Root Cause Failure Analysis Part 6 pot

... 148 Root Cause Failure Analysis Figure 11-1 Top-entering propeller-type mixer (Thomas Register 1995). Figure 11-2 Side-entering propeller-type mixer (Thomas Register 1995). 168 Root Cause ... that the actual feed rate is maintained 160 Root Cause Failure Analysis Cleaning As previously indicated, most bag-type filters require a precoating of particulates befo...

Ngày tải lên: 11/08/2014, 21:23

... 5 Time (sec) Figure I 66 Flux-vector inverter response charaeteristks. 198 Root Cause Failure Analysis Per unit Torque 66 7 83.3 Speed in Hertz Figure 16- 3 V/Hz drive cannot ... This factor compensates for the variation in speed, or slip, caused by load changes. 194 172 Root Cause Failure Analysis Table 161 Gear Characteristics Overview Gear Type...

Ngày tải lên: 11/08/2014, 21:23

... resilient Figure 17-3 Rising stem gate valve. 2 16 Root Cause Failure Analysis PT PT U'JI PT El PT PT PT Type 3 Type 4 Type 6 Figure 17-15 Schematic for center or neutral ... operate an I1 12 B Y3 il Figure 17-11 Three-way, fluid-power valve (Nelson 19 86) . 2 06 Root Cause Failure Analysis Straight - flow Angle - flow Cross - fl...

Ngày tải lên: 11/08/2014, 21:23

... increased difficulty is that the cause often is subjective. ROOT CAUSE FAILURE ANALYSIS Part I INTRODUCTION TO ROOT CAUSE FAILURE ANALYSIS ROOT CAUSE FAILURE ANALYSIS R. Keith Mobley ... Valves Seals and Packing i 3 6 13 58 67 73 75 77 07 112 173 137 153 164 171 187 1 93 302 ‘20 ROOT CAUSE FAILURE ANALYSIS I GENERAL ANALYSI...

Ngày tải lên: 11/08/2014, 21:23

... of potential root causes to verify each of the suspect causes is essential. In almost all cases, a relatively simple, inexpensive test series can be devel- Root Cause Failure Analysis ... use not enforced L.C"f?%EF-) Figure 3-9 Common root causes of procedure-related problems. 46 Root Cause Failure Analysis 4 Polides and Procedures No standard...

Ngày tải lên: 11/08/2014, 21:23

... fluorochloroethy lene 766 4-41-7 77 26- 95 -6 7782-50-5 75-21-8 764 7-01 -0 7783- 06- 4 75-3 1-0 463 -51-4 74-89-5 74-87-3 62 4-83-9 769 7-37-2 594-42-3 761 6-94 -6 79-38-9 10,000 1,500 ... selected with care. 77 56 Root Cause Failure Analysis Causes and Long-Term Corrective Actions This section of the report should clearly describe the specific root...

Ngày tải lên: 11/08/2014, 21:23

... (in.) 12x6 15x6 18x6 24 x 8 30x 10 36x 12 Quantity of Material cftm 0.40 0.49 0. 56 1. 16 1 .60 2.40 Approximate Capacity (short tonshour) 60 13 84 174 240 360 Lump ... 0.9 0.8 0.7 0 .6 Source: Theodore Baumeister, ed Marks’ Standard Handbook for Mechanical Engineers, 8th ed. (New York: McCraw-Hill, 1978). 122 Root Cause Failure Analysis...

Ngày tải lên: 11/08/2014, 21:23

... Root Cause Failure Analysis Table 21-1 Common Failure Modes of Pneumatic Conveyors I THE CAUSES Piping Configuratkn Unsuitable IPiping Leakage4 240 Root Cause Failure Analysis ... liquid. 260 Root Cause Failure Analysis Table 22-3d Common Failure Modes of Reciprocating, Positive-Displacement Compressors THE PROBLEM I THE CAUSES Table 22-3...

Ngày tải lên: 11/08/2014, 21:23

... Agitators 265 Table 23-1 Common Failure Modes of Mixers and Agitators Source: Integrated Systems, Inc. 2 86 Root Cause Failure Analysis Table 31-1 Common Failure Modes of Wear Part Surfaces ... may result in the use of improper equipment for a particular application. 264 274 Root Cause Failure Analysis Figure 26- 2 Wearpattern caused by abrasive...

Ngày tải lên: 11/08/2014, 21:23

... 14 ,62 Repetition of tasks, 61 Report preparation, 54 Reporting problems, 37 Resource conservation and recovery act, 71 Roll face, 166 Roll neck, 166 Root cause, 4, 5, 14 Root cause ... 1-800- 366 - 266 5. You can also visit our web site at: http://www.bh.com These books are available fiom all good bookstores or in case of difficulty call: 1-800- 366 - 266 5 in the...

Ngày tải lên: 11/08/2014, 21:23