Đang tải... (xem toàn văn)
Tài liệu học tập cơ bản khái quát về động cơ và các bộ phận trên ô tô phiên bản tiếng anh. Tài liệu này nhằm giúp chúng ta tiếp cận được cấu tạo chức năng của các bộ phận của xe. Với tài liệu này giúp các bạn sinh viên ngành cơ khí ô tô tiếp cận được những kiến thức cơ bản về ô tô và đồng thời nâng cao kiến thức tiếng anh. Bộ tài liệu này được soạn thảo bởi trường đào tạo và huấn luyện nghề ở Canada.
Chapter Diagnostic Equipment and Special Tools Engine Compression Tester • Compression gauges are used to check cylinder compression pressures Cylinder Leak Tester • Used if a compression gauge indicates low compression • Cylinder leak testers apply air to cylinder to locate the leak Oil Pressure Gauge • Oil pressure can provide information about the internal condition of an engine Stethoscope • Used to pinpoint engine and other noises • Can be electronic Engine/Transaxle Support • Used when removing an engine or transaxle from a FWD vehicle Valve Spring Compressor • Used to safely compress the valve spring for removal and installation • Some can be used on-vehicle Torque Angle Gauge • Many torque specification are in both force (ft lbs or NM) and in torque angle • Provides more accurate torque Cooling System Pressure Tester • Used to apply pressure to the cooling system to inspect for leaks Coolant Hydrometer • Used to determine the protection factor provided by the coolant Chassis Dynamometer • Often called a “dyno,” used to simulate a road test in the shop • Used for I/M 240 emission tests Hybrid Vehicle Tools • Hybrid vehicles require special tools and procedures to be serviced safely • HEV batteries can supply 300 to over 500 volts High-Voltage Gloves • High-voltage gloves should be covered with heavy leather gloves • High-voltage gloves should be inspected and certified Clutch Tools • Alignment tools align the pressure plate, disc, and flywheel • Pilot bearing pullers remove the clutch pilot bearing Tire Equipment • Tire dismounting and mounting equipment • Tire balancing equipment Suspension System Tools • Tie-rod and ball joint tools separate ball socket joints Coil Spring Compressors • Coil springs store a large amount of energy • Spring compressors allow for safe removal and installation Brake System Tools • Trap and control asbestos dust • Used to properly and safely remove brake springs • Retract rear caliper parking brake pistons • Hydraulic system bleeding • Measure brake drum and rotor size • Recondition drums and rotor Asbestos Containment Drum Brake Tools Brake Hydraulic System Tools Brake Measurement Drum and Rotor Refinishing Heating and Air Conditioning Tools • Manifold gauge sets are used to test A/C system pressures and perform A/C service A/C Service Station • Reclaims, recycles, and recharges the air conditioning system ... drum and rotor size • Recondition drums and rotor Asbestos Containment Drum Brake Tools Brake Hydraulic System Tools Brake Measurement Drum and Rotor Refinishing Heating and Air Conditioning Tools. .. inspected and certified Clutch Tools • Alignment tools align the pressure plate, disc, and flywheel • Pilot bearing pullers remove the clutch pilot bearing Tire Equipment • Tire dismounting and mounting... a digital scope Lab Scope Display Wire and Terminal Tools • Used to repair wiring and remove and install terminals Generic Scan Tools • Generic scan tools can communicate with a wide variety