Bsi bs en 60598 2 4 1997

-, !." i! , i i " " BRITISH STANDARD BS EN ~ 60 98- -4 : 19 i Luminaires' Part Particular Section requirements 2.4 Portable general purpose luminaires" 'I i ! !! i, -~ ~ -~ ~ ~ ~ tn ~ "~ ! ! The European St2ndard EN 60598-2-4: 1997has the status of a British Standard , ,~ ~ !' I, i ICS 29.140.40 i 1; ,"! i ~""cO NO-~~~-~-COpnNG WITHOUTBSI PERMISSION EXCEPTAS PERMITTEDBY COPYRIGHrLAW =::::~~~~ -~ -, -"! BS E1~ 60598-24 : 1998 ~~~~~~~~" "",,,-~ =~~~~:;;: Nati,onal '- -, foreword , I This : British Standard identical with 1990 which The UK ~ LEC is English language 1997 It vexsion of supersedes BS EN 60598-2-4: 4533: Part 1997 102 : It Section is 102.4: witildrawn participation CPI./J4/4, tile 60598-24: in' Luminaires, its preparation which was has tl1e entrusted to responsibility Technical Committee to: , i II -aid enqujrern to -present to on the tile UIl;derstand tl1e responsible text; internationaJ/European intexpretation, or committee proposals for change, and any keep tile enquiries UK interests infonned; j i -monitor related them in international the and European developments and promulgate UK , I ! A II list of organizations represented on this committee can be obtained on request to its secretazy I From ~ JantlaIY number of II 1997, For time all instance, during tile publications LEC IEC change may publications 27-1 over contain have has been from one identifiers tile number renumbered numbering from botil 60000 as IEC added to 60027-1 system to For tile tile a old period otl1er, systems I! Cross-references Attention an is annex drawn fact or BSI and The publications under Index', CENELEC to publications Catalogue Con-espondence Electronic CEN references European Standarm that nonnative European international or by the ming tile Stan~ international British Stan~ refeITed to section entitled 'Find' normally include publications in with which ~ document may 'futernational facility of tile tl1eir j implement be found in Standarm BSI Standards Catalogue Compliance from tile lists con-esponding the to which with legal a British Standard does not of itself confer immunity obligations I I I, II : I i ,] " :1 II ' Summary This direction been British Sector under St4ndard, oftl1e prepared Board, tl1e ha'wing under EIectrotechnicaJ the was autltority of This document pages pages comprises to 8, an Amendments Amd a inside back issued No ~ and an a back inside front cover cover, tile EN title page, - publication Text affected published of 23010~ cover, sin~e Date the StandardsBoardand comesinto effect C>BSIon 1998 15May 1993 i.J:Bi-i front cover i I ~ ! L ' ~ , , ~ I II EUROPEAN ! STANDARD , EN 60598-2-4 NORME EUROPEENNE EUROPAISCHE NORM ;CS '9 14n 4nICS 29.140.40 Descriptors: Particular July 1997 Supersedes requirements portable luminaire EN 60598-2-4: 1989 and its amendment general purpose luminaire English version Luminaires Part 2: Particular requirements Section 4: Portable general purpose luminaires (IEC 60598-2-4: -(GEl ~ = luminaires Partie 2: Regles particulieres Section 4: luminaires portatifs a usage general 60598-2-4: 1997) 1997) leuchten Teil 2: Besondere Anforderungen Hauptabschnitt 4: Gewohnliche ortsveranderliche leuchten (lEG 60598-2-4: 1997) ~ ~ ~ ; This European Standard was approved by CENELECon 1997-07-01 CENELEC members are bound to II ! comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European Standard the status of a national standard without any alteration II Up-to-date lists and bibliographical references concerning such national standards may be obtained on application to the Central Secretariat or to any CENELECmember This European Standard exists in three official versions (English French, German) A version in any other language made by translation under the responsibility of a CENELEC member into its own language and notified to the Central Secretariat has the same status as the official versions CENELEC members are the national electrotechnical committees of Austria, Belgium Denmark, Finland France, Germany Greece, Iceland, Ireland, Italy Luxembourg, Netherlands, Norway, Portugal, Spain, Sweden, Switzerland and United Kingdom CENELEC European Committee for Electrotechnical Standardization Comite Europeen de Normalisation Electrotechnique Europaisches Komitee fur Elektrotechnische Normung Central Secretariat: C 1997 CENELEC -All rights of exploitation rue de Stassart 35, B-1 in any form and by any means reserved 050 Brussels worldwide for CENELEC members Ref No EN 60598.2-4:1997 I i I I E , Page EN 60598-2-4 : 1997 I Foreword The text of document 340/433/FOIS, future edition of IEC 60598-2-4, prepared by SC 340, Luminaires, of IEC TC 34, Lamps and' related equipment, was submitted to the IEC-CENELEC parallel vote and was approved by CENELEC as EN 60598-2-4 on 1997-07-01 This European Standard is to be used in conjunction with the latest edition of and all current amendments to EN 60598-1 Luminaires, Part 1: General requirements and tests This European Standard supersedes EN 60598-2-4: The following i :1 1989 and its amendment A3: 1993 dates were fixed: -latest date by which the EN has to be implemented at national level by publication of an identical national standard or by endorsement (dop) -latest date by which the national standards with the EN have to be withdrawn (dow) 998-04-01 998-04-01 conflicting ( For products which have complied with EN 60598-2-4:1989 and its amendment A3:1993 before 1998-04-01, as shown by the manufacturer or by a certification body, this previous standard may continue to apply for production until 2003-04-01 I r ! I ; I Annexes designated "normative" are part of the body of the standard In this standard, annex ZA is normative Annex ZA has been added by CENELEC Endorsementnotice The text of the International Standard IEC 60598-2-4: European Standard without any modification 1997 was approved by CENELEC as a (~ i , , , i I I ~ I ;i :.1 Ii i I Page EN 60598-2-4: 1997 II i CONTENTS Clause 4.1 Ii Page General : 4.1.1 Scope 4.1.2 Normative reference 4.2 General test requirements 4.3 Definitions 4.4 Classification of luminaires 4.5 Marking 4.6 Construction : : 5 i 4.7 Creepage distances and clearances 48 P f rth rOVISlon or ea Ing : 4.9 Terminals 4.10 External and internal wiring 4.12 Protection against electric shock Endurance tests and thermal tests 6 4.13 Resistance to dust and moisture ' i -4.11 ~ ~ ~ - = ~ -4.14 4.15 ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ Insulation resistance and electric strength Resistance to heat, fire an.d tracking Annex ZA -Normative reference to international publications with their corresponding European publications iI i ! @ BSI 1998 - ,.Page EN 60598-2-4 : 1997 l ,-.c LUMINAIRESPart 2: Particular requirements Section 4: Portable general purpose luminaires 4.1 General 4.1.1 Scope I' I This section of part pf lEG 60598 specifies requirements for portable general purpose luminaires, other than hand lamps, for use with tungsten filament, tubular fluorescent and other discharge lamps on supply voltages not exceeding 250 V It is to be read in conjunction with those sections of part°1 to which reference is made 4.1 Normative reference (- The following normative document contains provisions which, through reference in this text, constitute provisions of this section of lEG 60598-2 At the time of publication, the edition indicated was valid All normative documents are subject to revision, and parties to agreements based on this section of lEG 60598-2 are encouraged to investigate the possibility of applying the most recent edition of the normative document indicated below Members of lEG and ISO maintain registers of currently valid International Standards i i lEG 60529: 1989, Degrees of protection ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ provided I 4.2 General test requirements by enclosures (IP codes) The provisions of section of lEG 60598-1 apply The tests described in each section of Part shall be carried out in the order listed in this section of Part I 4.3 Definitions The definitions 4.3.1 of section Candlestick of lEG 60598-1 having NOTE -Candlestick luminaires Classification apply with the following addition: luminaires A portable luminaire free-standing frame 4.4 appropriate (series connected may incorporate lamps permanently mounted and separated on a E5 or E10 lampholderso of luminaires Luminaires shall be classified in accordance with the provision of section of lEG 60598-1 except that portable luminaires designed for standing on a floor or table shall be classified as suitable for direct mounting on normally flammable surfaces 4.5 Marking The provisions of section of lEG 60598-1 apply " I, 5tml; Page Ii ' EN 60598-2-4 : 1997 r 4.6 ! Construction The provisions of section of IEC 60598-1 apply, together with the requirements of 4.6.1 4.6.1 For portable luminaires, the insulation of flexible cables and cords shall be unlikely to be damaged when moving or adjusting the luminaire or when placing it on its support Compliance shall be checked by inspection 4.6.2 Wiring shall be fixed by means of wire carriers, clips or similar devices of insulating material, at all places where it might otherwise rub against metal parts in the normal movement of the luminaire if such rubbing will impair safety Compliance shall be checked by inspection 4.6.3 Portable luminaires shall have adequate stability Compliance shall be checked by placing the luminaire in the most unfavourable position of normal use on a plane inclined at an angle of 60 to the horizontal, the surface of the plane being such that the luminaire does not slide Any instructions supplied by the manufacturer with consideration in respect of the stability test The luminaire Luminaires -4.6.4 which are fastened Candlestick luminaires by clamps or similar shall be provided are not subjected due to this test ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ This switch shall, in candlestick =: -~ off simultaneously The switch shall be part of the luminaire 300 mm of the luminaire is checked receive with a switch .1 Compliance luminaires devices the luminaire shall shall not overturn with E5 or E10 lampholders, switch all lamps on and or if in the cord by inspection 4.7 is checked Creepage The provisions 4.8 Provision The provisions 4.9 by inspection distances and clearances of section 11 of lEG 60598-1 apply for earthing of section of IEC 60598-1 apply Terminals The provisions of sections I i 4.6.5 E5 lampholders shall be used only if the rated voltage does not exceed 25 V per lampholder and the rated voltage of E10 lampholders (60 V or 250 V respectively) shall be respected The maximum rated wattage of the luminaire shall not exceed 100 W Compliance I shall be within 14 and 15 of IEC 60598-1 apply Page EN60598-2-4:1997 4.10 External The provisions and Internal of section wiring of lEG 60598-1 apply except that: 1) the requirement whereby at least one part of the cord anchorage shall be fixed to or be integral with the luminaire does not apply to table lamps of glass or ceramic material; 2) for portable luminaires with a mass less than kg, a rated current not exceeding 2,5 A and provided with a flexible cable of length not greater than m, the cable shall have a nominal cross-sectional area~ of copper conductor not less than 0,5 mm2 ~ " ~-~ -~ 4.11 Protection The provisions 4.11.1 either against electric of section Portable Class shock of lEG 60598-1 I luminaires apply, together incorporating lampholders 1) be so designed that the lamp cap is not accessible luminaire is assembled as in normal use, or 2) be provided with a metal lampholder Endurance The provisions tests and thermal of section tests 12 of lEG 60598-1 for bayonet to the standard of 4.11.1 cap lamps shall test finger when the (' which is earthed Compliance shall be checked by inspection standard test finger shown in lEG 60529 4.12 with the requirements and, in addition, for Item 1) by a test with the ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ apply Luminaires with an IP classification greater than IP20 shall be subjected to the relevant tests of 12.4, 12.5 and 12.6 of section 12 of lEG 60598-1 after the test(s) of 9.2 but before the test(s) of 9.3 of section of lEG 60598-1 specified in 4.13 of this section of lEG 60598-2 Portable luminaires designed test as in normal use for standing on a floor, and pendants, are supported during Portable luminaires designed for standing on a table, and adjustable luminaires, are tested or above a dull black painted board similar to that described in annex D of lEG 60598-1 the on l In addition, for portable luminaires designed for standing on a floor or table which overturn when placed in their normal position of use on a plane inclined at an angle of 150 to the horizontal, the test of 12.5.1 of section 12 of lEG 60598-1 is made with the luminaire on a horizontal surface, in the most unfavourable of the overturned positions that may reasonably be expected in practice 4.13 Resistance The provisions to dust and moisture of section of lEG 60598-1 apply For luminaires with an IP classification greater than IP20, the order of the tests specified section of lEG 60598-1 shall be as specified in 4.12 of this section of lEG 60598-2 in -"' i" ",,\;, I Page I~ i I I EN 60598-2-4 V ; : 1997 II 4.14 Insulation The provisions 4.15 resistance of section Resistance The provisions and electric strength 10 of lEG 60598-1 apply to heat, fire and tracking of section 13 of lEG 60598-1 apply -~ - ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ ~~ = ~ ~ " ., '" "",' i~: Page I - EN 60598-2-4 : 1997 ' , ! I Annex ZA (normative) Normative references to international publications with their corresponding European publications This European Standard incorporates by dated or undated reference, provisions from other publications These normative references are cited at the appropriate places in the text and the publications are listed hereafter FOTdated references, subsequent amendments to or revisions of any of these publications apply to this European Standard only when incorporated in it by amendment or revision For undated references the latest edition of the publication referred to applies (including amendments) NOTE: When an international publication has been modified by common modifications, indicated by (modI, the relevant EN/HD applies I j i i : Publication Year Title IEC 60529 1989 Degrees of protection enclosures liP Code) pro,vided by EN/HD Year EN 60529 + corr May 1991 1993 ( "- ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ , C - : I i BSEN I 60598-2-4: ~ 1998 ===- BSI -British Standards Institution BSI ~ the independent natioruil body responsible for preparing British Standards It presents the UK view on standardsin Europe and at the international level It ~ incorporated by Royal Charter Contract requirements A British Standard does.not purport to include all the necessaryprovisions of a contract Users of British Standardsare responsible for their correct application Revisions British Standardsare updated by amendmentor revision.Users of British Standards should make sure that they possessthe latest amendmentsor editions I I ! i It ~ the constant aim of BSI to improve the quality of our products and services We would be grateful if anyone finding an inaccuracy or ambiguity while using this British Standard would infonn the Secretazyof the responsibletechnical committee, the identity of which can be found on the inside front cover Tel:0181996 9000;Fax: 0181 996 7400 BSI offers members an individual updating service called PLUS which ensures that subscribers automatically receivethe latest editions of standards ! i I ,I i ( Buying standards Orders for all BSI, internatioruil and foreign standards publications should be addr~ to CustomerServices,SalesDepartment at Chiswick Tel:0181 996 7000; Fax: 0181996 7001 In response to orders for intematioruil standards, it ~ BSI policy to supply the BSI ｗｗｗ．ｂｚｆｘｗ．ｃｏｍ implementation of those that have been published as British Standards, unless otherwise requested Information on standards I BSI provides a wide range of infonnation on natioruil, Europeanand international standardsthrough its Library,the StandardlineDatabase,the BSI Information TechnologyService (BITS) and its Technical Help to Exporters Service Contact the Information Department at Chiswick Tel: 01819967111;Fax: 01819967048 .AI Tel: Subscribing members of BSI are kept up to date with standardsdevelopmentsand receive substantial discounts on the purchaseprice of standards For details of these and other benefits contact CustomerServices,Membershipat Chiswick 0181996 7002;Fax: 01819967001 Copyright Copyright subsists in all BSI publications BSI also holds the copyrigh~ in the UK, of the publications of the internatioruil standardizationbodies Except as permitted under the Copyrigh~ Designsand PatentsAct 1988no extract may be reproduced, stored in a retrieval systemor traI1Smittedin any form or by any means -electronic, photocopying, recording or otherwise -without prior written pennission from BSI This does not preclude the free use, in the course of implementingthe standard, of necessarydetails such as symbols,and size, type or grade designations.If these details are to be used for any other purpose than implementationthen the prior written pennission of BSI must be obtained If peImission ~ granted,the tem1Smay include royalty paymentsor a licensing agreement.Details and advice can be obtained from the Copyright Manager,BSI, 389 Chiswick High Road, London W4 4AL I BSI 389 Chiswick High Road London W44AL , I (