Beer Processing Solutions doc

[...]... may be adjusted by means of an optional sound velocity/alcohol sensor, which measures the original extract of the beer and applies appropriate corrections This technique can also be used for blending beer types or diluted beer from filtration 16 FINAL BEER DEAERATED WATER FT FT DT GT HGB BEER Options • Original Extract Measurement Completed through the means of a sound velocity sensor This measures... pre- and post-run diluted beer • Carbonation – Correction of the CO2 contents of the final beer to specification This is normally a single point but pre-carbonation of the water can be supplied if desired The integrated unit is simpler, more compact and cheaper to GLYCOL GLYCOL WATER CO2 CO2/N2 HGB BEER • Fully CIP-cleanable HGB Master 20 FINAL BEER PU Pasteurizer – Controlled Beer Pasteurization If you... specialists to help them to meet the requirements for specific beer types The result is a complete and well-documented process line designed to maintain the characteristics of the beer and to meet consumer expectations for high quality It is important to control the different phases of the filtration process and integrate them into the rest of the beer processing line, ensuring that the required production... Derox – Cold and Hot Water Deaeration Improve your beer quality with the Derox Deaerator Deaerated water is used in the brewing industry to minimize damage to beer through oxidation It is used as a medium for purging mains and equipment and post fermentation as part of the brewing process The Derox product range covers units designed for deaeration of processing water Derox is used where a low O2 content... In the event of a downstream shutdown, water replaces the beer in the system to maintain the balance The temperature is controlled by means of hot water circulation With a beer pasteurizer, the dissolved gas must be retained in solution throughout the process by the appropriate system pressures The design system pressure can be set for each beer type to minimize energy requirements The unit is based... be integrated WATER I GLYCOL the pasteurizer is pushed out to drain or to a collection tank with fresh beer, and normal operation resumes R P CONDENSATE STEAM WATER/CIP BEER pupast.dwg CIP Master Go for perfect cleaning results at lower cost with the APV CIP Master The production of high quality beer using highly efficient operating techniques requires effective, careful cleaning of equipment APV offers... standard system is engineered to cope with levels of CO2 normally specified in beer Carbonation of up to 10g/kg CO2 may be obtained if required • CO2 contents to be automatically monitored and adjusted CO2 Measurement - An in-line CO2 analyzer can be installed together with a regulating valve to allow the BEER CARBONATED BEER 18 HGB Master – High Gravity Brewing The HGB Master is the result of a compact... is used together with a magnetic flow meter to regulate the flow and thus the holding time The beer enters a buffer tank equipped with a load cell to measure the contents In the event of a downstream shutdown, the pasteurizer continues operation until a pre-determined maximum level is reached The remaining beer in the system is flushed into the buffer tank with water, which is then recirculated to maintain... product range covers units designed for deaeration of processing water Derox is used where a low O2 content is required or recommended, for example for the lauter tun, blending of bright beer and in High Gravity Brewing (HGB) processing Deaeration can be performed by two different systems - cold (Derox) or hot (Derox+) deaeration The hot system heats the water to high temperature, which reduces the risk... brewing water after fermentation instead of within the brewhouse Even when HGB is not a standard procedure, cutting the final beer with small amounts of water to achieve a consistent product is often required Magnetic flow meters are used to measure the volumes of high gravity beer and deaerated water Dosing takes place by means of a simple ratio control operating a modulating valve on the water supply . h0" alt="" Beer Processing Solutions Table of contents Introduction 3 Brewing Process Diagram 4 Complete Product Range 5 Complete Process Solutions 6-7 Automation. everything from a single process line to complete greenfield turnkey beer processing solutions. To meet today’s demand for modern, highly efficient production