Waste water treatment system design dod 1997 handbook

INCH-POUND MIL-HDBK-1005/16 31 OCTOBER 1997 SUPERSEDING TM-5-814-3 AFM 88-11 VOLS 1, 2, AND MARCH 1985 MIL-HDBK 1005/8 FEBRUARY 1997 DEPARTMENT OF DEFENSE HANDBOOK WASTEWATER TREATMENT SYSTEM DESIGN AUGMENTING HANDBOOK AMSC N/A AREA FACR Distribution Statement A APPROVED FOR PUBLIC RELEASE: DISTRIBUTION IS UNLIMITED MIL-HDBK-1005/16 ABSTRACT This handbook augments six Water Environment Federation (formerly Water Pollution Control Federation) manuals selected by the Department of Defense to serve as basic design guidance These Water Environment Federation (WEF) manuals address most topics pertinent to wastewater treatment system design However, some topics important to military facilities are not covered in detail in the WEF manuals or require particular emphasis This handbook addresses those topics and includes the following topic areas: wastewater treatment facility planning and design development (including regulatory compliance and management), wastewater flow rates and characteristics, Navy wastewater collection and transmission systems, oil and water separators, package plants and small flow treatment systems, lagoon systems, chemical storage and handling considerations, effluent disposal/ reclamation, solids conveyance and solids pretreatment, laboratory facilities and sample collection system design, and corrosion control ii MIL-HDBK-1005/16 FOREWORD This handbook is approved for use by all Departments and Agencies of the Department of Defense It is intended to guide the reader in the design of wastewater treatment systems Commercial equipment and materials mentioned in this handbook are included for illustration purposes and not constitute an endorsement Beneficial comments (recommendations, additions, deletions) and any pertinent data which may be of use in improving this document or the WEF manuals should be submitted on the DD Form 1426 Standardization Document Improvement Proposal and addressed through major commands to: Air Force: HQ AFCESA/CESC, 139 Barnes Dr., Suite 1, Tyndall AFB, FL 32403-5319 Army: HQ USACE/CEMP-ET, 20 Massachusetts Avenue, Northwest, Washington, DC 20314-1000 Navy: NAVFAC Criteria Office, 1510 Gilbert St., Norfolk, VA 23511-2699 DO NOT USE THIS HANDBOOK AS A REFERENCE IN A PROCUREMENT DOCUMENT FOR FACILITIES CONTRUCTION IT IS TO BE USED IN THE PURCHASE AND PREPARATION OF FACILITIES PLANNING AND ENGINEERING STUDIES AND DESIGN DOCUMENTS USED FOR THE PROCUREMENT OF FACILITIES CONSTRUCTION (SCOPE, BASIS OF DESIGN, TECHNICAL REQUIREMENTS, PLANS, SPECIFICATIONS, COST ESTIMATES, REQUEST FOR PROPOSALS, AND INVITATION FOR BIDS) DO NOT REFERENCE IT IN MILITARY OR FEDERAL SPECIFICATIONS OR OTHER PROCUREMENT DOCUMENTS iii MIL-HDBK-1005/16 WASTEWATER TREATMENT SYSTEM DESIGN CRITERIA MANUALS Criteria Manual Title Preparing Activity MIL-HDBK-1005/9 Industrial and Oily Wastewater Control NAVFACENGCOM 15C EI 11C201 Wastewater Collection and Pumping HQ USACE-CEMP Military-adopted commercial wastewater treatment system guidance (Primary Design Guidance Document), published by WEF: Design of Municipal Wastewater Treatment Plants (Manual of Practice [MOP] 8, Volumes I and II) (Jointly published with the American Society of Civil Engineers [ASCE] as Report on Engineering Practice No 76.) Gravity Sanitary Sewer Design and Construction (MOP FD-5) (Jointly published with ASCE as Report on Engineering Practice No 60.) Design of Wastewater and Stormwater Pumping Stations (MOP FD-4) Alternative Sewer Systems (MOP FD-12) Existing Sewer Evaluation and Rehabilitation (MOP FD-6) (Jointly published with ASCE as Report on Engineering Practice No 62.) Wastewater Disinfection (MOP FD-10) iv MIL-HDBK-1005/16 WASTEWATER TREATMENT SYSTEM DESIGN GUIDANCE DOCUMENT AUGMENTING HANDBOOK CONTENTS Section 1.1 1.1.1 1.1.2 1.1.3 1.2 1.3 Section 2.1 2.2 2.2.1 2.2.2 2.2.2.1 2.2.2.2 2.2.3 2.2.4 2.3 2.3.1 2.3.2 2.3.2.1 2.3.2.2 2.3.3 2.3.3.1 2.3.3.2 2.3.4 2.3.5 2.3.6 2.4 2.5 2.5.1 2.5.2 2.6 Page INTRODUCTION Scope of This Handbook Use and Limitations Primary Design Guidance Documents Augmenting Handbook Organization of Handbook Cancellation WASTEWATER TREATMENT FACILITY PLANNING AND DESIGN DEVELOPMENT Introduction Regulatory Compliance and Management Federally Owned Treatment Works (FOTWs) Permitting Requirements Stormwater NPDES Permit Residual Solids Permit Permit Renewal Permit Application Forms Governing Effluent Limitations Current Trends in the Wastewater Industry That Affect Effluent Permitting Water Quality Standards Waste Load Allocation Chemical-Specific Criteria Wastewater Effluent Toxicity Aquatic Life Criteria General Narrative Criteria Negotiation of Effluent Limits Wastewater Reuse 10 Land Disposal 11 Design Requirements for Cold Climates 11 Facilities Planning 12 Capacity Analysis Report 12 Operation and Maintenance Report 13 Programming 13 v MIL-HDBK-1005/16 Page Section 2.7 2.7.1 2.7.2 2.7.2.1 2.7.2.2 2.7.2.3 2.7.3 2.7.4 2.8 2.8.1 2.8.2 2.8.3 2.9 2.10 Preliminary Engineering Report Design Basis Alternatives Evaluations Life-Cycle Costs Evaluation Non-Monetary Evaluation Alternatives Selection Recommended Plan Beneficial Reuse of Solids O&M Manuals Operations Manual Maintenance Manual Maintenance Summary Forms Startup Training Performance Testing 3.1 3.2 3.2.1 3.2.2 3.2.3 3.2.3.1 WASTEWATER FLOW RATES AND CHARACTERISTICS Introduction Wastewater Sources and Characteristics Domestic Wastewater Flow Infiltration and Inflow Industrial Wastewater Vehicle and Aircraft Maintenance and Wash Facilities Additional Resources Closed-Loop Recycling Ship Holding Tank Discharges Quantifying Wastewater Flows and LoadsDesign Basis Development Wastewater Flow Estimate Terminology Flow Estimating Methodology Design Populations Domestic Flows, Annual Average Domestic Flows, Maximum Daily Flow Domestic Flow, Peak Flow Domestic Flows, Minimum Flow Infiltration Inflow Industrial Flows 3.2.3.2 3.2.3.3 3.2.4 3.3 3.3.1 3.3.2 3.3.2.1 3.3.2.2 3.3.2.3 3.3.2.4 3.3.2.5 3.3.2.6 3.3.2.7 3.3.2.8 vi 13 13 14 15 15 16 18 18 19 19 20 22 23 23 25 25 25 25 27 27 28 28 30 31 31 32 32 33 33 34 35 35 35 35 MIL-HDBK-1005/16 3.3.2.9 3.3.2.10 3.3.3 3.3.3.1 3.3.3.2 3.3.3.3 3.3.3.4 Section 4.1 4.2 4.2.1 4.2.2 4.2.3 4.2.4 4.2.5 4.2.6 4.2.7 4.2.8 4.3 4.3.1 4.3.2 4.3.3 4.3.4 Section 5.1 5.2 5.2.1 5.2.2 5.2.3 5.3 5.3.1 5.3.2 Page Ship Discharges 36 Flow Rate Variations 36 Wastewater Loadings 40 Domestic Wastes 40 Industrial Wastes 40 Ship Sewage 40 Effect of Wastewaters with High Seawater Content 41 NAVY WASTEWATER COLLECTION AND TRANSMISSION SYSTEMS Introduction Pier and Wharf Systems Layout/Location Utility Connections Environmental Considerations (Corrosion, Freeze Protection) Odor/Septicity Control Structures and Appurtenances Pump Stations Pipe Sewage Transfer Hoses Drydock Facilities Layout Pump Station Features Sewage Receiving Connections and Transfer Hoses Special Structures and Appurtenances OIL/WATER SEPARATORS Section Overview Oil Classification Fre Oil Emulsified Oil Oily Wastes Basis for Considering Oil/Water Separators Regulatory Compliance Related Impacts on Collection/Treatment Systems vii 43 43 43 46 51 53 53 53 53 56 56 60 60 60 60 65 65 65 65 65 66 66 67 MIL-HDBK-1005/16 Page 5.4 5.5 5.5.1 5.5.1.1 5.5.1.2 5.5.2 5.5.3 5.5.3.1 5.5.3.2 5.5.3.3 5.5.4 5.6 5.6.1 5.6.2 5.6.3 5.6.4 5.6.5 5.7 5.8 Section 6.1 6.1.1 6.1.2 6.2 6.2.1 6.2.2 6.2.3 6.2.4 6.3 6.3.1 6.3.2 6.3.3 6.3.3.1 6.3.3.2 6.3.3.3 6.3.3.4 Evaluating the Need for Oil/Water Separators Treatment Technology Gravity Separation Conventional Gravity Separators Parallel Plate Separators Air Flotation Separators Treatment of Emulsified Oil Destabilization Chemical Processes Mechanical Impingement and Filtration Processes Treatment of Dissolved Oil Design of OWSs Wastewater Characterization Site Considerations Establishing the Design Flow Design Criteria for Conventional Separators Design Criteria for Parallel-Plate Separators Oil/Sludge Removal and Disposal Guidance Documents PACKAGE PLANTS AND SMALL FLOW TREATMENT SYSTEMS General Types of Small Flow Treatment Systems Unique Characteristics of Small Flow Treatment Systems Package Plant Systems Types of Treatment Processes Evaluation of Particular Packages Performance Certification Capacity Ranges Septic Tank Systems Size Detention Time Effluent Disposal Subsurface Absorption Leaching Wells Subsurface Sand Filters Percolation Tests viii 67 70 70 71 73 74 75 75 75 77 77 77 78 78 78 79 80 81 81 83 83 83 84 84 84 84 84 89 89 91 91 91 92 92 94 MIL-HDBK-1005/16 6.4.7 6.4.8 6.4.9 6.5 6.5.1 6.5.2 6.5.3 6.6 6.6.1 6.6.2 6.6.3 6.7 6.7.1 6.7.2 Page Mound Systems 94 Description 97 Site Considerations 97 Depth to Pervious Rock 97 Depth to High Water Table 101 Depth to Impermeable Soil Layer or Rock Strata 101 Depth to 50 Percent Volume Rock Fragments 101 Slopes 102 Special Siting Considerations 103 Basal Area Calculation 103 Waterless Toilets 104 Humus “Composting” Toilets 104 Chemical Toilets 104 Aerated Pit Latrines 105 Filtration/Reuse Systems 105 Recirculation Tank 106 Recirculation 106 Design Information 106 Garbage Grinders and Grinder Pumps 106 Garbage Grinders 108 Grinder Pumps 108 7.1 7.2 7.2.1 7.2.2 7.2.3 7.2.4 7.3 7.3.1 7.3.1.1 7.3.1.2 7.3.2 7.3.3 7.3.4 7.3.5 LAGOON SYSTEMS Background Lagoon Applications Facultative Lagoons Aerated Lagoons Aerobic Lagoons Anaerobic Lagoons Facultative Lagoon Design Sizing Basis: Loadings for Raw Sewage Depth Design Equations Location Exposure Inlets and Outlets Construction 6.4 6.4.1 6.4.2 6.4.3 6.4.4 6.4.5 6.4.6 Section ix 109 109 110 111 111 113 113 113 114 114 114 115 115 115 MIL-HDBK-1005/16 7.3.6 7.3.7 7.4 7.4.1 7.4.1.1 7.4.1.2 7.4.1.3 7.4.2 7.4.3 7.4.4 7.4.5 7.4.6 7.5 7.5.1 7.5.1.1 7.5.1.2 7.5.1.3 7.6 7.7 7.7.1 7.7.2 7.7.3 Section 8.1 8.2 8.2.1 8.2.2 8.2.2.1 8.2.2.2 8.2.2.3 8.2.2.4 8.2.3 8.2.4 8.3 Page Layout 115 Performance 115 Aerated Lagoon Design 115 Sizing Basis 116 Number of Equally Sized Basins 116 Design Conditions 116 Performance and Operating Requirements 116 Layout 123 Construction 123 Dimensions 123 Inlets and Outlets 123 Protection 123 Aerobic Lagoon Design 123 Sizing Basis 124 Loading 124 Depth 124 Applications 124 Anaerobic Lagoon Design 125 Lagoon Sealing 125 Bentonite Admixtures 126 Asphalt and Cement Linings 126 Thin Membrane Liners 126 CHEMICAL STORAGE AND HANDLING CONSIDERATIONS Information and Resources 128 Designer’s Checklists 128 Chemical Handling Checklist 128 Chemical Storage Checklist 129 Storage for All Chemicals 129 Storage for Dry or Containerized Chemicals 130 Storage for Liquid Chemicals 130 Storage for Liquified Gas Cylinders 130 Feed Equipment Checklist 131 Safety Checklist 131 Codes and Regulations 132 x MIL-HDBK-1005/16 OTHER GOVERNMENT DOCUMENTS AND PUBLICATIONS: Municipal Wastewater Lagoon Study, Report to Congress EPA 600/3-86-005 Ultraviolet Disinfection of Wastewater from Secondary Effluent and Combined Sewer Overflows EPA 600/4-82-029 Handbook for Sampling and Sample Preservation of Water and Wastewater EPA 625/1-81-013a Process Design Manual for Land Treatment of Municipal Wastewater, Supplement on Rapid Infiltration and Overland Flow EPA SW-870 Lining of Waste Impoundment and Disposal Facilities EPA/G25/R-92-013 Environmental Regulations and Technology: Control of Pathogens and Vector Attraction in Sewage Sludge (Including Domestic Sewage) Under 40 CFR Part 503 EPA-600/4-82-029 Handbook for Sampling and Sample Preservation of Water and Wastewater EPA-625/1-79-001 Process Design Manual for Sludge Treatment and Disposal EPA-625/1-80-012 Process Design Manual for Onsite Wastewater Treatment and Disposal Systems EPA-625/1-83-015 Design Manual for Municipal Wastewater Stabilization Ponds 224 MIL-HDBK-1005/16 FED MCD-54 Wastewater Stabilization Pond Linings (Unless otherwise indicated, copies are available from U.S Environmental Protection Agency, Office of Water Program Operations, Washington, DC) NCEL CR-70.11 Analysis of Wastewater Treatment and Disposal Systems for Advanced Bases NCEL R-593 Freeze Protection for Freshwater and Sanitary Piping Under Open Piers (Unless otherwise indicated, copies are available from Naval Facilities Engineering Service Center, Port Hueneme, CA 93043-4328) CCB Construction Criteria Base (Unless otherwise indicated, copies are available from National Institute of Building Services, 1201 L Street, Northwest, Suite 400, Washington, D.C 20005) DTRC/SME-91/53 Catalog of Shipboard Pollution Abatement Systems (Unless otherwise indicated, copies are available from David Taylor Research Center, Bethesda, MD 20084-5000) AMERICAN PETROLEUM INSTITUTE API Publication 421 Design and Operation of Oil/Water Separators (Unless otherwise indicated, copies are available from API, 1220 L Street, Northwest, Washington, D.C 22005) 225 MIL-HDBK-1005/16 AMERICAN WATER WORKS ASSOCIATION (AWWA) Safety Practice for Water Utilities (Unless otherwise indicated, copies are available from AWWA, 6666 W Quincy Avenue, Denver, CO 80235) AMERICAN SOCIETY OF CIVIL ENGINEERS (ASCE) Photosynthesis in Sewage Treatment 1957 Cold Regions Utilities Monograph 1996 (Unless otherwise indicated, copies are available from ASCE, 1015 15th St NW, Suite 600, Washington, DC 20005) AMERICAN SOCIETY FOR TESTING AND MATERIALS (ASTM) ASTM B695, Specification of Coatings of Zinc Mechanically Deposited on Iron and Steel) ASTM A380, Standard Practice for Cleaning and Descaling Stainless Steel Parts, Equipment, and Systems ASTM D3299, Standard Specification for Filament-Wound GlassFiber-Reinforced Thermoset Resin Chemical-Resistant Tanks ASTM D4097, Standard Specification for Contact-Molded GlassFiber-Reinforced Thermoset Resin Chemical-Resistant Tanks (Unless otherwise indicated, copies are available from ASTM, 1916 Race St., Philadelphia, PA 19813-1187) NATIONAL ASSOCIATION OF CORROSION ENGINEERS (NACE) RP0169, Control of External Corrosion and Underground or Submerged Metallic Piping Systems RP0178, Fabrication Details, Surface Finish Requirements, and Proper Design Considerations for Tanks and Vessels to be Lined for Immersion Service RP0180, Cathodic Protection of Pulp and Paper Mill Effluent Clarifiers 226 MIL-HDBK-1005/16 RP0286, The Electrical Isolation of Cathodically Protected Pipelines RP0296, Galvanic Anode Cathodic Protection of Internal Submerged Surfaces of Steel Water Storage Tanks RP0388, Impressed Current Cathodic Protection of Internal Submerged Surfaces of Steel Water Storage Tanks RP0391, Materials for the Handling and Storage of Concentrated (90 to 100%) Sulfuric Acid at Ambient Temperatures RP0572, Design, Installation, Operation, and Maintenance of Impressed Current Deep Groundbeds (Available from NACE, Post Office Box 218340, Houston, Texas 77218) STEEL STRUCTURES PAINTING COUNCIL (SSPC) SSPC SP1 Solvent Cleaning SSPC SP2 Hand Tool Cleaning SSPC SP3 Power Tool Cleaning SSPC SP5 White Metal Blast Cleaning SSPC SP6 Commercial Blast Cleaning SSPC SP7 Brush-Off Blast Cleaning SSPC SP8 Pickling SSPC SP10 Near-White Blast Cleaning SSPC SP11 Power Tool to Bare Metal SSPC SP12 High- and Ultrahigh-Pressure Water Jetting (Available from SSPC, 40 24th Street, 6th Floor, Pittsburgh, PA 15222-4643.) WATER ENVIRONMENT FEDERATION (WEF) WEF MOP 8, Design of Wastewater Treatment Plants, Volumes I and II) (Jointly published with the American Society of 227 MIL-HDBK-1005/16 Civil Engineers [ASCE] as Report on Engineering Practice No 76.) MOP FD-5, Gravity Sanitary Sewer Design and Construction (Jointly published with ASCE as Report on Engineering Practice No 60.) MOP FD-4, Design of Wastewater and Stormwater Pumping Stations MOP FD-12, Alternative Sewer Systems MOP FD-6, Existing Sewer Evaluation and Rehabilitation (Jointly published with ASCE as Report on Engineering Practice No 62.) MOP FD-10, Wastewater Disinfection (Available from WEF, 601 Wythe Street, Alexandria, VA 22314-1994) AUTHORED PUBLICATIONS: Adams and Eckenfelder Process Design Techniques for Industrial Waste Treatment Aldridge, Thomas D., Jr "What Is an Oil/Water Separator, and Why I Need One?" Pollution Equipment News December 1996 American Society of Agricultural Engineers On-Site Sewage Treatment American Society of Agricultural Engineers, Publication 1-82 St Joseph, MO 49085 1984 BIF/General Signal Chemicals Used in Treatment of Water and Wastewater/Engineering Data BIF Technical Bulletin 5/70 (supersedes 6/61) Ref 1.21-15 Boyle, W.C., and R.J Otis On-Site Treatment Environmental Research Information Center, Office of Research and Development EPA, Cincinnati, OH 45268 1982 Clark, Douglas W Laboratory Planning for Water and Wastewater Analysis Miscellaneous Report No M20 New Mexico State University and New Mexico Water Resources Research Institute 1988 228 MIL-HDBK-1005/16 Curds, C.R., and H.A Hawkes Ecological Aspects of Used Water Treatment Volume Academic Press 1975 Driscoll, Fletcher Ground Water and Wells 2nd Edition Johnson Filtration Systems, Inc 1986 Ecology and Environment, Inc Wastewater Pretreatment Systems with Emphasis on Recycling and Reuse Prepared for Air Combat Command, 1996 Environmental Training Symposium, St Louis, Missouri February 12-16, 1996 Prepared by Ecology and Environment, Inc., Lancaster, NY Eikum, A.S., and R.W Seabloom Alternative Wastewater Treatment (Reidel-Holland), Kluwer-Academic 1982 Fay, S.C., and R.H Walke The Composting Option for Human Waste Disposal in the Backcountry Forest Service Research Note NE-246, N.E Forest Service, USDA, Upper Darby, PA 19082 1975 Fischer, List, Koh, Imberger, and Brooks Coastal Waters 1979 Mixing in Inland and Grady and Lim Biological Wastewater Treatment: Theory and Applications Pollution Engineering and Technology Series Volume 12 Dekker 1985 Great Lakes-Upper Mississippi River Board of State Public Health and Environmental Managers (Great Lakes) Recommended Standards for Wastewater Facilities 1990 Ground Water Protection Council Ground Water Protection Council Class II Injection Well Integrity Basic Training Course Ground Water Protection Council 1994 12.3.3 Groundwater Recharge Using Waters of Impaired Quality, National Research Council, National Academy Press, 1994 Harris, S.E., J.J Reynolds, D.W Hill, D.S Filip, and E.J Middlebrooks Intermittent Sand Filtration for Upgrading Waste Stabilization Pond Effluents JWPCF 49:83-102 1977 Hartenstein, R., and M.J Mitchell Utilization of Earthworms and Micro-organisms in Stabilization and Detoxification of Residue Sludges from Treatment of Wastewaters NSF Report Grant ENV-7-06994 1978 229 MIL-HDBK-1005/16 Hutzler, N.J., R.J Otis, and W.C Boyle Field and Laboratory Studies of Onsite Household Wastewater Treatment Alternatives Proceedings of Ohio Home Sewage Disposal Conference, Ohio State University Columbus, OH 1984 Johnson, A.I., and Donald J Finlayson Artificial Recharge of Groundwater Proceedings of the International Symposium August 1988 American Society of Civil Engineers Kardos, L.T., W.E Sopper, E.A Myers, R.R Parizek, and J.B Nesbitt Renovation of Secondary Effluent for Re-use as a Water Resource Office of Research and Development EPA-66012-74-016 1974 Kreft, P., et al., “Hydraulic Studies and Cleaning Evaluations of Ultraviolet Disinfection Units.” Journal of the Water Pollution Control Federation Volume 58, 1129 1986 Liech, H New Options for a Sewerless Society Summer 1976 Compost Science Mancini and Barnhart Advances in Water Quality Improvement "Industrial Waste Treatment in Aerated Lagoons." 1968 Metcalf & Eddy, Inc., Wastewater Engineering: Treatment, Disposal, and Reuse 2nd Edition, New York, NY, McGraw-Hill Book Company 1991 Pyne, David Groundwater Recharge and Wells, a Guide to Aquifer Storage Recovery Lewis Publishers 1994 Ronayne, M.P., R.C Paeth, and T.J Osbourne Intermittent Sand Filter Design and Performance: An Update Proceedings, 4th N.W Onsite Wastewater Disposal Short Course University of Washington Seattle, WA 1982 Wagner, E.G., and J.N Lanoix Excreta Control for Rural Area World Heath Organization Palais des Nations, Geneva 1982 White, Clifford Handbook and Chlorination and Alternative Disinfectants Third Edition 1992 230 MIL-HDBK-1005/16 GLOSSARY Abbreviation or Acronym Definition A/E architectural engineering AC alternating current ACI American Concrete Institute AFFF aqueous film forming foam AGE aircraft ground equipment API American Petroleum Institute ASAE American Society of Agricultural Engineers ASCE American Society of Civil Engineers ASIP Army Stationing and Installation Plan ASR aquifer storage recovery ASTM American Society for Testing and Materials AWWA American Water Works Association BOD biochemical oxygen demand BOD5 5-day biochemical oxygen demand BTEX benzene, toluene, ethylbenzene, and xylene cal/sq m/d calories per square meter per day CBOD carbonaceous biochemical oxygen demand CE Civil Engineering CFR Code of Federal Regulations CHT Collection-Holding-Transfer 231 MIL-HDBK-1005/16 CMA Chemical Manufacturing Association COE U.S Army Corps of Engineers CPI corrugated plate interceptor CPVC chlorinated polyvinylchloride cu ft/day cubic feet per day cu m/d cubic meters per day cu m/d/sq m cubic meters per day per square meter CWA Clean Water Act DC direct current DO dissolved oxygen DoD Department of Defense DPDO Defense Property Disposal Office EPA U.S Environmental Protection Agency FGS Final Governing Standards FOTW federally owned treatment works fps feet per second FRP fiberglass-reinforced plastic gpcd gallons per capita per day gpd gallons per day gpd/in.-mi gallons per day per inch diameter mile gpd/sq ft gallons per day per square foot gpm gallons per minute HDPE high density polyethylene 232 MIL-HDBK-1005/16 hp horsepower hp/MG horsepower per million gallons HVAC heating, ventilating and air conditioning I/I infiltration and inflow kg/d kilograms per day kg/day/ha kilograms per day per hectare kPa kiloPascals L liters L/s liters per second lb/d pounds per day Lpcd liters per capita per day Lpd liters per day Lpd/mm-km liters per day per millimeter diameter kilometer Lpd/sq m liters per day per square meter m meter m/s meters per second MCC motor control center mg/L milligrams per liter mgd million gallons per day MI mechanical integrity MILCON Military Construction mL milliliter ML/d million liters per day 233 MIL-HDBK-1005/16 mm millimeter MOP Manual of Practice MSDS material safety data sheet N/A not applicable NACE National Association of Corrosion Engineers NAF nonappropriated funds NCEL Naval Civil Engineering Laboratory NFPA National Fire Protection Association NPDES National Pollutant Discharge Elimination System O&M operations and maintenance O3 ozone OSHA Occupational Safety and Health Act OWS oil/water separator PTFE polytetrafluorothylene POLs petroleum, oil, and lubricants POTW publicly owned treatment works PPI parallel plate interceptor psig pounds per square inch gage pressure PVC polyvinylchloride RAMP Requirements and Management Plan RAS return activated sludge RCRA Resource Conservation and Recovery Act RPM Real Property Maintenance 234 MIL-HDBK-1005/16 SAR sodium exchange capacity/sodium absorption ratio SCBA self-contained breathing apparatus SI international system SS suspended solids SSPC Steel Structures Painting Council SWMU solid waste management unit SWOB ship waste offload barge TMDL total maximum daily load TSS total suspended solids UIC Underground Injection Control Rules UV ultraviolet VPI vapor phase inhibitor VSS volatile suspended solids WAS waste activated sludge WEF Water Environment Federation WWTP wastewater treatment plant 235 MIL-HDBK-1005/16 CONCLUDING MATERIAL CUSTODIANS: PREPARING ACTIVITY: NAVY - YD2 NAVY - YD2 ARMY - CE AF - 50 PROJECT NUMBER: FACR-1179 236 STANDARDIZATION DOCUMENT IMPROVEMENT PROPOSAL INSTRUCTIONS The preparing activity must complete blocks 1, 2, 3, and In block 1, both the document number and revision letter should be given The submitter of this form must complete blocks 4, 5, 6, and The preparing activity must provide a reply within 30 days from receipt of the form NOTE: This form may not be used to request copies of documents, nor to request waivers, or clarification of requirements on current contracts Comments submitted on this form not constitute or imply authorization to waive any portion of the referenced document(s) or to amend contractual requirements DOCUMENT NUMBER I RECOMMEND A CHANGE: DOCUMENT DATE (YYMMDD) MIL-HDBK-1005/16 971031 DOCUMENT TITLE WASTEWATER TREATMENT SYSTEM DESIGN AUGMENTING HANDBOOK NATURE OF CHANGE (identify paragraph number and include proposed rewrite, if possible Attach extra sheets as needed.) REASON FOR RECOMMENDATION SUBMITTER a NAME (Last, First, Middle Initial) b ORGANIZATION c ADDRESS (Include Zip Code) d TELEPHONE (Include Area Code) DATE SUBMITTED: (YYMMDD) (1) Commercial (2) DSN (If applicable) PREPARING ACTIVITY a NAME b TELEPHONE (Include Area Code) (1) Commercial c ADDRESS (Include Zip Code) DD Form 1426, OCT 89 (2) DSN IF YOU DO NOT RECEIVE A REPLY WITHIN 45 DAYS, CONTACT: Defense Quality and Standardization Office 5203 Leesburg Pike, Suite 1403, Falls Church, VA 22041-3466 Telephone (703) 756-2340 DSN 289-2340 Previous editions are 198/290 obsolete ... initial selection and design of treatment processes MIL-HDBK-1005/16 2.3.5 Wastewater Reuse Two general categories of wastewater management exist: wastewater disposal and wastewater reuse Several... USACE-CEMP Military-adopted commercial wastewater treatment system guidance (Primary Design Guidance Document), published by WEF: Design of Municipal Wastewater Treatment Plants (Manual of Practice... Variations 36 Wastewater Loadings 40 Domestic Wastes 40 Industrial Wastes 40 Ship Sewage 40 Effect of Wastewaters with High Seawater Content 41 NAVY WASTEWATER COLLECTION