Tài liệu hạn chế xem trước, để xem đầy đủ mời bạn chọn Tải xuống
1
/ 116 trang
THÔNG TIN TÀI LIỆU
Cấu trúc
Table of Contents
GENERAL
Doors Level 2 (2)
SYSTEM OVERVIEW
PASSENGER DOORS
EMERGENCY EXITS
CARGO DOORS
AVIONICS COMPARTMENT DOORS
COCKPIT DOOR
SERVICING
DOOR BOTTLE SERVICING
MAINTENANCE TIPS
DOOR SAFETY PIN
EMERGENCY EXIT DOOR DEACTIVATION
EMERGENCY COCKPIT DOOR ACCESS
PASSENGER DOORS
Operation from Inside (2)
NORMAL OPENING
NORMAL CLOSING
Operation from Outside (2)
WARNING
OPENING
CLOSING
Emergency Operation (2)
EMERGENCY OPENING
Slide Arming Mechanical Operation (2)
ARMING
DISARMING
Damper/Emergency Cylinder Description (3)
GENERAL
DOOR DAMPER FUNCTION
EMERGENCY FUNCTION
CYLINDER DEACTIVATION
CYLINDER ACTIVATION
SERVICING
EMERGENCY EXITS (A318/A319/A320)
Doors Operation (2)
OPERATION
Doors Opening for Maintenance (2)
WARNING
OPENING FOR MAINTENANCE
EMERGENCY EXITS (A321)
Doors Operation (2)
DESCRIPTION/OPERATION
CARGO DOORS
Normal Operation (2)
NORMAL DOOR OPENING
NORMAL DOOR CLOSING
Manual Operation (2)
MANUAL DOOR OPENING
MANUAL DOOR CLOSING
Bulk Cargo Door Operation (2)
BULK CARGO DOOR OPERATION
COCKPIT DOOR
Cockpit Door Surveillance System D/O (3)
GENERAL
DESCRIPTION
DOOR
CDLS
DOOR OPENING
CABIN TO COCKPIT
CABIN TO COCKPIT (EMERGENCY)
BACK-UP SYSTEM (OPTIONAL)
COCKPIT TO CABIN
COCKPIT TO CABIN (EMERGENCY)
WARNING/INDICATING
Doors Indication & Warning D/O (3)
PASSENGER DOORS
DOOR INDICATING AND WARNING - PRINCIPLE
DOOR INDICATING AND WARNING - LOCKED
DOOR INDICATING AND WARNING - NOT LOCKED
ESCAPE SLIDE INDICATING AND WARNING - PRINCIPLE
ESCAPE SLIDE INDICATING AND WARNING - SLIDE ARMED, DOOR LOCKED
ESCAPE SLIDE INDICATING AND WARNING - SLIDE ARMED, DOOR NOT LOCKED
ESCAPE SLIDE INDICATING AND WARNING - SLIDE DISARMED, DOOR LOCKED
ESCAPE SLIDE INDICATING AND WARNING - SLIDE DISARMED, DOOR NOT LOCKED
RESIDUAL CABIN PRESSURE
EMERGENCY EXIT DOORS
DOOR INDICATING AND WARNING - PRINCIPLE
DOOR INDICATING AND WARNING - LOCKED
DOOR INDICATING AND WARNING - NOT LOCKED
ESCAPE SLIDE INDICATING AND WARNING - PRINCIPLE
ESCAPE SLIDE INDICATING AND WARNING - SLIDE ARMED, DOOR LOCKED
ESCAPE SLIDE INDICATING AND WARNING - SLIDE ARMED, DOOR NOT LOCKED
ESCAPE SLIDE INDICATING AND WARNING - SLIDE DISARMED, DOOR LOCKED
ESCAPE SLIDE INDICATING AND WARNING - SLIDE DISARMED, DOOR NOT LOCKED
FWD & AFT CARGO DOORS
DOOR INDICATING AND WARNING - PRINCIPLE
DOOR INDICATING AND WARNING - LOCKED
DOOR INDICATING AND WARNING - NOT LOCKED
DOOR INDICATING AND WARNING - FULLY OPEN
ELECTRICAL CONTROL SYSTEM - ENABLE LOGIC
ELECTRICAL CONTROL SYSTEM - CONTROL
AVIONICS, BULK CARGO & AIRSTAIRS DOORS
DOOR INDICATING AND WARNING - PRINCIPLE
DOOR INDICATING AND WARNING - LOCKED
DOOR INDICATING AND WARNING - NOT LOCKED
CIDS WARNINGS
FAP DOOR PAGE
Nội dung
SINGLE AISLE TECHNICAL TRAINING MANUAL MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) DOORS This document must be used for training purposes only Under no circumstances should this document be used as a reference It will not be updated. All rights reserved No part of this manual may be reproduced in any form, by photostat, microfilm, retrieval system, or any other means, without the prior written permission of AIRBUS S.A.S. DOORS GENERAL Doors Level 2 (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 PASSENGER DOORS Operation from Inside (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Operation from Outside (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 Emergency Operation (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 Slide Arming Mechanical Operation (2) . . . . . . . . . . . . . . . . . . . . . . 28 Damper/Emergency Cylinder Description (3) . . . . . . . . . . . . . . . . . . 30 EMERGENCY EXITS (A318/A319/A320) Doors Operation (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 Doors Opening for Maintenance (2) . . . . . . . . . . . . . . . . . . . . . . . . . . 42 EMERGENCY EXITS (A321) Doors Operation (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46 CARGO DOORS Normal Operation (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 Manual Operation (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 Bulk Cargo Door Operation (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58 COCKPIT DOOR Cockpit Door Surveillance System D/O (3) . . . . . . . . . . . . . . . . . . . . 62 WARNING/INDICATING Doors Indication & Warning D/O (3) . . . . . . . . . . . . . . . . . . . . . . . . . 76 MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS TABLE OF CONTENTS May 11, 2006 Page 1 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 DOORS LEVEL 2 (2) SYSTEM OVERVIEW The different doors of the single aisle family are: - Passenger doors, - Emergency exits, - Cargo doors, - Avionics compartment doors, - Cockpit door. PASSENGER DOORS The single aisle family is equipped with two forward and two aft passenger doors. These are plug-type doors that open upward, outward and forward parallel to the fuselage. The doors can be operated from the inside or the outside the aircraft. Normal operation of the doors is manual, with hydraulic damping. Each door is equipped with an emergency opening system: - An escape slide stowed in a container attached to the lower side of the door, - A door damping and emergency operation cylinder that assists normal door operation and acts as an actuator for automatic door opening in an emergency, - a slide ARMING/DISARMING lever. When the slide-arming lever is in the ARMED position, the slide is connected to the floor. When the door is opened, the escape slide inflates and deploys automatically. Opening the door from the outside disarms the door and the escape slide. MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 2 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 SYSTEM OVERVIEW - PASSENGER DOORS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 3 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 DOORS LEVEL 2 (2) SYSTEM OVERVIEW (continued) EMERGENCY EXITS The A318 and A319 are equipped with two overwing emergency exits (one on each side). The A320 is equipped with four overwing emergency exits (two on each side). The A321 is equipped with four emergency exit doors (two on each side) located forward and aft of the wing. On the A318, A319, and A320 aircraft, for emergency evacuation, the exit can be opened from inside or outside the cabin to activate the evacuation system. Normally these emergency exits are always armed. To open the exit for maintenance, authorized personnel must disarm it from the inside. The A321 emergency exit door can be opened from inside or outside. These exits must be armed in flight and disarmed on the ground. MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 4 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 SYSTEM OVERVIEW - EMERGENCY EXITS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 5 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 DOORS LEVEL 2 (2) SYSTEM OVERVIEW (continued) CARGO DOORS The cargo compartment doors, installed on the lower right hand side of the fuselage, give access to the forward and aft cargo compartments. They open outwards and upwards from the fuselage. They are manually locked and unlocked by a locking handle on the door. The forward and aft cargo doors are operated hydraulically using the yellow system electric pump. In case of electrical failure the door can be opened manually using a hand pump. The bulk cargo door is installed aft of the aft cargo door on the A320 and A321. The bulk door gives access to the bulk cargo compartment. The door is operated manually and opens into the compartment. MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 6 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 [...]... can now be opened MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 18 U3U06191 - U0O35M0 - UM52BA000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL MAINTENANCE TIPS - EMERGENCY COCKPIT DOOR ACCESS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 19 SINGLE AISLE TECHNICAL TRAINING MANUAL OPERATION... integrated maintenance annunciators, - Buzzer on cockpit overhead panel MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 10 U3U06191 - U0O35M0 - UM52BA000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL SYSTEM OVERVIEW - COCKPIT DOOR MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 11 SINGLE AISLE TECHNICAL. .. bay These doors are manually operated and open inward The locking mechanism is identical on each door MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 8 U3U06191 - U0O35M0 - UM52BA000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL SYSTEM OVERVIEW - AVIONICS COMPARTMENT DOORS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL... the correct locking MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS OPERATION FROM INSIDE (2) May 10, 2006 Page 20 U3U06191 - U0O35M0 - UM52D2000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL NORMAL OPENING & NORMAL CLOSING MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS OPERATION FROM INSIDE (2) May 10, 2006 Page 21 SINGLE AISLE TECHNICAL TRAINING MANUAL OPERATION FROM... safety precautions must be taken MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS OPERATION FROM OUTSIDE (2) May 10, 2006 Page 22 U3U06191 - U0O35M0 - UM52D3000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL WARNING MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS OPERATION FROM OUTSIDE (2) May 10, 2006 Page 23 SINGLE AISLE TECHNICAL TRAINING MANUAL OPERATION FROM OUTSIDE... flush with the fuselage MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS OPERATION FROM OUTSIDE (2) May 10, 2006 Page 24 U3U06191 - U0O35M0 - UM52D3000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL OPENING & CLOSING MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS OPERATION FROM OUTSIDE (2) May 10, 2006 Page 25 SINGLE AISLE TECHNICAL TRAINING MANUAL EMERGENCY OPERATION... is safe for the evacuation MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS EMERGENCY OPERATION (2) May 10, 2006 Page 26 U3U06191 - U0O35M0 - UM52D4000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL EMERGENCY OPENING MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS EMERGENCY OPERATION (2) May 10, 2006 Page 27 SINGLE AISLE TECHNICAL TRAINING MANUAL SLIDE ARMING MECHANICAL... arming lever MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS SLIDE ARMING MECHANICAL OPERATION (2) May 10, 2006 Page 28 U3U06191 - U0O35M0 - UM52D5000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL ARMING & DISARMING MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS SLIDE ARMING MECHANICAL OPERATION (2) May 10, 2006 Page 29 SINGLE AISLE TECHNICAL TRAINING MANUAL DAMPER/EMERGENCY... closing sequences MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DAMPER/EMERGENCY CYLINDER DESCRIPTION (3) May 10, 2006 Page 30 U3U06191 - U0O35M0 - UM52D9000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL GENERAL MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DAMPER/EMERGENCY CYLINDER DESCRIPTION (3) May 10, 2006 Page 31 SINGLE AISLE TECHNICAL TRAINING MANUAL DAMPER/EMERGENCY... deactivated for maintenance This allows the door to be opened in the ARMED configuration without discharging the cylinder MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 14 U3U06191 - U0O35M0 - UM52BA000000001 SINGLE AISLE TECHNICAL TRAINING MANUAL SERVICING & MAINTENANCE TIPS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ME) 52 - DOORS DOORS LEVEL . OVERVIEW - PASSENGER DOORS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 3 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 DOORS. OVERVIEW - CARGO DOORS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 7 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 DOORS. OVERVIEW - EMERGENCY EXITS MAINTENANCE COURSE - M35 LINE MECHANICS (V2500-A5/ ME) 52 - DOORS DOORS LEVEL 2 (2) May 10, 2006 Page 5 SINGLE AISLE TECHNICAL TRAINING MANUAL U3U06191 - U0O35M0 - UM52BA000000001 DOORS