Ford diesel 6lvgtguide 2005

... reduce leaks due to improper installation 10 FCS-13943-03 © 2005 International Truck and Engine Corporation FCS-13943-03 February 2005 Revision ... incremental counter This code is used to detect a MAP circuit shorted to power Code P0299 (2004 & 2005 MY only) will be set if the difference between EP_G and EP_DES meet any of the following conditions: ... are rounded off and there is dirt...

Ngày tải lên: 20/09/2017, 23:08

... P0 568 P0 569 P0571 O R Cruise Control SET Signal R Cruise Control COAST Signal Brake Switch A Circuit P 060 3 C P 060 5 P 060 6 P 061 1 P 062 0 P 062 3 P 064 5 P 064 9 P 067 0 P 067 1 P 067 2 P 067 3 P 067 4 P 067 5 P 067 6 ... 22 36 BCPIL N/C DPCAT 33 30 38 26 12 20 24 25 15 29 16 37 17 36 36 28 18 EGRT2 EGRT1 ITAC FICMM CAN2H CAN2L CKPO CMPO 34 15 28 37 22 26 19 20 12 35 J1- C2 Pocke...

Ngày tải lên: 20/09/2017, 23:22

... BRACKET 12 2005 6.0L DIT RUNNING CHANGES 2005 MY Excursion Engine Change 2005 Excursion • The early 2005 MY Excursions were equipped with the 2004.25 MY engines Component Pre-Jan 2005 Post-Jan 2005 ... plate as used on the previous design 0.24” 0.12” 2005 6.0L DIT RUNNING CHANGES Early Style Rear Heat Shield • The 2003, 2004, and early production 2005 MY engines have t...

Ngày tải lên: 20/09/2017, 23:22

... described in the remainder of this document FORD MOTOR COMPANY REVISION DATE: JANUARY 7, 2010 09.01.00.02-PAGE OF 157 General Description 6.7L Diesel Engine The 6.7L is a V8 engine designed to meet ... System Diesel Oxidation Inlet Temperature Diesel Oxidation Outlet Temperature Selective Catalytic Reduction Outlet Temperature Upstream Catalyzed Diesel Particulate Filter Pressur...

Ngày tải lên: 22/10/2012, 08:40

... vehicles 62 Install the Heavy Duty Floor Crane and Diesel Engine Lifting Bracket on the engine 2005 F-250, 350, 450, 550 Super Duty, 10 /2004 303-01C-10 Engine — 6. 0L Diesel 303-01C-10 REMOVAL ... electrical connectors 2005 F-250, 350, 450, 550 Super Duty, 10 /2004 303-01C -6 Engine — 6. 0L Diesel 303-01C -6 REMOVAL (Continued) 36 Remove the retaining nut and di...

Ngày tải lên: 20/09/2017, 22:57

... (X1) C1388B (X2) C1388C (X3) Powertrain Control Module FICM Fuel Injection Control Module 16 10 FAULT CODE DIAGNOSTICS P0 261 P0 264 P0 267 P0270 P0273 P02 76 P0279 P0282 Cylinder Cylinder Cylinder ... Contribution/Balance P 261 4 P 261 7 Camshaft Position Output Circuit/Open Crankshaft Position Output Circuit/Open P 061 1 Fuel Injection Control Module Performance P1378...

Ngày tải lên: 20/09/2017, 22:57

... the oil level indicator and tube 2005 F-250, 350, 450, 550 Super Duty, 10 /2004 303-01C -6 Engine — 6. 0L Diesel 303-01C -6 IN-VEHICLE REPAIR (Continued) 25 Remove the retaining nuts Remove the exhaust ... Super Duty, 10 /2004 303-01C-11 Engine — 6. 0L Diesel 303-01C-11 IN-VEHICLE REPAIR (Continued) Tighten the head bolts in the following sequence Tighten bolts through 10 to 8...

Ngày tải lên: 20/09/2017, 22:57

... coolant temperature (ECT) sensor 2005 F-250, 350, 450, 550 Super Duty, 10 /2004 303-01C -6 Engine — 6. 0L Diesel 303-01C -6 IN-VEHICLE REPAIR (Continued) All vehicles 33 NOTE: Left side shown, right ... Super Duty, 10 /2004 303-01C-5 Engine — 6. 0L Diesel 303-01C-5 IN-VEHICLE REPAIR (Continued) 28 Disconnect the engine oil pressure (EOP) sensor electrical connector 31 Disconnect...

Ngày tải lên: 20/09/2017, 22:57

... pins 2005 F-250, 350, 450, 550 Super Duty, 10 /2004 303-04D -6 Fuel Charging and Controls — Turbocharger 303-04D -6 REMOVAL AND INSTALLATION (Continued) 16 Install the push pins 17 NOTE: If there is ... apply clean engine oil Position the turbocharger and install the turbocharger drain tube Remove the front mounting bolts 16 Position the turbocharger and remove the turbocharger drain t...

Ngày tải lên: 20/09/2017, 22:57

... the turbocharger relative to performance can be visually identified WARNING: ALL VISUAL INSPECTIONS OF THE TURBOCHARGER MUST BE MADE WITH THE ENGINE OFF AND THE TURBOCHARGER NOT SPINNING TURBOCHARGER ... vibration and ultimately turbocharger failure Over-speeding the turbocharger may also cause turbocharger thrust bearing failure, increasing the axial endplay of the turbocharge...

Ngày tải lên: 20/09/2017, 23:08

... spacers out of the PCV, VCV connectors while the pump is still on the bench HPFP cover gasket kit Ford did not a good job with the convolute solution to chaffing, as you can see if left alone it ... Document prepared by Bradley C Clayton Photography by Bradley C Clayton Appendix: parts list 9/10 /2009 6.4L longblock parts list photo # part number #1 8C3Z-6009-A #2 3C3Z-9C064-DA #3 W300132...

Ngày tải lên: 20/09/2017, 23:14

Ngày tải lên: 20/09/2017, 23:14

... pressure fuel system damage Replace both fuel filters (primary and secondary) Perform Fuel System Flush Refer to Procedure C, below.) Procedure C – Fuel System Flush Remove the rear Fuel Cooler ... High Pressure fuel system components; • High Pressure Fuel Pump • Engine mounted high pressure fuel lines • Both high pressure fuel rails • Eight fuel injectors • Low pr...

Ngày tải lên: 20/09/2017, 23:14

... 2000 250 0 3000 3500 4000 engine speed [rpm ] Torque [ft-lb] Pow er [bhp] 6. 0L POWER STROKE OVERVIEW 6. 0L Power Stroke Diesel Specifications Engine Type Diesel, ... i n t e n t i o n a l l y l e ft b l a n k 6. 0L Power Stroke Direct Injection Tu r b o c h a r g e d D i e s e l Engine 6. 0L POWER STROKE OVERVIEW 6. 0L Power Stroke Overview • This publication ... Horsepow...

Ngày tải lên: 20/09/2017, 23:15

... TURBOCHARGER DESCRIPTION AND BASIC OPERATION The turbocharger for the 6. 0L Power Stroke engine is designed to improve throttle response ... dirt accumulation in the compressor inlet Note: For 6. 0L Powerstroke diesel engines with engine oil diluted with four or more quarts of oil, the turbocharger endplay needs to be checked (.001” - ... vibration and ultimately turbocharger...

Ngày tải lên: 20/09/2017, 23:15