Hydroblasting and Coating of Steel Structures Episode 1 docx

... surface preparation References 13 3 13 6 13 8 14 4 14 9 15 0 15 1 15 2 15 4 15 5 15 7 15 9 16 0 16 9 17 6 18 1 18 3 Appendix 19 9 Index 203 viii List of Symbols and Abbreviations Used plunger ... vii 17 18 24 29 38 45 46 47 55 59 63 66 73 77 78 84 87 94 11 3 11 4 11 4 12 1 12 6 Hydroblasting and Coating of Steel Structures...

Ngày tải lên: 13/08/2014, 16:21

... unusually high (compare Fig. 2 .1 3(a)). 38 Hydroblasting and Coating of Steel Structures coating: rubber ;J rotational speed in min-' - -250 -10 00 11 111 111 11. I 0.005 m < 0.004 ... both paint systems in 46 Hydroblasting and Coating of Steel Structures 3 .1 High-pressure Water Jet Machines 3 .1. 1 General Structure 3 .1. 1 .1 Def...

Ngày tải lên: 13/08/2014, 16:21

... 3.57 420 4.52 3 31 12 0 95 10 0 78 11 7 93 98 74 12 2 96 10 0 78 22 300 18 19 15 26 250 20 21 17 32 200 26 27 21 350 nc = 420 min-' Lo- d -15 mm n, = 504 mid ... HHdroblasting and Coating of Steel Structures Table 3 .1 Operating pressure in MPa Recommended water filter siaes (Kauw, 19 92). Recommended filter size in pn...

Ngày tải lên: 13/08/2014, 16:21

... 0.003-0. 01 0.86' 1. 65 2.99 0.093-0. 21 0. 31- 1 3.5 0 .1 32-0. 710 6 .14 11 .11 14 -20 0 .12 0 .16 ~ Dupuy et al. (20 01) Marshall (20 01) Dupuy et al. (20 01) Holle (2000) Holle ... section of the nozzle 78 Hydroblasting and Coating of Steel Structures 4 .1 Efficiency of Hydroblasting 4. I. 7 General Aspects Numerous factors af...

Ngày tải lên: 13/08/2014, 16:21

... Coating system ~44 Sa2 11 2 0~0~ OFl' OF2 ' Rust OF0 gradeC OF1 OF2 Degraded OF0 shop OF1 primer OF2 ~~ 11 11 00 10 0 010 11 1 1 11 11 10 0 0 10 010 000 011 1 ... Noxyde ~ 204 2 22 213 2 17 19 9 2 20 213 2 24 2 212 16 208 t 21 17 3 2 15 19 2 518 18 2 2 21 18 12 17 17 829 16 9 t 11 14 82 15 13 62 11 15 1 t...

Ngày tải lên: 13/08/2014, 16:21

... 0.0 21 0 .12 1 0.033 0.003 0. 015 0. 018 0. 414 0.855 0.846 0. 211 2. 611 (10 0%) 0.057 1. 512 0.0 31 0.672 1. 989 0.250 0.352 0.045 9.450 0. 513 42.03 62.55 1. 260 12 0. 71 (4623%) 13 4 ... 1. 5 4 .1 Hydroblasting 1. 6 15 .2 - 0.8 1. 8 4.2 0 2.4 4.6 1. 2 0 .1 2 .1 2.4 4.8 10 .3 1. 2 0 1. 0 0 0 0.8 Wire brush 28.8 16 .0 23.2 17 .6 63.5...

Ngày tải lên: 13/08/2014, 16:21

... 0.74 0.93 0.69 0.99 -0.24 1. 557 0.358 1. 215 -0.63 1. 185 0 .15 6 1. 457 -0. 61 1 .19 9 0 .16 6 1. 4 51 0.025 1. 976 1. 976 0.976 -0.67 1. 156 0 .13 5 1. 463 0.68 6.089 0.836 0.329 Projectile material. ... moulds and castings 18 Hydroblasting and Coating 01 Steel Structures 2 .1 Properties and Structure of High-speed Water Jets 2 .1. 1 Velocit...

Ngày tải lên: 13/08/2014, 16:21

... E: f a n " 1 2 3 4 5 6 7 8 9 loll 12 1 314 1 516 1 718 1920 212 2 Day of measurement (October 1, 19 99 till October 22, 19 99) Figure 4 .18 Dupuy, 20 01 ). Air monitoring results ... Copper 19 .7 Lead (0 .10 Nickel 0.39 Selenium 0.20 Silver <0 .10 Zinc 13 .2 Recycled water in mg/l (0 .10 0 .14 <0 .10 <0 .10 0 .11 <0 .10 (0 .1...

Ngày tải lên: 13/08/2014, 16:21

... 15 4 Hydroblasting and Coating of Steel Structures Table 6.2 Standard Cleaning degree Comparative cleaning degrees (visible contaminants). IS0 85 01- 1 Sa 1 Sa 2 Sa 2 11 2 Sa ... rusting: Limitations to hydroblasting (e.g. the removal of oil and grease, or milscale); 15 0 Hydroblasting and Coating of Steel Structures 6 .1 Introduction A num...

Ngày tải lên: 13/08/2014, 16:21

... 62.9 16 .7-29.7 20.8-2 1. 9 14 .8 8.5 -1 8.6 6.6 -1 3.3 5.3 10 .3-2 1. 5 21. 5 4.2-7.5 1 .o 0 .12 -0 .19 0 .1 5-0 .16 0 .11 0.06-0 .12 0.05-0 .10 0.04 0.09-0 .1 7 0.20 0.04-0.06 0. 01 dynamic ... Rotterdam, 2 31- 243. 99 7 -1 0 12 . on coating performance. Proc. SSPC Con$, Atlanta. 233-235,l -12 . 697- 716 . Part B, Vol. 211 ,l-9. 18 2 Hydrobl...

Ngày tải lên: 13/08/2014, 16:21