Automobile training 33 lighting

Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting Automobile training 33 lighting

LI–1 LIGHTING – LIGHTING SYSTEM LIGHTING SYSTEM BODY ELECTRICAL LIGHTING PARTS LOCATION HATCHBACK: PARK / NEUTRAL POSITION SWITCH *2 LI ENGINE ROOM R/B NO - H-LP/ AMT RELAY BACK-UP LIGHT SWITCH *1 HEADLIGHT ASSEMBLY RH HEADLIGHT ASSEMBLY LH FRONT FOG LIGHT ASSEMBLY RH ENGINE ROOM R/B FRONT FOG LIGHT ASSEMBLY LH - H-LP MAIN FUSE - H-LP LH/ H-LP LO LH FUSE - H-LP RH/ H-LP LO RH FUSE - DOME FUSE *1: M/T *2: A/T - HAZ FUSE - ECU-B FUSE B125736E02 LI–2 LIGHTING – LIGHTING SYSTEM SEDAN: ENGINE ROOM R/B HEADLIGHT ASSEMBLY LH - H-LP MAIN FUSE LI ENGINE ROOM R/B NO - H-LP LH/ H-LP LO LH FUSE - H-LP/ AMT RELAY*3 - H-LP RH/ H-LP LO RH FUSE - DOME FUSE HEADLIGHT ASSEMBLY RH - HAZ FUSE - ECU-B FUSE FRONT FOG LIGHT ASSEMBLY RH BACK-UP LIGHT SWITCH*2 PARK / NEUTRAL POSITION SWITCH*1 FRONT FOG LIGHT ASSEMBLY LH *1: A/T *2: M/T *3: W/ DAYTIME RUNNING LIGHT SYSTEM B142264E01 LI–3 LIGHTING – LIGHTING SYSTEM HATCHBACK: FRONT DOOR COURTESY SWITCH RH MAP LIGHT ASSEMBLY ROOM LIGHT ASSEMBLY REAR DOOR COURTESY SWITCH RH LI SIDE TURN SIGNAL LIGHT ASSEMBLY RH REAR DOOR COURTESY SWITCH LH FRONT DOOR COURTESY SWITCH LH SIDE TURN SIGNAL LIGHT ASSEMBLY LH B125737E04 LI–4 LIGHTING – LIGHTING SYSTEM SEDAN: ROOM LIGHT ASSEMBLY LUGGAGE COMPARTMENT ROOM LIGHT REAR DOOR COURTESY SWITCH RH MAP LIGHT ASSEMBLY LI FRONT DOOR COURTESY SWITCH RH FRONT DOOR COURTESY SWITCH LH REAR DOOR COURTESY SWITCH LH B142265E01 LI–5 LIGHTING – LIGHTING SYSTEM HATCHBACK: HEADLIGHT DIMMER SWITCH HAZARD WARNING SIGNAL SWITCH RUNNING LIGHT RELAY ASSEMBLY* STOP LIGHT SWITCH LI FRONT FOG LIGHT RELAY MAIN BODY ECU DLC3 (INSTRUMENT PANEL J/B) - T-LP RELAY - STOP FUSE - TAIL FUSE - PANEL1 FUSE PARKING BRAKE SWITCH - FRONT FOG FUSE - ECU-IG FUSE - GAUGE FUSE *: W/ DAYTIME RUNNING LIGHT SYSTEM - FLASH RELAY B125739E02 LI–6 LIGHTING – LIGHTING SYSTEM SEDAN: FRONT FOG LIGHT RELAY HEADLIGHT DIMMER SWITCH HAZARD WARNING SWITCH LI RUNNING LIGHT RELAY DLC3 MAIN BODY ECU (INSTRUMENT PANEL J/B) STOP LIGHT SWITCH - STOP FUSE - PANEL1 FUSE - FR FOG FUSE PARKING BRAKE SWITCH - MET FUSE - GAUGE FUSE - TAIL FUSE - FLASH RELAY - T-LP RELAY B142266E01 LI–7 LIGHTING – LIGHTING SYSTEM HATCHBACK: HIGH MOUNTED STOP LIGHT ASSEMBLY BACK DOOR LOCK ASSEMBLY - BACK DOOR COURTESY SWITCH LI LUGGAGE COMPARTMENT ROOM LIGHT REAR COMBINATION LIGHT ASSEMBLY RH REAR COMBINATION LIGHT ASSEMBLY LH LICENSE PLATE LIGHT ASSEMBLY B142267E01 LI–8 LIGHTING – LIGHTING SYSTEM SEDAN: W/O REAR SPOILER: LICENSE PLATE LIGHT ASSEMBLY LH HIGH MOUNTED STOP LIGHT ASSEMBLY LICENSE PLATE LIGHT ASSEMBLY RH LI REAR COMBINATION LIGHT ASSEMBLY RH REAR COMBINATION LIGHT ASSEMBLY LH LUGGAGE COMPARTMENT DOOR LOCK ASSEMBLY - LUGGAGE COMPARTMENT DOOR COURTESY SWITCH W/ REAR SPOILER: HIGH MOUNTED STOP LIGHT ASSEMBLY B142268E01 LI–9 LIGHTING – LIGHTING SYSTEM SYSTEM DIAGRAM Front Fog Light Relay Front Fog Light Hazard Warning Signal Switch Turn Signal Flasher Relay LI Turn Signal Light Taillight T-LP Relay Illumination Parts License Plate Light Headlight Dimmer Switch Hatchback, Sedan (w/ Daytime running light system) H-LP/AMT Relay Headlight (Lo) Headlight (Hi) Sedan (w/o Daytime running light system) Headlight (Lo) Headlight (Hi) B144234E01 LI–10 LIGHTING – LIGHTING SYSTEM Hatchback: Back Door Courtesy Switch Luggage Compartment Room Light Room Light Assembly Map Light Assembly LI Front Door Courtesy Switch LH Front Door Courtesy Switch RH Main Body ECU Rear Door Courtesy Switch LH Rear Door Courtesy Switch RH Stop Light Stop Light Switch High Mounted Stop Light Assembly Back-up Light Park / Neutral Position Switch*1 Back-up Light Switch*2 *1: A/T *2: M/T E122896E05 LI–186 LIGHTING – REAR DOOR COURTESY SWITCH E113844 LI INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP (a) Install the rear door opening trim weatherstrip CONNECT CABLE TO NEGATIVE BATTERY TERMINAL Torque: 5.4 N*m (55 kgf*cm, 48 in.*lbf) LIGHTING – BACK DOOR COURTESY SWITCH (for Sedan) LI–187 BACK DOOR COURTESY SWITCH (for Sedan) BODY ELECTRICAL LIGHTING COMPONENTS LI 7.5 (76, 66 in.*lbf) LUGGAGE COMPARTMENT DOOR LOCK ASSEMBLY N*m (kgf*cm, ft*lbf) : Specified torque E129676E01 LI–188 LIGHTING – BACK DOOR COURTESY SWITCH (for Sedan) REMOVAL DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL REMOVE LUGGAGE COMPARTMENT DOOR LOCK ASSEMBLY (a) Remove the snap ring in the direction indicated by the arrow and remove the luggage compartment door lock link E127146 LI (b) Disconnect the connector (c) Disengage the claw and pull up the protector lid in the direction indicated by the arrow E129672 (d) Remove the luggage door lock control cable (e) Remove the bolts and the luggage compartment door lock assembly E129673 LIGHTING – BACK DOOR COURTESY SWITCH (for Sedan) LI–189 INSPECTION LOCK: UNLOCK: INSPECT LUGGAGE COMPARTMENT DOOR LOCK ASSEMBLY (a) Check the resistance of the back door courtesy switch (1) Using an ohmmeter, measure the resistance between the terminals when the latch is operated with a screwdriver Standard Resistance Tester Connection Condition Specified Condition 1-2 Unlocked Below Ω 1-2 Locked 10 kΩ or higher If the result is not as specified, replace the luggage compartment door lock assembly E129674E01 INSTALLATION INSTALL LUGGAGE COMPARTMENT DOOR LOCK ASSEMBLY (a) Install the luggage door lock control cable (b) Install the luggage compartment door lock assembly with the bolts Torque: 7.5 N*m (76 kgf*cm, 66 in.*lbf) E129673 (c) Connect the connector (d) Install the protector lid E129675 LI LI–190 LIGHTING – BACK DOOR COURTESY SWITCH (for Sedan) (e) Install the luggage compartment door lock link E127151 LI CONNECT CABLE TO NEGATIVE BATTERY TERMINAL Torque: 5.4 N*m (55 kgf*cm, 48 in.*lbf) LIGHTING – BACK DOOR COURTESY SWITCH (for Hatchback) LI–191 BACK DOOR COURTESY SWITCH (for Hatchback) BODY ELECTRICAL LIGHTING COMPONENTS BACK DOOR TRIM BOARD ASSEMBLY LI BACK DOOR LOCK ASSEMBLY (BACK DOOR COURTESY SWITCH) x3 7.5 (76, 66 in.*lbf) N*m (kgf*cm, ft*lbf) : Specified torque E117230E01 LI–192 LIGHTING – BACK DOOR COURTESY SWITCH (for Hatchback) REMOVAL LI DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL REMOVE BACK DOOR TRIM BOARD ASSEMBLY (See page ED-142) REMOVE BACK DOOR LOCK ASSEMBLY (a) Disconnect the connector and clamp (b) Remove the bolts and the back door lock E113846 INSPECTION Lock Latch Unlock INSPECT BACK DOOR LOCK ASSEMBLY (a) Check the resistance of the back door courtesy switch (1) Using an ohmmeter, measure the resistance between the terminals when the latch is operated with a screwdriver Standard Resistance Tester Connection Condition Specified Condition 1-2 Unlocked Below Ω 1-2 Locked 10 kΩ or higher If the result is not as specified, replace the back door lock E107946E01 INSTALLATION E113846 INSTALL BACK DOOR LOCK ASSEMBLY (a) Install the back door lock with the bolts Torque: 7.5 N*m (76 kgf*cm, 66 in.*lbf) (b) Connect the connector and clamp INSTALL BACK DOOR TRIM BOARD ASSEMBLY (See page ED-146) LIGHTING – BACK DOOR COURTESY SWITCH (for Hatchback) LI–193 CONNECT CABLE TO NEGATIVE BATTERY TERMINAL Torque: 5.4 N*m (55 kgf*cm, 48 in.*lbf) LI LI–194 LIGHTING – TURN SIGNAL FLASHER ASSEMBLY TURN SIGNAL FLASHER ASSEMBLY Main Body ECU Connector Front View: ON-VEHICLE INSPECTION INSPECT TURN SIGNAL FLASHER CIRCUIT (a) Check the power source circuit and ground circuit (1) Remove the turn signal flasher relay from the main body ECU (2) Measure the voltage and check the results in accordance with the value(s) in the table below Standard Voltage Tester Connection Condition Specified Condition - Body ground Ignition switch OFF 0V - Body ground Ignition switch ON 11 to 14 V - Body ground Always 11 to 14 V LI (3) Measure the resistance and check the result in accordance with the value(s) in the table below Standard Resistance Turn Signal Flasher Relay I042805E02 Tester Connection Condition Specified Condition - Body ground Always Below Ω (b) Check the output operation signal (1) Install the turn signal flasher relay onto the main body ECU Main Body ECU (Front Side) Wire Harness View: 4A27 4A28 (Rear Side) Wire Harness View: 4B31 4S13 4B14 4S16 4S11 4S12 4S17 I042806E02 LI–195 LIGHTING – TURN SIGNAL FLASHER ASSEMBLY (2) Measure the voltage and check the results in accordance with the values in the table below Standard Tester Connection Condition Specified Condition 4A-27 - Body ground Hazard warning switch OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4A-27 - Body ground Turn signal switch (left turn) OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4A-28 - Body ground Hazard warning switch OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4A-28 - Body ground Turn signal switch (right turn) OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4B-14 - Body ground Hazard warning switch OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4B-14 - Body ground Turn signal switch (left turn) OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4B-31 - Body ground Hazard warning switch OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4B-31 - Body ground Turn signal switch (right turn) OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4S-11 - Body ground Turn signal switch (left turn) OFF → ON 11 to 14 V → V 4S-12 - Body ground Turn signal switch (right turn) OFF → ON 11 to 14 V → V 4S-13 - Body ground Hazard warning switch OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4S-13 - Body ground Turn signal switch (left turn) OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4S-16 - Body ground Hazard warning switch OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4S-16 - Body ground Turn signal switch (right turn) OFF → ON V → 11 to 14 V (60 to 120 times per minute) 4S-17 - Body ground Hazard warning switch OFF → ON 11 to 14 V → V LI LI–196 LIGHTING – HEADLIGHT RELAY HEADLIGHT RELAY ON-VEHICLE INSPECTION Battery Ohmmeter LI E109076E01 INSPECT HEADLIGHT RELAY (a) Check the resistance (1) Using an ohmmeter, measure the resistance between the terminals Standard Resistance Tester Connection Specified Condition 3-5 10 kΩ or higher 3-5 Below Ω (Battery voltage applied to terminals and 2) If the result is not as specified, replace the headlight relay LIGHTING – FOG LIGHT RELAY (for Sedan) LI–197 FOG LIGHT RELAY (for Sedan) BODY ELECTRICAL LIGHTING COMPONENTS LI FOG LIGHT RELAY INSTRUMENT PANEL BOX E129677E01 LI–198 LIGHTING – FOG LIGHT RELAY (for Sedan) REMOVAL LI DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL REMOVE INSTRUMENT PANEL BOX (See page IP-45) REMOVE FOG LIGHT RELAY (a) Remove the fog light relay E129656 INSPECTION Battery INSPECT FOG LIGHT RELAY (a) Check the resistance (1) Using an ohmmeter, measure the resistance between the terminals Standard Resistance Tester Connection Specified Condition 3-5 10 kΩor higher 3-5 Below Ω (Battery voltage applied to terminals and 2) If the result is not as specified, replace the fog light relay Ohmmeter E109078E01 INSTALLATION E129656 INSTALL FOG LIGHT RELAY (a) Install the fog light relay INSTALL INSTRUMENT PANEL BOX (See page IP-53) CONNECT CABLE TO NEGATIVE BATTERY TERMINAL Torque: 5.4 N*m (55 kgf*cm, 48 in.*lbf) LIGHTING – FOG LIGHT RELAY (for Hatchback) LI–199 FOG LIGHT RELAY (for Hatchback) BODY ELECTRICAL LIGHTING COMPONENTS LI FOG LIGHT RELAY INSTRUMENT PANEL BOX E129699E01 LI–200 LIGHTING – FOG LIGHT RELAY (for Hatchback) REMOVAL LI DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL REMOVE INSTRUMENT PANEL BOX (See page IP-70) REMOVE FOG LIGHT RELAY (a) Remove the fog light relay E123168 INSPECTION Battery INSPECT FOG LIGHT RELAY (a) Check the resistance (1) Using an ohmmeter, measure the resistance between the terminals Standard Resistance Tester Connection Specified Condition 3-5 10 kΩor higher 3-5 Below Ω (Battery voltage applied to terminals and 2) If the result is not as specified, replace the fog light relay Ohmmeter E109078E01 INSTALLATION E123168 INSTALL FOG LIGHT RELAY (a) Install the fog light relay INSTALL INSTRUMENT PANEL BOX (See page IP-78) CONNECT CABLE TO NEGATIVE BATTERY TERMINAL Torque: 5.4 N*m (55 kgf*cm, 48 in.*lbf) ... LI–12 LIGHTING – LIGHTING SYSTEM w/ Daytime Running Light System: Parking Brake Switch Headlight Dimmer Switch LI Running Light Relay Headlight (Lo) Generator (Alternator) B144235E01 LIGHTING – LIGHTING. .. LI–19 LIGHTING – LIGHTING SYSTEM TERMINALS OF ECU CHECK MAIN BODY ECU Main Body ECU (Rear View): 4H 4D 4C 4A 4E LI 4D 4K 4A 4B 4C 4J 4H 4E 4J 4K 4B 4L 4L 4G 4F 4F 4G E114510E06 LI–20 LIGHTING – LIGHTING. .. following part • Headlight (Low) LI–15 LIGHTING – LIGHTING SYSTEM HOW TO PROCEED WITH TROUBLESHOOTING HINT: • Use these procedures to troubleshoot the lighting system • Use an intelligent tester