Handbook of Lubrication Episode 2 Part 3 ppt

... which gives: ΔΤ ϭ H/[ ρ c(Q Ϫ Q s /2) ] (1) For typical petroleum oils, ρc = 1 12 lb F /in. 2 F ( 139 N/cm 2 C) and for water ρc = 32 7 lb F /in. 2 F (406 N/cm 2 C). Rather than assuming a uniform ... when system operating. Normally below 50 µm. 39 5-411 4/10/06 4:54 PM Page 4 02 Copyright © 19 83 CRC Press LLC 422 CRC Handbook of Lubrication Table 3 (continued) JOURNAL...

Ngày tải lên: 05/08/2014, 09:20

... which gives: ΔΤ ϭ H/[ ρ c(Q Ϫ Q s /2) ] (1) For typical petroleum oils, ρc = 1 12 lb F /in. 2 F ( 139 N/cm 2 C) and for water ρc = 32 7 lb F /in. 2 F (406 N/cm 2 C). Rather than assuming a uniform ... 404 Copyright © 19 83 CRC Press LLC 422 CRC Handbook of Lubrication Table 3 (continued) JOURNAL BEARING PERFORMANCE INCLUDING INERTIA AND TURBULENCE (L/D = 1.0, ββ = 160°)...

Ngày tải lên: 05/08/2014, 09:20

... support 434 CRC Handbook of Lubrication Copyright © 19 83 CRC Press LLC 428 CRC Handbook of Lubrication β = 40° (0.70 rad) γ r = 0 (no radial tilt) R 2 = 5.50 in. γ θ = 5. 82 × 10 –4 rad (0. 033 3°) R 1 = ... = 20 0 psi) ρ = 7.77 × 10 –5 lb sec 2 /in. 4 ␯ = µ/ ρ = 2. 32 × 10 2 in. 2 /sec Calculating the Reynolds and bearing characteristic numbers: Re = R ω C/␯...

Ngày tải lên: 05/08/2014, 09:20

... Stability of a viscous liquid contained between two rotating cylinders, Phil. Trans. R. Soc, Ser, A, 22 3, 28 9, 1 9 23 . 4. Coles, D., Transition in circular couette flow, J. Fluid Mech., 21 , 38 5, 1965. 5. ... McGraw-Hill, New York, 1957. 29 . Raimondi, A. A., A theoretical study of the effect of offset loads on the performance of a 120 ° partial journal bearing, ASLE Trans.,...

Ngày tải lên: 05/08/2014, 09:20

... Stability of a viscous liquid contained between two rotating cylinders, Phil. Trans. R. Soc, Ser, A, 22 3, 28 9, 1 9 23 . 4. Coles, D., Transition in circular couette flow, J. Fluid Mech., 21 , 38 5, 1965. 5. ... McGraw-Hill, New York, 1957. 29 . Raimondi, A. A., A theoretical study of the effect of offset loads on the performance of a 120 ° partial journal bearing, ASLE Trans.,...

Ngày tải lên: 05/08/2014, 09:20

... Λ, the ratio of EHD film thickness to composite surface roughness, has come into use to define the state of lubrication. Composite surface roughness, in turn, 524 CRC Handbook of Lubrication Copyright ... © 19 83 CRC Press LLC 25 m (50 to 1000 in.). Osculation clearances are normally in the range of 5 to 50 μm (0.00 02 to 0.0 02 in.). Contact Stresses The maximum principle s...

Ngày tải lên: 05/08/2014, 09:20

... hardened steel gears. They offer quiet operation, abrasion 5 42 CRC Handbook of Lubrication 539 -564 4/10/06 5: 02 PM Page 5 42 Copyright © 19 83 CRC Press LLC Volume II 533 Table 18 FAILURE MODES THAT ... illustrated in Figure 23 . 5 32 CRC Handbook of Lubrication FIGURE 23 . Subsurface nucleated spall on cylindrical bearing inner ring raceway. (Magnification × 50.) Copyr...

Ngày tải lên: 05/08/2014, 09:20

... and 121 °C (25 0°F) oil, 448 .2 kPa (65 psi), wear life in excess of 600 hr with leakage of 3. 5 × 10 −4 m 3 /sec (0.75 standard ft 3 /min), and radial unbalance force of 30 6 N/m (1.75 lb/in. )of seal ... also apply to circumferential seals. 12 FIGURE 12. Two-piece rod seal. 581- 622 4/10/06 6: 02 PM Page 594 Copyright © 19 83 CRC Press LLC 588CRC Handbook of Lubricat...

Ngày tải lên: 05/08/2014, 09:20

... experiments on the turbulent viscoseal, ASLE Trans., 13( 4), 31 1, 1970. 622 CRC Handbook of Lubrication 581- 622 4/10/06 6: 03 PM Page 622 Copyright © 19 83 CRC Press LLC In many cases, material selection ... 730 050, January 8 to 12, 19 73. Volume II 621 FIGURE 38 . Viscoseal. 581- 622 4/10/06 6: 03 PM Page 621 Copyright © 19 83 CRC Press LLC 18. Brink, R. V., The working...

Ngày tải lên: 05/08/2014, 09:20

... wear of mechanical aggregates, (in German), Schmierungstechnik, 3, 139 , 19 72. 12. Fleischer, G., Problems of reliability of machines, (in German), Wiss. Z. Tech. Hochsch. Magdeburg, 16, 28 9, 19 72. 13. ... 13, 3, 1974. 17. Bartz, W. J., Tribo-engineering as a basis for the prevention of damages of machine elements (in German), Schmiertech. Tribol., 20 , 50, 19 73. 18. Fl...

Ngày tải lên: 05/08/2014, 09:20