Tài liệu hướng dẫn sửa chữa Hộp số sàn trên xe Hilux 2015 2018 manual rc60f rc61f mt transmission hop so san. Cung cấp các thông tin cần thiết cho Kỹ thuật viên tiến hành chẩn đoán, sửa chữa nhanh chóng, chính xác, hiệu quả
Print-Toyota Service Information 11/3/17, 7'33 pm Print Exit RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE MANUAL TRANSMISSION ASSEMBLY COMPONENTS ILLUSTRATION *1 NO ENGINE UNDER COVER ASSEMBLY *2 N*m (kgf*cm, ft.*lbf): Specified torque - NO ENGINE UNDER COVER - https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ87.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'33 pm ILLUSTRATION *1 FLOOR SHIFT SHIFT LEVER ASSEMBLY *2 NO FLOOR SHIFT BUSH *3 *5 NO FRAME CROSSMEMBER SUB-ASSEMBLY PROPELLER SHAFT GUARD *4 *6 NO CYLINDER BROCK INSULATOR SHIFT LEVER BOOT ASSEMBLY *7 STIFFENER PLATE LH *8 STIFFENER PLATE RH *9 WIRE HARNESS - - Tightening torque for "Major areas involving https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ87.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'33 pm basic vehicle performance such as moving/turning/stopping": N*m (kgf*cm, ft.*lbf) MP grease N*m (kgf*cm, ft.*lbf): Specified torque - - ILLUSTRATION https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ87.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'33 pm *A w/ Intelligent Manual Transmission Switch *1 *3 MANUAL TRANSMISSION ASSEMBLY TRANSFER ASSEMBLY *2 *4 REAR ENGINE MOUNTING INSULATOR TRANSMISSION BREATHER SUB-ASSEMBLY *5 WIRING HARNESS CLAMP BRACKET *6 BRACKET Tightening torque for "Major areas involving basic vehicle performance such as moving/turning/stopping": N*m (kgf*cm, ft.*lbf) - - N*m (kgf*cm, ft.*lbf): Specified torque https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ87.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'33 pm © 2012 TOYOTA MOTOR CORPORATION All Rights Reserved https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ87.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'33 pm Print Exit RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE BACK-UP LIGHT SWITCH INSTALLATION PROCEDURE 1.INSTALL BACK-UP LIGHT SWITCH ASSEMBLY 84210 a Using SST, install a new gasket and the back-up light switch assembly to the transmission case SST 09817-16011 Torque: 44 N*m (449 kgf*cm, 32 ft.*lbf) b Attach the clamps c https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ86.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'33 pm Connect the connector 2.INSTALL SHIFT LEVER BOOT ASSEMBLY 58280A Click hereDrivetrain>RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE>MANUAL TRANSMISSION ASSEMBLY>INSTALLATION © 2012 TOYOTA MOTOR CORPORATION All Rights Reserved https://toyotamanuals.com.au/docs/hilux-service-repair-manual-…manual/repair/contents/RM100000000LZ86.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'32 pm Print Exit RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE BACK-UP LIGHT SWITCH INSPECTION PROCEDURE 1.INSPECT BACK-UP LIGHT SWITCH ASSEMBLY 84210 a *a Pushed *b Released Measure the resistance according to the value(s) in the table below Standard Resistance: Switch Condition Specified Condition Pushed Below Ω Released 10 kΩ or higher If the result is not as specified, replace the back-up light switch assembly © 2012 TOYOTA MOTOR CORPORATION All Rights Reserved https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ85.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'32 pm Print Exit RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE BACK-UP LIGHT SWITCH COMPONENTS ILLUSTRATION *1 BACK-UP LIGHT SWITCH ASSEMBLY N*m (kgf*cm, ft.*lbf): Specified torque *2 ● GASKET Non-reusable part © 2012 TOYOTA MOTOR CORPORATION All Rights Reserved https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ83.html?PUB_TYPE=RM&MODE=1 Page of Print-Toyota Service Information 11/3/17, 7'32 pm Print Exit RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE BACK-UP LIGHT SWITCH REMOVAL PROCEDURE 1.REMOVE SHIFT LEVER BOOT ASSEMBLY 58280A Click hereDrivetrain>RC60F / RC61F MANUAL TRANSMISSION / TRANSAXLE>MANUAL TRANSMISSION ASSEMBLY>REMOVAL 2.REMOVE BACK-UP LIGHT SWITCH ASSEMBLY 84210 a Disconnect the connector b Detach the clamps c Using SST, remove the back-up light switch assembly and gasket from the transmission case https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000LZ84.html?PUB_TYPE=RM&MODE=1 Page of