Root Cause Failure Analysis Part 2 ppt
Root Cause Failure Analysis Part 2 ppt
... potential root causes to verify each of the suspect causes is essential. In almost all cases, a relatively simple, inexpensive test series can be devel- Root Cause Failure Analysis Methodology ... tests can measure the real effect of each variable. Root Cause Failure Analysis Methodology 23 No matter what the event is (i.e., equipment failure, environmental relea...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 3 pptx
... selected with care. 77 56 Root Cause Failure Analysis Causes and Long-Term Corrective Actions This section of the report should clearly describe the specific root cause( s) that hig- gered ... fluorochloroethy lene 7664-41-7 7 726 -95-6 77 82- 50-5 75 -21 -8 7647-01 -0 7783-06-4 75-3 1-0 463-51-4 74-89-5 74-87-3 624 -83-9 7697-37 -2 594- 42- 3 7616-94-6 79...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 1 ppsx
... increased difficulty is that the cause often is subjective. ROOT CAUSE FAILURE ANALYSIS Part I INTRODUCTION TO ROOT CAUSE FAILURE ANALYSIS ROOT CAUSE FAILURE ANALYSIS R. Keith Mobley ... that leads to failure. Instead, it displays all the possible causes that CONTENTS Part I Introduction to Root Cause Failure Analysis Chapter 1 Introduction...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 5 pdf
... the design conditions generally are used. 120 Root Cause Failure Aniysis Table 9-6 Allowance Factor H (he) I 1 -2 2- 4 4-5 5 G 2 1.5 1 .25 1.1 1 .o Source: Theodore Baumeister, ... Handbook for Mechanical Engineers, 8th ed. (New York: McCraw-Hill, 1978). 122 Root Cause Failure Analysis In addition, the product-feed system must prevent entrainment o...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 6 pot
... 148 Root Cause Failure Analysis Figure 11-1 Top-entering propeller-type mixer (Thomas Register 1995). Figure 11 -2 Side-entering propeller-type mixer (Thomas Register 1995). 168 Root Cause ... prevent stress failure. Smaller- diameter rolls can be reduced in a single step, but they also must have stress relief by undercutting to prevent failure. 144 Root Cause...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 7 potx
... drive. This factor compensates for the variation in speed, or slip, caused by load changes. 194 1 72 Root Cause Failure Analysis Table 161 Gear Characteristics Overview Gear Type Characteristics ... quietness, and smoothness of operation, which results Figure 14 -2 Example of an internal spur gear (Neale 1993). 186 Root Cause Failure Analysis and the parallel r...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 8 pot
... 22 8 Root Cause Failure Analysis Figure 18-10 Proper lantern ring installation (Bearings Inc. catalogue). 23 . 24 . 25 . 26 . 27 . 28 . 29 . Tighten up the gland ... ~ P T P T 2- Position Valve w P T P T P 1 21 5 3-Position Valve Figure 17-14 Schematic of two-position and three-position valves. 22 4 Root Cause Failure Analysis Precauti...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 9 pdf
... flow. 23 9 25 2 Root Cause Failure Analysis Table 21 -1 Common Failure Modes of Pneumatic Conveyors I THE CAUSES Piping Configuratkn Unsuitable IPiping Leakage4 24 0 Root Cause ... liquid. 26 0 Root Cause Failure Analysis Table 22 -3d Common Failure Modes of Reciprocating, Positive-Displacement Compressors THE PROBLEM I THE CAUSES Table 22...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 10 pdf
... 28 8 Mixers and Agitators 26 5 Table 23 -1 Common Failure Modes of Mixers and Agitators Source: Integrated Systems, Inc. 28 6 Root Cause Failure Analysis Table 31-1 Common Failure ... prob- lems. Table 3 1 -2 provides troubleshooting guidelines for this common machine-train component. 28 5 27 2 Root Cause Failure Analysis Table 26 1 Common Fa...
Ngày tải lên: 11/08/2014, 21:23
Root Cause Failure Analysis Part 11 ppsx
... fans. 1 02 Mechanical seals, 22 0 ,22 8. 23 4, 28 2 Miter gears, I8 I Mixers, 147, 26 4 Natural frequency, 1 02 Net positive suction head. 80 NPSH. 80 Observations, 27 One-way valves, 2 I I ... Packing, 22 0 .23 4 ,28 2 Perceived causes, 29 Performed work. 25 Personal problems, 60 Physical evidence, 3 Physical impairment. 60 Plate-out in fans, 24 6 Pneumatic...
Ngày tải lên: 11/08/2014, 21:23