Tài liệu Automatic Transmissions P18 doc

... found at the top of the chart. (for example: A−540E AUTOMATIC TRANSAXLE Repair Manual Pub. No. RM530U) The overhaul repair manual for automatic transmissions is a separate silver and black publication ... will affect line pressure and shift quality in both ECT and non−ECT transmissions. Shift timing will be affected in non−ECT transmissions only. The shift cable connects the shift se...

Ngày tải lên: 19/01/2014, 04:20

... the converter is appropriate. Section 2 TORQUE CONVERTER Lesson Objectives TORQUE CONVERTER Automatic Transmissions - Course 262 15 There are two ways to test a torque converter. The first method ... specification, replace the converter. Stall Testing CAUTION Converter Installation TORQUE CONVERTER Automatic Transmissions - Course 262 17 When replacing a converter or installing a rema...

Ngày tải lên: 12/12/2013, 11:15

... the driver. The automatic transmission cannot select these positions automatically on its own. The next selector position is the only position from which the transmission is fully automatic. In ... vehicle speed and will downshift to second gear; however, in Electronic Control Transmissions and on A40 and A340 series transmissions with a D−2 Downshift Timing Valve, the transmission do...

Ngày tải lên: 22/12/2013, 11:15

... Toyota automatic transmissions. 3. Identify automatic transmission fluid conditions and their cause. Section 6 AUTOMATIC TRANSMISSION FLUID Lesson Objectives: AUTOMATIC TRANSMISSION FLUID Automatic ... have been used in Toyota automatic transmissions. Type T is the latest type to be used and is found in All−Trac transaxles (A241H and A540H). Type F was used in early Toyota aut...

Ngày tải lên: 22/12/2013, 11:15

... Automatic Transmissions - Course 262 137 1. Given the clutch application chart for the A340H Transfer ... and four-wheel drive as well as low-gear four-wheel drive. CAUTION Components A340H TRANSFER Automatic Transmissions - Course 262 139 The transfer unit has three shafts: • The transmission output ... axle. Section 9 A340H TRANSFER Lesson Objectives: Section 9 138 TOYOTA Technical...

Ngày tải lên: 22/12/2013, 11:15

... A Glossary of Terms A C D F Automatic Transmission Diagnosis - Course 273 E-188 Customer Interview Sheet Automatic Transmission/Transaxle Appendix E Customer Interview Sheet Automatic Transmission ... volts when the circuit is on. Automatic Transmission Diagnosis - Course 273 C-185 Appendix C ECT Diagnostic Information Appendix C C-186 TOYOTA Technical Training Automatic Transmissio...

Ngày tải lên: 19/01/2014, 04:20

... holding devices used in Toyota automatic transmissions. Section 1 FUNDAMENTALS OF AUTOMATIC TRANSMISSIONS Lesson Objectives Section 1 2 TOYOTA Technical Training Automatic transmissions can be basically ... drive automatics are the same. They share the same planetary gear train design which is used in all Toyota automatic transmissions and the majority of automatics in product...

Ngày tải lên: 12/12/2013, 11:15

... design is basic to most all automatic transmissions in production today. Reverse Direction Direct Drive - (One-To-One Ratio) SIMPSON PLANETARY GEAR UNIT Automatic Transmissions - Course 262 The ... Ring Gear TorqueSpeed Rotational SIMPSON PLANETARY GEAR UNIT Automatic Transmissions - Course 262 SIMPSON PLANETARY GEAR UNIT Automatic Transmissions - Course 262 external gears are...

Ngày tải lên: 22/12/2013, 11:15

... POWER FLOW Automatic Transmissions - Course 262 77 PROCEDURE Drive Pinion Preload Perform the following procedures. ... it. Preload: In Lbs. Preload (at Starting) New Bearing Reused Bearing Spec. Measured POWER FLOW Automatic Transmissions - Course 262 51 Multiplate clutches and brakes were discussed in detail earlier, ... Clutch ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁ...

Ngày tải lên: 22/12/2013, 11:15

... Automatic Transmissions - Course 262 81 1. Demonstrate the measurement of the oil pump gears to determine the ... OIL PUMP Lesson Objectives: Section 7 82 TOYOTA Technical Training The pump used in Toyota automatic transmissions is the crescent type. It is designed to: • Provide fluid to lubricate the planetary ... reaction shaft) as well as the front of planetary gear set. Purpose of...

Ngày tải lên: 22/12/2013, 11:15