ OX DG VF E2 10 THG 11 VTA 12 IDL 13 ~ 14 ~ 15 T 16 ~ 22 21 20 19 16 PIN PLUG 18 17 16 15 14 16 15 14 13 12 22 PIN PLUG 11 10 22 pin plug BATT ELS ~ STP W ~ OD2 ~ SPD 10 AC1 11 STA 12 +B 13 ~ 14 FC 15 ~ 16 ~ 17 ~ 18 ~ 19 ~ 20 OD1 21 ACT 22 NSW 11 22 10 21 20 19 18 17 16 15 14 13 12 DATA SOURCES TOYOTA SERA - JAPANESE WORKSHOP MANUALS BY ANDREW CLIFFE / WWW.TOYOTASERA.CO.UK TOYOTA STARLET – FROM WWW.STREETLEGALSTARLET.NL AND WWW.TOYOTAGTTURBO.COM TOYOTA PASEO – FROM US WORKSHOP MANUAL 1995 EDITION, ANDREW CLIFFE / WWW.TOYOTASERA.CO.UK ... 13 12 DATA SOURCES TOYOTA SERA - JAPANESE WORKSHOP MANUALS BY ANDREW CLIFFE / WWW.TOYOTASERA.CO.UK TOYOTA STARLET – FROM WWW.STREETLEGALSTARLET.NL AND WWW.TOYOTAGTTURBO.COM TOYOTA PASEO – FROM... VF ~ Neutral Starter Switch Water Temparature Signal Pressure Intake Manifold Intake Air Temparature Ignition Timing Ignition Feedback from the Ignitor-Coil Distributor Distributor Crank Angle... Valve Neutral Starter Switch Water Temparature Signal Pressure Intake Manifold Intake Air Temparature Ignition Timing Ignition Feedback from the Ignitor-Coil Distributor Distributor Crank Angle