Sơ đồ mạch điện đầu kéo International Truck CF500 CF600

Table of Contents 1-1 CF 500, CF 600 Circuit Diagrams Table of Contents 1-1 Introduction 3-1 Symbols 4-1 Connector Repair Procedures 5-1 Wiring Harness Overview 9-1 Grounds 10-1 Fuse and Relay Information 11-1 Charging System 12-1 Power Distribution 13-1 Module Communications Network 14-1 Starting System 20-1 Electronic Engine Controls 23-1 Transmission Controls 29-1 Speed Control 31-1 Vehicle Dynamic Systems 42-1 Horn/Cigar Lighter 44-1 Fuel Tank Selector 49-1 Manual Climate Control System 54-1 Instrument Cluster 60-1 Cluster and Panel Illumination 71-1 Front Wipers and Washers 81-1 Headlamps 85-1 Fog Lamps 86-1 Interior Lamps 89-1 Turn Signal/Stop/Hazard Lamps 90-1 Parking, Rear and License Lamps 92-1 Reversing Lamps 93-1 Trailer Adapter 95-1 Daytime Running Lamps 97-1 Power Windows 100-1 Power Door Locks 110-1 Remote Keyless Entry and Alarm 117-1 Audio System 130-1 Customer Access 140-1 Component Testing 149-1 Connector Views 150-1 Component Location Views 151-1 Component Location Charts 152-1 Vehicle Repair Location Charts 160-1 NOTE: The descriptions and specifications contained in this manual were in effect at the time this manual was approved for printing International Truck and Engine Corporation reserves the right to change specifications or design without notice and without incurring any obligation S08311 3-1 Introduction Note All wiring connections between components are shown exactly as they exist in the vehicles It is important to realize, however, that no attempt has been made on the schematic to represent components and wiring as they physically appear on the vehicle For example, a 4-foot length of wire is treated no differently in a schematic from one which is only a few inches long Furthermore, to aid in understanding electrical (electronic) operation, wiring inside complicated components has been simplified Central Junction Box (CJB) (14A067) 13−4 Hot in run F2.6 5A 31 C270a 1405 LB/BK See page 13−8 11 C220a Instrument cluster (10849) 1) Traction control 12 Complete Circuit Operation Each circuit is shown completely and independently in one cell Other components which are connected to the circuit may not be shown unless they influence the circuit operation 939 15 Current Flow (1) Each cell normally starts with the component that powers the circuit, such as a fuse or the ignition switch Current flow is shown from the power source at the top of the page to ground at the bottom of the page In order to concentrate on the essential parts, power supply and ground connections are sometimes simplified by a dashed line in the schematics A full representation of the power supply of a fuse or the power distribution from a fuse to various components is given in cell 13 “Power Distribution” Full representation of the ground connections are shown in cell 10 “Grounds” Switch Positions (2) Within the schematic, all switches, sensors and relays are shown “at rest” (as if the Ignition Switch were OFF) Splices (3) A dashed line indicates that the splice is not shown completely A reference is given to the page where the splice appears in full It is also listed in the Index 939 62−3 16 VT 603 27 VT 12) ABS 603 C220a Data Link Connector (DLC) (14489) DG C1019 DG S157 914 15 10 See page 14−3 TN/OG SCP + C251 See page 14−3 S156 915 11 PK/LB C135 ABS control module (2C219) 151−5 SCP − 530 LG/YE S200 530 LG/YE G104 Introduction Component Referencing (4) Each component on a schematic has a reference to the component location view or the page where it is shown completely It is located to the right of each component Component Names, Notes and Base Part Numbers (5) Component names are placed on the right hand side of each component Any notes that describe switch positions or operating conditions follow the name Descriptions of the internals of the component are also included here The page where the component appears in full is listed in the Index The base part number for a component is listed in parentheses next to or under a component These part numbers will appear any place the component name appears in the publication Internal Name and Function Identification Numbers (6) Some components on each page have internal symbols with an identification number located to the right You can identify the internal symbol or function by finding the corresponding number under the component name Circuit Function Identifiers (7) Some components without internal schematics use symbols or text to describe the function of a circuit in a system 3-2 3-3 Introduction Fuse and Relay Information Cell 11 “Fuse and Relay Information” contains a view of the fuse-/relay box in which all fuses and relays are identified Fuse and Relay Numbering and Naming F1.12 F1.1 F1.13 F1.2 F1.14 F1.3 F1.15 F1.4 F1.23 F1.24 Fuse and relay numbering and naming follow the indication of the fuse panel cover In addition, a prefix precedes the fuse number to facilitate finding the fuse in the Component Location Charts, e.g “F1.” precedes Power Distribution Center fuses, and “F2.” precedes Central Junction Box fuses Power Distribution S130 Battery Cell 13 “Power Distribution” shows the current feed circuit The current path is shown from the battery to the ignition switch and to all fuses It also shows the circuits protected by each fuse The circuit is traced from the fuse to the component All details (wires, splices, connectors) between the fuse and the first component are shown 57 Fusible Link A 1) 12 gauge 2) gray S131 BK F1.20 10A F1.21 20A G1002 Hot at all times Hot at all times F1.2 20A F1.1 30A 932 RD 932 C1041 Headlamp, right 85−1 Power Distributi on Center (PDC) RD 196 C1021 Headlamp, left 85−1 Power Distributio n Center (PDC) DB/OG C220 Instrument cluster 60−1 Introduction Ground Distribution Cell 10 “Grounds” contains the schematics that show the complete details for each ground connection or main ground splice This is useful in diagnosing a problem affecting several components at once (poor ground connection or ground splice) All details (wires, splices, connectors) between the ground point and the components are shown These ground connection details are shown here in order to keep the individual cell schematics as uncluttered as possible Headlamp, right (13008) 85−2 57 C1041 BK C162 57 BK Fog lamp, right front (15200) 86−1 57 Side lamp, left front (13411) 92−1 57 C152 Fog lamp, front left (15200) 86−1 BK Headlamp, left (13008) 85−2 C1127 BK 57 C1021 BK S102 Side lamp, right front (13411) 92−1 57 BK 57 C1126 BK G100 151−3 3-4 3-5 Introduction Component and Connector Information Cell 152 “Component Location Charts” helps the user find where the various items depicted on the schematic can physically be found on the vehicle A brief written description of the location is given, along with a reference to the component location views Cell 151 “Component Location Views” show the components and their connecting wires as they can be found on the vehicle Cell 150 “Connector Views” show the views of the pins and/or cavities of all connectors The pin and cavity sides are shown separately as if the connector were disconnected The color of the connector housing is indicated next to the connector number when available The harness causal number is located above the component name and below the connector number or above the connector face itself Wiring harness designations are listed in cell 152 “Component Location Charts” Circuit function charts are located below each connector C150 (BK) 12A581 Wheel speed sensor, left front (2C205) FEMALE Pin Circuit Circuit Function 522 (TN/BK) Wheel speed sensor, left front (2C205) − 521 (TN/OG) Wheel speed sensor, left front (2C205) + C1033 (BK) 12B637 14B102 2 FEMALE MALE (1) − (3) 359 (GY/RD) (2) 1102 (YE/LG) (4) − Introduction WARNINGS ! D Always wear safety glasses for eye protection D Use safety stands whenever a procedure requires being under a vehicle D Be sure that the Ignition Switch is always in the OFF position, unless otherwise required by the procedure D Set the parking brake when working on any vehicle An automatic transmission should be in PARK A manual transmission should be in NEUTRAL D Operate the engine only in a well-ventilated area to avoid danger of carbon monoxide D Keep away from moving parts, especially the fan and belts, when the engine is running D To prevent serious burns, avoid contact with hot metal parts such as the radiator, exhaust manifold, tail pipe, catalytic converter and muffler D Do not allow flame or sparks near the battery Gases are always present in and around the battery cell An explosion could occur D Do not smoke when working on a vehicle D To avoid injury, always remove rings, watches, loose hanging jewelry and avoid wearing loose clothing 3-6 -1 Symbols Distributed splice Entire component Resistor Part of a component Crossed wiring without connection Splice Potentiometer (pressure or temperature) Component case directly attached to metal part of vehicle (ground) Potentiometer (outside influence) Removable connection Component with screw terminals Ground Connector Battery Connector attached to component Fuse Female connector Connector attached to component lead (pigtail) Circuit breaker Positive Temperature Coefficient (PTC) Heating element, Conductor loop Male connector Twisted pair Symbols Ignition coil assembly Coil Bifilament lamp Shield Solenoid controlled valve or clutch solenoid Hall sensor Gauges Horn or speaker Light emitting diode (LED) Air bag sliding contact (14A664) Antenna Fusible link Capacitor Diode, current flows in direction of arrow Permanent magnet, one−speed−motor ! Variable capacitor Transistor Permanent magnet, two−speed−motor Piezoelectric sensor Lamp Rotational sensor Warning -2 -3 Symbols Wire colors BK Black BN Brown BU Blue DB Dark blue DG Dark green GN Green GY Gray LB Light blue LG Light green NA Natural OG Orange PK Pink RD Red SR Silver TN Tan VT Violet WH White YE Yellow VREF PWR VBATT Switched power Reference voltage VPWR Battery voltage − Switched or module voltage signal Joint connector signal SCP − Standard Corporate Protocol (SCP) data + Standard Corporate Protocol (SCP) data − ISO Data bus ISO 9141 (K−line) SIG RTN + signal SCP + − Signal return Signal return Switched ground C120 359 GY/RD C200 C200 359 GY/RD C120 Ground jumper 2079c151 00 00p24 US# Component Location Views 151-24 A A S401 C412 Tail lamp, left B B C C D D S402 S403 S405 S407 C415 Tail lamp, right E E C4015 Reversing alarm speaker F F front of vehicle vehicle rear end 152-1 Component Location Charts Components Location Cell 151 Page/coordinates ABS control module (2C219) main chassis side member, LH side Instrument cluster (10849) in dash panel, driver side Automatic transmission module (7G422) near Power Distribution Center (PDC) Engine Control Module (ECM) near Power Distribution Center (PDC) Remote keyless entry module (15K602) under dash panel, RH side Audio unit (18808) in dash panel, center Daytime Running Lamps (DRL) module behind dash panel, center Fuel Injector Control Module (FICM) near Power Distribution Center (PDC) 5R110 transmission transmission, RH side, bottom Door lock timer behind dash panel, center Manifold Absolute Pressure (MAP) sensor engine, top, front Engine Coolant Temperature (ECT) sensor (12A648) engine, front, near thermostat housing Water−in−fuel sensor main chassis side member, LH side, near transmission Wheel speed sensor, right front (2C204) wheel hub, RH side Wheel speed sensor, left front (2C205) wheel hub, LH side 22 − C −B 16 − C 17 − D 8 −D −A −D 17 − B −E −A −E −A 22 − F 22 − D 22 − A Mass Air Flow (MAF) sensor (12B579) engine, top, LH side Rear axle speed sensor (4B409) rear axle, top, center Camshaft position sensor (6B288) engine, LH side, bottom Crankshaft position sensor (6C315) engine, LH side, bottom Barometric Absolute Pressure (BAP) sensor behind dash panel, center Output Shaft Speed (OSS) sensor (7H103) transmission, top, rear Accelerator pedal position sensor under dash panel, on accelerator pedal support Engine Oil Temperature (EOT) sensor engine, top Injection Control Pressure (ICP) sensor (9F972) engine, top, on RH valve cover Speed sensor assembly (7M101) transmission, LH side Manifold Air Temperature (MAT) sensor engine, top, LH side Fuel sender, primary on fuel tank, top Fuel sender, secondary on fuel tank, top Data Link Connector (DLC) (14489) under dash panel, driver side Engine diagnostic connector under dash panel, driver side Headlamp, left (13008) front of vehicle, LH side Headlamp, right (13008) front of vehicle, RH side Roof marker lamp, left roof, LH side −A 21 − C −E −F −B −B −D −C −A −B −E 19 − B 20 − B −F −F −E −E 14 − A Component Location Charts Roof marker lamp, right roof, RH side Ashtray illumination lamp in dash panel, center Fog lamp, right front (15200) front of vehicle, RH side Fog lamp, left front (15200) front of vehicle, LH side License plate lamp (13550) vehicle rear end Interior lamp in roof panel Park/turn lamp, left front (13411) front of vehicle, LH side Park/turn lamp, right front (13411) front of vehicle, RH side Tail lamp, left vehicle rear end, LH side Tail lamp, right vehicle rear end, RH side Roof marker lamp, left center roof, center Roof marker lamp, center roof, center Roof marker lamp, right center roof, center Horn (13832) main chassis side member, RH side, front Indicator flasher relay (13350) behind dash panel, driver side Fuel pump relay in Power Distribution Center (PDC) Starter relay (11450) in Power Distribution Center (PDC) Fog lamp relay in Power Distribution Center (PDC) 14 − C 11 − B −F −E 14 − C −E −D 24 − B 24 − E 14 − A 14 − A 14 − B −E −D Horn relay behind dash panel, driver side Low beam relay in auxiliary fuse and relay box High beam relay in auxiliary fuse and relay box Park lamp relay in Power Distribution Center (PDC) Fuel heater relay in Power Distribution Center (PDC) Blower motor relay in auxiliary fuse and relay box A/C clutch relay in Power Distribution Center (PDC) Windshield wiper relay in Power Distribution Center (PDC) ECM power relay in Power Distribution Center (PDC) Glow plug relay near Power Distribution Center (PDC) Power window relay in auxiliary fuse and relay box Trailer tow relay, right turn in Auxiliary Junction Box (AJB), trailer tow Trailer tow relay, left turn in Auxiliary Junction Box (AJB), trailer tow Trailer tow relay, parking lamp in Auxiliary Junction Box (AJB), trailer tow Fuel Injector Control Module (FICM) power relay in Power Distribution Center (PDC) Manifold intake air heater relay near Power Distribution Center (PDC) Trailer tow relay, stoplamp in Auxiliary Junction Box (AJB), trailer tow Reversing lamps relay in Power Distribution Center (PDC) 152-2 −C −D −D 152-3 Component Location Charts Run/Accessory relay behind dash panel, center − B Body builder relay #1 in Power Distribution Center (PDC) Transmission relay in Power Distribution Center (PDC) A/C demand relay behind dash panel, center Pusher fan relay under dash panel, RH side Starter motor (11002) −F engine, LH side, bottom Fuel pump main chassis side member, LH side, near transmission Blower motor behind dash panel, RH side − C Windshield wiper motor (17508) behind dash panel, RH side − A Windshield washer pump motor (17618) −F under dash panel Door lock actuator, left front in driver door 15 − C Door lock actuator, right front in passenger door 15 − B Power window motor, left front in driver door 15 − E Power window motor, right front in passenger door 15 − E EGR valve actuator −E engine, top, front Pusher fan main chassis side member, RH side, front Fuel transfer pump main chassis side member, RH side 20 − E Brake fluid level switch (2L414) under dash panel, on master cylinder − D Oil pressure switch (9278) engine, top Hazard flasher switch in dash panel, center Parking brake switch (15A851) vehicle floor, center Key warning switch (11A127) on steering column Brake pedal position switch (13480) under dash panel, on brake pedal support Door ajar switch, left front LH B−pillar, bottom Door ajar switch, right front RH B−pillar, bottom Window adjust switch, passenger side in passenger door A/C high pressure switch (19D594) under dash panel, RH side Brake pressure switch (2B264) under dash panel, on master cylinder, bottom Ignition switch (11572) on steering column Safety belt buckle switch (10B924) seat belt buckle, driver side Illumination dimmer switch in dash panel, LH side A/C clutch cycling pressure switch (19D594) under dash panel, RH side Multifunction switch on steering column Master window adjust switch in driver door Floor shifter vehicle floor, center Speed control Set/Resume switch in dash panel, center −B −A 13 − B 10 − B 7 −C 13 − E 13 − A 15 − A −F −E 10 − B 13 − E 11 − D −F 10 − A 15 − A 13 − C −A Component Location Charts Speed control On/Off switch in dash panel, center − A Freeze protection switch −E behind dash panel, center Pusher fan pressure switch under dash panel, RH side Battery (10655) behind cab, RH side 18 − C Battery behind cab, RH side 18 − E Generator engine, front − A Fusible link A engine compartment, generator Fusible link B engine compartment, generator Glow plug engine, LH side − A Glow plug engine, RH side − A Glow plug engine, LH side − A Glow plug engine, RH side − A Function selector switch assembly (19B888) in dash panel, center − B In−line fuse near Power Distribution Center (PDC) In−line fuse near Power Distribution Center (PDC) Power Distribution Center (PDC) under cab, RH side, rear 17 − A Auxiliary relay box −E behind dash panel, center Auxiliary relay box vehicle underbody, chassis crossmember, rear 24 − E 152-4 Glow plug engine, LH side − A Glow plug engine, RH side − A Glow plug bank, right RH cylinder head − A Glow plug bank, left LH cylinder head − A Fuel heater main chassis side member, LH side, near transmission 22 − E Cigar lighter, front (15055) in dash panel, center − D Air intake heater engine, front − A Blower motor resistor (19A706) behind dash panel, RH side − A Resistor cap main chassis side member, LH side 19 − D A/C Compressor clutch diode −E engine, top, RH side Transmission relay diode in Battery Junction Box (BJB) Speaker, right front (18808) in passenger door 15 − C Speaker, left front (18808) in driver door 15 − C A/C clutch field coil (19D798) engine, front, RH side − D Fuel injector (9F593) −E RH cylinder head Fuel injector (9F593) LH cylinder head − D Fuel injector (9F593) RH cylinder head − D Fuel injector (9F593) LH cylinder head − B 152-5 Component Location Charts Fuel injector (9F593) RH cylinder head Fuel injector (9F593) LH cylinder head Injection Pressure Regulator (IPR) engine, top, rear Boost control solenoid engine, top, front Reversing alarm speaker vehicle rear end, RH side, on tail lamp support EGR system module near Power Distribution Center (PDC) −A −A −A −E 24 − E −B Component Location Charts Connectors Location C100 C102a C102b C103 C104 C110 C124 C125 C128 C130 C131 C133 C134 C135 C137 C139 C140 C143 C150 C152 C160 C162 C168 C175a C175b C175c C175d C193 C197a C197b C199 C202a Cell 151 Page/coordinates engine, front, RH side engine, front engine, front engine, top engine, top chassis crossmember, front, under dash panel, on master cylinder behind dash panel, RH side engine, top, LH side under dash panel, RH side main chassis side member, RH side, front chassis crossmember, front, chassis crossmember, front, main chassis side member, LH side under dash panel near Power Distribution Center (PDC) near Power Distribution Center (PDC) transmission, LH side wheel hub, LH side front of vehicle, LH side wheel hub, RH side front of vehicle, RH side near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) transmission, top, rear engine, LH side, bottom engine, LH side, bottom transmission, RH side, bottom on steering column −D −A −A 4 −B −C 11 − E −D −A −A −E −E 11 − E 11 − E 22 − B −E 16 − F 16 − E −B 22 − A −E 22 − D −E 16 − C 17 − C 17 − C 17 − D 17 − D −B −E −F −D 10 − A C202b C210 C211 C212 C220a C220b C240 C250 C251 C272 C278 C288 C290 C294a C294b C294c C300 C306 C311 C323 C412 C415 C421 C422 C423 C431 C455 C504 C518 C523 C552 C604 C612 C623 C641 C970 on steering column LH A−pillar LH A−pillar, under dash panel RH A−pillar, under dash panel in dash panel, driver side in dash panel, driver side in dash panel, center on steering column under dash panel, driver side under dash panel, RH side under dash panel, on brake pedal support behind dash panel, RH side in dash panel, center in dash panel, center in dash panel, center in dash panel, center LH B−pillar vehicle floor, center main chassis side member, LH side seat belt buckle, driver side vehicle rear end, LH side vehicle rear end, RH side 152-6 10 − A 14 − D 11 − E 11 − D −A −B 7 −A 10 − B −E −D 7 −C −B 7 −A −B 7 −B 7 −B 14 − D 13 − B 19 − A 13 − E 24 − B 24 − E L9501, L1081 L9501, L1081 L9501, L1081 vehicle underbody, rear, chassis crossmember rear axle, top, center in driver door in driver door in driver door in driver door in passenger door in passenger door in passenger door in passenger door roof, LH side 21 − C 15 − A 15 − E 15 − C 15 − C 15 − A 15 − C 15 − E 15 − B 14 − A 152-7 C971 C972 C973 C974 C981 C1007 C1016 C1017 C1021 C1023 C1025 C1030 C1035 C1041 C1043 C1051 C1064 C1076 C1078 C1080 C1084a C1084b C1084c C1084d C1086 C1087 C1095 C1100a C1100b C1120 C1162a C1162b C1174a C1174b Component Location Charts roof, center roof, center roof, center roof, RH side in roof panel in Power Distribution Center (PDC) in Power Distribution Center (PDC) in Power Distribution Center (PDC) front of vehicle, LH side front of vehicle, LH side under dash panel, on master cylinder, bottom behind dash panel, center under cab, RH side, rear front of vehicle, RH side front of vehicle, RH side in Power Distribution Center (PDC) engine, front, near thermostat housing main chassis side member, LH side, near transmission under dash panel, RH side main chassis side member, LH side, near transmission near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) engine, top, RH side engine, top, front in Power Distribution Center (PDC) behind cab, RH side behind cab, RH side engine, LH side, bottom behind dash panel, center behind dash panel, center near Power Distribution Center (PDC) near Power Distribution Center (PDC) 14 − A 14 − A 14 − B 14 − C 14 − C −E −E 7 −E −D 17 − A −E −D 1 −A 22 − E −E 22 − E −C −C −C −C −E −E 18 − C 18 − C −F −E −E 17 − B 17 − B C1174c C1181 C1182 C1183 C1184 C1185 C1186 C1228 C1235 C1236 C1237 C1239 C1242 C1244 C1245a C1245b C1245c C1245d C1249a C1249b C1253 C1275 C1329 C1382 C1389 C1413 C1414 C1450 C1474 C1491 C1515 C1519 C1520 C1521 C1529 near Power Distribution Center (PDC) RH cylinder head LH cylinder head RH cylinder head LH cylinder head RH cylinder head LH cylinder head behind dash panel, RH side in Power Distribution Center (PDC) engine, top, LH side main chassis side member, LH side engine, front engine, top, rear engine, top, on RH valve cover near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) near Power Distribution Center (PDC) behind cab, RH side behind cab, RH side main chassis side member, LH side, near transmission engine, LH side, bottom in Power Distribution Center (PDC) in Power Distribution Center (PDC) engine, top, front LH cylinder head RH cylinder head near Power Distribution Center (PDC) in Power Distribution Center (PDC) in Power Distribution Center (PDC) engine, top, front in Power Distribution Center (PDC) in Power Distribution Center (PDC) in Power Distribution Center (PDC) main chassis side member, RH side, front 17 − B 4 −E −D −D −A −A −A −A −E 19 − C −A −A −A −C −C −D −D 18 − E 18 − E −E −E −A 2 −A −A −E Component Location Charts C2014 C2017 C2031 C2039 C2047 C2077 C2112 C2171 C2173 C2177 C2178 C2188 C2218 C2234 C2242 C2246 C2256 C2298 C2312 C2333 C2334 C2344 C2345 C2346 C3129 C3141 C3245 C3262 C3263 C3264 C4015 C4019 C4020 C4022 C4046a C4046b in dash panel, center in auxiliary fuse and relay box in dash panel, center in dash panel, center behind dash panel, driver side behind dash panel, driver side on steering column under dash panel, on accelerator pedal support under dash panel, driver side in dash panel, center in dash panel, center in dash panel, center in auxiliary fuse and relay box in auxiliary fuse and relay box in auxiliary fuse and relay box in dash panel, LH side behind dash panel, center in dash panel, LH side behind dash panel, center behind dash panel, center in auxiliary fuse and relay box behind dash panel, center under dash panel, RH side under dash panel, RH side LH B−pillar, bottom RH B−pillar, bottom vehicle floor, center on fuel tank, top on fuel tank, top main chassis side member, RH side vehicle rear end, RH side, on tail lamp support in Auxiliary Junction Box (AJB), trailer tow in Auxiliary Junction Box (AJB), trailer tow in Auxiliary Junction Box (AJB), trailer tow vehicle rear end vehicle rear end 11 − B −D −A −D 7 −C 10 − B 7 −D −F −A −A −C −B 11 − D −B −A 13 − E 13 − A 13 − C 19 − B 20 − A 20 − D 24 − E C4202 in Auxiliary Junction Box (AJB), trailer tow 152-8 152-9 Component Location Charts Ground points Location G100 G101 G102 G103 G104 G105 G106 G107 G108 G200 Cell 151 Page/coordinates behind dash panel, RH side behind dash panel, RH side main chassis side member, near Power Distribution Center (PDC) main chassis side member, near Power Distribution Center (PDC) vehicle underbody, front on radiator engine, top, RH side engine, bottom, RH side main chassis side member, RH side in LH front footwell 12 − E 12 − E 16 − D 16 − D 23 − B 22 − C −E 12 − E Component Location Charts 152-10 S124 Splices Location S100 S101 S102 S103 S104 S105 S106 S107 S108 S109 S110 S111 S112 S113 S114 S115 S116 S117 S118 S119 S120 S121 S122 S123 Wiring harness − Main near T/O to C1080 Wiring harness − Main near T/O to G103 Wiring harness − Engine Sensor in T/O to C1087 Wiring harness − Engine Sensor in T/O to C1087 Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) Wiring harness − Main near T/O to C175b Wiring harness − Engine Sensor near T/O to C140 Wiring harness − Engine Sensor near T/O to C140 Wiring harness − Main near T/O to C143 Wiring harness − Main in T/O to C168 Wiring harness − Main near T/O to C150 Wiring harness − Main near T/O to C150 Wiring harness − Main near T/O to C150 Wiring harness − Main near T/O to C150 Wiring harness − Main near T/O to C1237 Wiring harness − Main near T/O to C1237 Wiring harness − Main near T/O to C1237 Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) Wiring harness − Main near T/O to C1237 Wiring harness − Engine Sensor near T/O to C1450 22 − A −C −C 17 − B 16 − E −D 1 −D 22 − B 16 − E 23 − A 23 − A 22 − A 22 − A 19 − A 19 − A 23 − F 17 − B 17 − B 17 − B 17 − B 17 − C 23 − F 3 −B S125 S126 S127 S128 S129 S130 S131 S132 S133 S134 S135 S136 S138 S139 S140 S141 S142 S143 S144 S145 S146 S147 S148 S149 S200 S201 S202 S203 S204 Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) 17 − C Wiring harness − Engine Sensor near T/O to C1450 −A Wiring harness − Main near T/O to C1237 23 − F Wiring harness − Engine Sensor near T/O to C140 −E Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) 17 − C Wiring harness − Main near T/O to C150 23 − F Wiring harness − Main in T/O to Power Distribution Center (PDC) (14A003) 17 − C Wiring harness − Main near T/O to C1237 23 − F Wiring harness − Main near T/O to C1237 23 − F Wiring harness − Main near T/O to C143 22 − F Wiring harness − Main near T/O to C143 22 − A Wiring harness − Main near T/O to C1237 23 − F Wiring harness − Main near T/O to C143 22 − F Wiring harness − Main near T/O to C143 22 − E Wiring harness − Engine Sensor near T/O to C175c −B Wiring harness − Engine Sensor near T/O to C1236 −E Wiring harness − Engine Sensor near T/O to C1244 −B Wiring harness − Engine Sensor near T/O to C1244 −B Wiring harness − Engine Sensor near T/O to C1244 −B Wiring harness − Engine Sensor in T/O to C175d −D Wiring harness − Engine Sensor in T/O to C175d −E Wiring harness − Engine Sensor in T/O to C175d −E Wiring harness − Engine Sensor in T/O to C175c −D Wiring harness − Engine C268 near T/O to C1174a −E Wiring harness − Engine Sensor in T/O to C1450 −C Wiring harness − Instrument panel in T/O to G200 −E Wiring harness − Instrument panel in T/O to G200 −E Wiring harness − Instrument panel near T/O to C1030 −A Wiring harness − Instrument panel near T/O to C2333 −E Wiring harness − Instrument panel near T/O to C2312 12 − A 152-11 S205 Component Location Charts Wiring harness − Instrument panel near T/O to C1030 −A S206 Wiring harness − Instrument panel near T/O to C2233 S207 S208 Wiring harness − Instrument panel in T/O to C124 Wiring harness − Instrument panel near T/O to C220a S209 Wiring harness − Instrument panel near T/O to C220a S210 Wiring harness − Instrument panel near T/O to C220a S228 S229 S230 −F −A S231 −E S232 −E S233 S234 −E S211 S212 S213 S214 S215 S216 S217 S218 S219 S220 S221 S222 S223 S224 S225 S226 S227 Wiring harness − Instrument panel near T/O to C220a −E 12 − A −A Wiring harness − Instrument panel near T/O to C278 Wiring harness − Instrument panel in T/O to C1025 Wiring harness − Instrument panel in T/O to Auxiliary −D relay box Wiring harness − Instrument panel in T/O to Auxiliary −D relay box Wiring harness − Instrument panel near T/O to C278 12 − A Wiring harness − Instrument panel near T/O to C1030 12 − E Wiring harness − Instrument panel near T/O to C110 −E Wiring harness − Instrument panel in T/O to C2312 −D Wiring harness − Instrument panel in T/O to C2178 −E Wiring harness − Instrument panel near T/O to C2312 12 − A Wiring harness − Instrument panel near T/O to C1030 12 − A Wiring harness − Instrument panel near T/O to C1030 12 − A Wiring harness − Instrument panel near T/O to G200 12 − E Wiring harness − Instrument panel near T/O to C278 −A Wiring harness − Instrument panel near T/O to G200 12 − A Wiring harness − Instrument panel near T/O to C2312 12 − A S235 S236 S237 S238 S239 S240 S241 S242 S243 S244 S245 S246 S247 S248 S249 S250 S251 S300 Wiring harness − Instrument panel near T/O to G200 12 − A Wiring harness − Instrument panel near T/O to G200 12 − E Wiring harness − Instrument panel near T/O to C202b 12 − D Wiring harness − Instrument panel near T/O to C1030 12 − E Wiring harness − Instrument panel near T/O to C202b 12 − D Wiring harness − Instrument panel near T/O to C110 11 − E Wiring harness − Instrument panel near T/O to C202b 12 − A Wiring harness − Instrument panel in T/O to G200 12 − E Wiring harness − Instrument panel near T/O to C110 11 − E Wiring harness − Instrument panel near T/O to G200 12 − D Wiring harness − Instrument panel near T/O to G200 12 − A Wiring harness − Instrument panel near T/O to C294c −A Wiring harness − Instrument panel near T/O to C1030 12 − E Wiring harness − Instrument panel in T/O to C2333 12 − E Wiring harness − Instrument panel near T/O to C1030 Wiring harness − Instrument panel near T/O to C251 Wiring harness − Instrument panel near T/O to C2171 Wiring harness − Instrument panel near T/O to Audio unit (18808) Wiring harness − Instrument panel near T/O to Audio unit (18808) Wiring harness − Instrument panel near T/O to Audio unit (18808) Wiring harness − Instrument panel near T/O to Function selector switch assembly (19B888) Wiring harness − Instrument panel in T/O to Auxiliary relay box Wiring harness − Instrument panel near T/O to G200 Wiring harness − Instrument panel in T/O to C2177 Wiring harness − Floor Component Location Charts 152-12 S301 S401 S402 S403 S404 S405 S406 S407 S408 S409 S900 S901 S902 Wiring harness − Floor Wiring harness − Rear C762 near T/O to C412 Wiring harness − Rear C762 near T/O to C415 Wiring harness − Rear C762 near T/O to C415 Wiring harness − Rear C762 near T/O to C311 Wiring harness − Rear C762 near T/O to C412 Wiring harness − Rear C762 near T/O to C405 Wiring harness − Rear C762 near T/O to C412 Wiring harness − Rear C762 near T/O to C405 Wiring harness − Rear C762 near T/O to C455 Wiring harness − roof near T/O to C210 Wiring harness − roof near T/O to C210 Wiring harness − roof near T/O to C971 24 − A 24 − D 24 − D 19 − C 24 − E 24 − E 24 − E 24 − E 21 − A 14 − B 14 − B 14 − A 152-13 Component Location Charts Wiring harness Location 12B637 12A581 12B637 14335 14401 14405 14405 14405 14630 14630 14631 14631 14A005 9D930 Cell 151 Page/coordinates Wiring harness − Engine Sensor Wiring harness − Main Wiring harness − Engine Sensor Wiring harness − roof Wiring harness − Instrument panel Wiring harness − Rear Chassis − Aft tank Wiring harness − Rear Chassis − Dual tank Wiring harness − Rear Chassis − Left tank Wiring harness − passenger door Wiring harness − Power Door Locks − passenger door Wiring harness − driver door Wiring harness − Power Door Locks − driver door Wiring harness − Floor Wiring harness − Fuel injectors 160 -1 Vehicle Repair Location Charts Vehicle Repair Location Codes TO PINPOINT THE ACTUAL VEHICLE LOCATION OF A REPAIR, THE VEHICLE REPAIR LOCATION CODE IS REQUIRED For example, an ”X” has been placed in the quadrant of the vehicle diagrams indicating the location of the repair See diagrams LOCATION CODE, FOR THE EXAMPLE: A5/FU − (UNDER THE FLOOR OF DRIVER’S LEFT FOOT.) Front/rear direction FRONT A B x C D E F Over/under direction RO RU ENGINE BO BU FO FU R = roof line RO = roof over RU = roof under B = belt line BO = belt over BU = belt under F = floor pan FO = floor over FU = floor under x CENTER RO RU BO BU FO FU x SIDE VIEW REAR ... pillars below door trim panel, center console 400−499 4000−4999 behind rear seats, to rear bumper; Truck bed, Tailgate, Liftgate, Rear fenders 500−599 left front door 600−699 right front door 700−799