Mechanical Science Handbooks P2 ppt
Tài liệu Mechanisms and Mechanical Devices Sourcebook P2 pptx
... tools, and axes J5 and J6 have precision gear
drives. All process and application cables are routed through the
arm, and there are brakes on all axes.
S-900
i robots support standard I/O networks and ... place and remove parts from annealing furnaces
and punch presses, and they assemble and test electrical and
mechanical products. Benchtop robots pick and place electro...
Mechanical Science Handbooks P1 ppsx
... not all-encompassing. An attempt to present
the entire subject of mechanical science would be impractical. However, the Mechanical Science
handbook presents enough information to provide the reader ... parts.
ME-01 Rev. 0
Page 8
DOE-HDBK-1018/1-93
MECHANICAL SCIENCE
Rev. 0 ME
OVERVIEW
The Department of Energy Fundamentals Handbook entitled Mechanical Science was
prepared as an...
Mechanical Science Handbooks P2 ppt
... an engine's brake horsepower and its indicated horsepower is called the
mechanical efficiency of the engine. The mechanical efficiency of a four-cycle diesel is
about 82 to 90 percent. This ... DIESEL CYCLE Diesel Engine Fundamentals
To convert the chemical energy of the fuel into useful mechanical energy all internal combustion
engines must go through four events: intake, compress...
Mechanical Science Handbooks P3 pps
... and Control; Electrical Science; Material Science; Mechanical
Science; Chemistry; Engineering Symbology, Prints, and Drawings; and Nuclear Physics and
Reactor Theory. The handbooks are provided ... not all encompassing. An attempt to
present the entire subject of mechanical science would be impractical. However, the Mechanical
Science
handbook presents enough information to pro...
Mechanical Science Handbooks P4 pps
... plug
coated. Lift-type valves provide a means of mechanically lifting the tapered plug slightly to
disengage it from the seating surface to permit easy rotation. The mechanical lifting can be
accomplished ... be unique in their excellent resistance to certain
chemicals at high temperatures. However, the mechanical properties of any elastomeric material
will be lowered at the higher temper...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 1 pptx
... is managed by EG&G Idaho, Inc.
DOE-HDBK -10 18 /1- 93
JANUARY 19 93
DOE FUNDAMENTALS HANDBOOK
MECHANICAL SCIENCE
Volume 1 of 2
U.S. Department of Energy FSC-6 910
Washington, D.C. 20585
Distribution ... DOE-HDBK -10 18 /1- 93
MECHANICAL SCIENCE
Rev. 0 ME
FOREWORD
The Department of Energy (DOE) Fundamentals Handbooks consist of ten academic
subjects, which ... distribut...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 2 pptx
... (Cont.)
Figure 22 2- Stroke Intake 26
Figure 23 2- Stroke Compression 27
Figure 24 2- Stroke Fuel Injection 27
Figure 25 2- Stroke Power 27
Figure 26 Fuel Injector Cutaway 31
Figure 27 Fuel Injector ...
Department of Energy
Fundamentals Handbook
MECHANICAL SCIENCE
Module 1
Diesel Engine Fundamentals
Diesel Engine Fundamentals DOE-HDBK -10 18 /1- 93 LIST OF FIGURES...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 3 docx
... DIESEL ENGINES DOE-HDBK -10 18 /1- 93 Diesel Engine Fundamentals
Figure 2 Cutaway of a GM V -16 Four-Stroke Supercharged Diesel Engine
ME- 01 Rev. 0
Page 4
DIESEL ENGINES DOE-HDBK -10 18 /1- 93 Diesel Engine ... by Figure 6.
Rev. 0 ME- 01
Page 7
OBJECTIVES DOE-HDBK -10 18 /1- 93 Diesel Engine Fundamentals
Intentionally Left Blank
ME- 01 Rev. 0
Page viii
DIESEL ENGINES DOE-HDBK...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 4 pdf
... moving parts is accomplished by the engine's
internal lubricating system.
Figure 12 Diesel Engine Internal Lubrication System
Rev. 0 ME- 01
Page 13
Diesel Engine Fundamentals DOE-HDBK -10 18 /1- 93 ... is shown in Figure 13 . The excess fuel is routed
back to the fuel pump or the fuel storage tank depending on the application.
ME- 01 Rev. 0
Page 14
DIESEL ENGINES DOE-HDBK -1...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 5 pps
... valve(s)
g. Fuel injector
ME- 01 Rev. 0
Page 20
DIESEL ENGINES DOE-HDBK -10 18 /1- 93 Diesel Engine Fundamentals
Compression Ratio and Clearance Volume
Clearance volume is the volume remaining in the cylinder ... the cylinder is exerting a force of approximately 713 5 lb. or 3 -1/ 2 tons of
force.
Rev. 0 ME- 01
Page 23
Diesel Engine Fundamentals DOE-HDBK -10 18 /1- 93 DIESEL EN...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 7 pptx
... Exchangers 6
Summary 11
HEAT EXCHANGER APPLICATIONS 12
Introduction 12
Preheater 12
Radiator 13
Air Conditioner Evaporator and Condenser 14
Large Steam System Condensers 14
Summary 18
Rev. 0 Page i ... Heat Exchangers DOE-HDBK -10 18 /1- 93 TABLE OF CONTENTS
TABLE OF CONTENTS
LIST OF FIGURES ii
LIST OF TABLES iii
REFERENCES iv
OBJECTIVES v
TYPES OF HEAT EXCHANGERS 1
Introd...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 9 pdf
... cooling.
Rev. 0 ME-02
Page 11
TYPES OF HEAT EXCHANGERS DOE-HDBK -10 18 /1- 93 Heat Exchangers
Parallel flow ∆T
lm
=
(200 80
o
F) (14 5 12 0
o
F)
ln
(200 80
o
F)
(14 5 12 0
o
F)
61
o
F
Inserting the above ... 12 0°F
Counter flow ∆T
lm
=
(200 12 0
o
F) (14 5 80
o
F)
ln
(200 12 0
o
F)
(14 5 80
o
F)
72
o
F
Rev. 0 ME-02
Page 7
TYPES OF HEAT EXCHANGERS DOE-HDBK -10 18 /1-...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 10 pps
... efficiency possible.
ME-02 Rev. 0
Page 18
Department of Energy
Fundamentals Handbook
MECHANICAL SCIENCE
Module 3
Pumps
HEAT EXCHANGER APPLICATIONS DOE-HDBK -10 18 /1- 93 Heat Exchangers
To prevent the ... Hg.
Figure 10 Jet Pump
ME-02 Rev. 0
Page 16
Pumps DOE-HDBK -10 18 /1- 93 TABLE OF CONTENTS
TABLE OF CONTENTS
LIST OF FIGURES ii
LIST OF TABLES iii
REFERENCES iv
OBJECTIVES v...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 12 pptx
... positive suction head necessary to avoid
cavitation.
ME-03 Rev. 0
Page 12
CENTRIFUGAL PUMPS DOE-HDBK -10 18 /1- 93 Pumps
Mechanical Seals
In some situations, packing material is not adequate for ... liquid whose temperature is close to saturated conditions.
Rev. 0 ME-03
Page 11
CENTRIFUGAL PUMP OPERATION DOE-HDBK -10 18 /1 Pumps
Cavitation
The flow area at the eye of the pump imp...
Volume 1 Mechanical Science Handbooks DOE-HDBK Part 14 ppt
... 28
Pumps DOE-HDBK -10 18 /1- 93 POSITIVE DISPLACEMENT PUMPS
Figure 20 Diaphragm Pump
Positive Displacement Pump Characteristic Curves
Positive displacement pumps deliver a definite volume of
Figure 21
Positive ...
Rev. 0 ME-03
Page 27
Pumps DOE-HDBK -10 18 /1- 93 POSITIVE DISPLACEMENT PUMPS
The complete assembly and the usual flow
Figure 17 Two-Screw, Low-Pitch, Screw Pump
Figure...